2007 Ford F-250 problems

What is wrong

Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.

Risk

In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.

Remedy

Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1‑800‑443‑4540.

Recall number 19V238000 · Recall details

What is wrong

Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. A multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate.

Risk

Non-functioning lights could increase the risk of a crash.

Remedy

Dealers will replace the switches free of charge. The safety recall began on august 15, 2011. Owners may contact ford motor company customer relationship center at 1‑866‑436‑7332.

Recall number 11V352000 · Recall details

What is wrong

Comm trans is recalling 108 my 2005-2008 ford e250 and e350 vans built on ford chassis and equipped with ricon platform style wheelchair lifts. These lifts fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift system accessible for motor vehicles." the anti-stow interlock may not detect the presence of a wheelchair or mobility aid user. The pressure sensing switch that detects the presence of weight on the platform was not adjusted to the necessary sensitivity level. The lift could stow even though someone or something is still on the lift.

Risk

A lift occupant can be injured should the lift begin to stow unintentionally.

Remedy

Comm trans is working with ricon to correct the wheelchair lifts free of charge (please see 07e097). Owners may contact ricon at 1‑818‑267‑3000 or comm trans at 901‑726‑9394.

Recall number 09V026000 · Recall details

What is wrong

Comm trans is recalling 111 my 2005-2008 ford e250 and e350 vans built on ford chassis and equipped with ricon platform style wheelchair lifts. These vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installations on motor vehicles." the threshold warning system may not detect the presence of a wheelchair or mobility aid user in a certain spot within the defined threshold area.

Risk

The user of the lift could be injured should the lift move unintentionally.

Remedy

Comm trans is working with ricon to correct the wheelchair lifts free of charge (please see 07e095). Owners may contact ricon at 1‑818‑267‑3000 or comm trans at 901‑726‑9394.

Recall number 09V025000 · Recall details

This investigation was opened based on 78 consumer complaints of severe suspension and steering wheel oscillations after the subject vehicles traveled over an uneven surface.odi was concerned about these complaints because many of them alleged loss of control and the loss of control occurredat speeds above 50 miles per hour.at the time these complaints were received, odi was also aware of the tsb 07-10-10 and early warning field reports that discussed the shimmy condition on the subject vehicles.since opening this investigation, odi has confirmed, based on consumer complaints, warranty data, testing conducted by vrtc, and odi inspection of complaint vehicles, that the owners of the subject vehicles are experiencing shimmy events on their vehicles.however, odi has also confirmed that owners typically do not maintain their tires at the pressures recommended by ford on the tire label.further, odi has found that in order for shimmy to occur, tire pressures must be substantially below (at least 20%) those specified on the vehicle tire label.odi considers these unsafe tire conditions to be the result of one of three typical situations.the tires are being improperly maintained, the owners are intentionally setting the tire pressures low to enhance ride quality, or aftermarket tires (not designed for use on the vehicle) are installed to change the appearance or function of the vehicle.the subject vehicles are intended and designed to be used as heavy duty vehicles and as such require that the tires be capable of handling the loads for which the vehicle is designed and marketed.in order for the tires to be capable of handling these loads, the proper tire pressure must be maintained.in light of the information gathered in this investigation and ford's agreement to notify subject vehicle owners (now and every two years until the vehicles reach ten years from their production date) about the importance of maintaining proper tire pressures on their vehicles, further use of agency resources does not appear to be warranted.the closing of this investigation does not constitute a finding by the federal safety agency that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.for additional information, see the attached closing report.

EA08007

Odi has received 78 consumer complaints of severe suspension and steering wheel shimmy and oscillations commencing after the subject vehicles traveled over an uneven road surface. The majority of these incidents occurred at speeds of 50 MPH or greater.thirteen of the complaints received by odi allege loss of steering control and that the vehicle changed driving lanes uncontrollably.four of the complaints received by odi allege that the vehicle left the road surface as a result of the violent suspension and steering wheel oscillations.in one case the consumer alleges that after the vehicle left the road surface, it crashed into a wooded area.additionalfactors contributing to the opening of this ea were early warning field reports,submitted by ford, describing suspension shimmy / oscillationsand a ford tsb (07-10-10) describing the suspension shimmy issue and how to repair the problem.ford has described shimmy as self-excited oscillation of the steering wheels with accompanying wheel tramp.this pe has been upgraded to an engineering analysis (ea) to determine if the shimmy condition that occurs on the subject vehicles creates a condition where the vehicle becomes difficult to control or startles the driver, thus presenting a safety risk.

PE07057