2016 Ford F-250 SD wheels problems

Filed Sep 23, 2026 · Steering, Suspension · FL

I was driving my truck on a highway in [XXX]. I was going 70 MPH when we crossed over a bridge. The pavement was lower than the bridge cement. that cause the truck to have a slight bump when crossing over it. That cause the entire truck to begin a violent shaking (death wobble). it was very hard to control the truck. I had to step on the brakes very hard to slow down almost completely on the highway to stop the shaking. all the other traffic was trying to avoid my truck. fortunately no accidents occurred. I've spent $4000. dollars to try to fix the problem. Every time the Ford dealership says there is nothing else they can do. How long is it going to take for you to force Ford to fix or Lemon law these trucks? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 7, 2025 · Steering, Suspension · FL

Driving on highway 70 mph. Drove a rough spot on highway. Pot hole patch. Death wobble started. Had to preform emergency stop to end death wooble. This is the 10th time this has happened.

Filed Aug 14, 2024 · Steering, Suspension · FL

Death Wobble on several occasions very scary! speed over 50 mph vehicle began violently shaking had to get off roadway very dangerous almost uncontrolable!

Filed Jun 25, 2024 · Steering, Suspension · CA

The problem is commonly called "DEATH WOBBLE". The steering system enters an extremely violent wobble/shake making control of the vehicle nearly impossible. 2 independent service centers have addressed the issue. The first did repairs, including warranty replacement of a faulty part and the truck still has the "DEATH WOBBLE". The 2nd independent service center made note of the 2nd faulty replacement part (TRACK BAR) and reports "TRACK BAR BUSHING IS MOVING EXCESSIVELY. TRACK BAR SHOULD BE REPLACED." No other physical inspections have been performed. There were no vehicle warning lights due to this issue. There were a few incidences of the "DEATH WOBBLE" prior to my first appointment with an independent service center. That first appointment was approx. 2/19/2024, completed on 2/27/2024. Second time completed on 6/21/2024.

Filed Jan 4, 2024 · Steering, Suspension · FL

Increase of speed on a rough tar highway road caused a violent Death Wobble.

Filed Sep 24, 2023 · Steering, Suspension · OK

DEATH WOBBLE! Driving at any speeds from 30 MPH to highway speeds of 65-70 MPH, the front end (front suspension) of the truck will Wobble Uncontrollably in a Vehement and Violent Manner, making driving unsafe with loss of steering after hitting a small bump or dip in the road/highway. The condition is worse when pulling a 30 foot gooseneck trailer. I have replaced the front shocks, steering damper, and rear shocks and to no avail, the Death Wobble still occurs! This is Major Safety Concern and Life Threatening to myself and anyone on the road during the Death Wobble, and seeing the reaction of other drivers in the opposite direction should be cause for concern! My truck is at a dealer now for inspection of the front end suspension system (drag link, track bar, tie rod ends, ball joints, bushings, tires, and alignment), to include the engine mounts, which were worn and deteriorating (I noticed this when I was replacing my steering damper) probably from the Death Wobble. The tires were balanced and rotated on September 9th by Discount Tire and the technicians there didn't see any problems with the tires or the wheels. I get my tires balanced and rotated about every 7,500 miles and I keep an accurate vehicle history of my truck.

Filed Jan 6, 2023 · Steering, Wheels · NC

Truck was driving 70 mph going to TN when it started shaking and grinding or awful noise. Lost control of steering d/t shaking. Slowed down and pulled over to side of road to check vehicle equipment. Made call to my son who said it's the death wobble, advised to slow below 60 mph. No death wobble again unless I hit a bump then it started again.

Filed Nov 27, 2022 · Steering, Suspension · TX

Violently shaking can not control truck, I’ve looked this up and it is known as the death wobble. It looks like they have recalled /027 but not 2016 models what can be done about this. It has happened about 6 times in 3 days

Filed Sep 28, 2022 · Steering, Suspension · TX

Death wobble occurred this morning for the first time ever. It was terrifying for me and my children. I had to slam on the brakes so hard that I nearly slid off the road! The fact that Ford doesn’t acknowledge this is ridiculous. I hope and pray that this does not occur with my children in the vehicle, or while I’m hauling my horses.

Filed Mar 24, 2021 · Acceleration, Electrical · 74,000 miles · VA · crash

Vehicle was purchased from priorty ford in norfolk, va on sunday march 21st 2021. Incident #1 march 22nd 2021: front driver's tire completely blew on highway en route to tennesse an hour and a half out of gatlinburg, tn. Speedometer was also not functioning properly prior to saying we were driving a faster than actual MPH (confirmed while using GPS). Spare tire was put in place of blown out tire, changed spark plug wire (which didn't repair ticking noise per mechanic) mechanic also said we would be good to go with spare tire. Incident #2 march 24th 2021: while en route to next destination (new orleans, la) tred came off rear drivers side tire causing truck to go out of control on I-59 near birmingham, al. Vehicle spun into grass median onto opposite side of interstate and was no longer drivable. A police report was made and truck was towed. Additional information and proof via pictures and reports available upon request.**