2017 Ford F-350 SD engine problems

Filed Oct 19, 2026 · Engine · UT

This issues sounds remarkably similar to Recall 26E02 Crankcase Filter (PCV) had to be replaced due to excessive crankcase pressure. Excessive pressure caused oil cap to blow off, and caused Oil seals to fail and leaks oil (upper oil pan, passenger valve cover) Had various DPF emission related codes, and mpg had suffered considerably. Parts replaced: (Related to incident) PCV Filter Pending repairs: Dpf unit Upper oil pan seal Passenger valve cover seal Passenger Injector seal

Filed Jul 9, 2026 · Electrical, Engine · VA · fire

I am filing this complaint regarding my Ford F-350, VIN [XXX], which caught fire on XXX. The truck had approximately 130,000 miles, which I consider low mileage for a properly maintained diesel Ford F-350. These trucks are known for long service life, and many Ford diesel trucks routinely remain in service for 20 years or more and exceed 250,000 miles when properly maintained. For that reason, I did not expect a sudden and catastrophic fire in a truck with only 130,000 miles. While driving, passing motorists alerted us the truck was on fire. The fire appeared to originate in the engine compartment and spread extremely rapidly. Within a very short period, the front of the truck was engulfed in flames and sustained catastrophic damage. Based on the speed and severity of the fire, I am concerned a failure in the engine compartment, fuel system, electrical system, or another vehicle component may have caused or contributed to the fire. This truck has been well maintained, kept clean, and responsibly cared for. I followed the manufacturer’s maintenance guidelines and did not expect a sudden engine-compartment fire. After the fire, I found reports of other F-350 fires and references to fire-related complaints and investigations. This raises serious concerns Ford may have known of a potential fire risk involving these trucks. This incident created major safety hazard not only to the occupants of the truck, but to other motorists and anyone nearby. Had passing drivers not alerted us, the outcome could have been far worse. The severity of the fire required a major emergency response, including multiple fire trucks and police. A vehicle fire of this magnitude presents an obvious risk of serious injury or death. I request the federal safety agency investigate Ford F-350 and vehicle fire incidents to determine whether a defect involving the fuel system, electrical system, or related parts may cause these trucks to catch fire without warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 5, 2026 · Engine · MN

A valve spring broke on a drivers side valve.

Filed Feb 2, 2026 · Engine · VA

See attached document for complaint.

Filed Jan 9, 2026 · Engine, Fuel system · CA · fire

Driving uphill at approx 20mph near my home. Loud bang/explosion from engine or front driver-side wheel well. Red alarm flashed on instrument cluster (something like “Front Brake Failure”) and strong odor of fuel or exhaust entered cab. I immediately pulled into a pullout and put vehicle in park when I noticed flames coming from the engine compartment through the gaps in hood and wheel well. I splashed a small amount of water on the driver side front tire, but the fire continued to grow. I backed away to a safe distance and called 911. Within 5 minutes, the entire engine compartment was on fire and I captured on video explosions as the fire raged Local fire department arrived within 15 minutes, but the entire engine and cab had already been destroyed by fire. Had I been driving at high speed or with passengers, this incident could have resulted in serious burn injuries and death. Had I been driving during summer months, this incident would have caused a devastating wildfire. Had I been in traffic, I may have caused a multi-car wreck. There were absolutely no warning indicators that such a violent incident could occur. Tow truck driver said it may have been a fuel filter issue which has caused other Super Duty’s to experience sudden and catastrophic engine compartment fires. Minimal research showed me that NHSTA is investigating Ford Super Duty for this very issue. My F350 is model year 2017. I also have video of fluids dripping from the burning vehicle and the droplets are on fire which leads me to believe that leaking fuel — possibly from a cracked plastic filter — may be to blame for this incredibly dangerous incident. The vehicles remains have been searched by California Highway Patrol and the remains are currently being investigated by State Farm Auto Insurance claims experts.

Filed Dec 4, 2025 · Engine · TX · 1 injury

I have a 2017 F-350 SuperDuty with the Engine Block Heater option, two recalls have been issued related to a condition that can cause overheating of the power cord with the possibility of a fire. Recall 18V‑894 and 19V‑278 have both been applied and verified by Ford Customer Service. During the recent cold weather in the Houston, Texas area, the engine block heater was used to keep the engine warm to assist with starting. When I disconnected the power cord the was hot enough to have melted the plug to the point where the blades in the plug were loose and I had to use gloves to separate the engine heater cord from the extension cord. This should have been fixed under one or both of the previous recalls. It represents an electrical hazard that could lead to fire and loss of property. I asked Ford to remedy the situation under case XXX and they have declined to resolve the hazard. Please review this case and have Ford issue a third recall to remedy this safety issue. I have provided pictures to assist in your determination. Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 14, 2025 · Engine, Fuel system · 172,000 miles · NC

The contact owns a 2017 Ford F-350 SD. The contact stated while driving 65 MPH, the contact drove over and object on the road and the check engine warning light and several other unknown warning lights illuminated. The contact stated that the vehicle was losing motive power. The accelerator pedal was depressed; however, the vehicle failed to respond as needed. The contact stated that the engine seized. The contact was able to coast to the side of the road. The contact attempted to restart the vehicle several times; however, the vehicle failed to restart. The vehicle was towed to the residence. A mechanic arrived at the residence and diagnosed the vehicle with high-pressure and low-pressure fuel pump failures due to the metal shavings inside the fuel rail and fuel injectors. Additionally, the EGR valve was damaged. The contact was advised that the entire fuel system needed to be replaced. The vehicle was not repaired due to the cost. In addition, the vehicle was leaking engine oil while parked. The manufacturer was not informed of the failure. The failure mileage was approximately 172,000.

Filed Apr 11, 2025 · Engine, Fuel system · VA

Engine Shuts Off Upon Acceleration on the onramp to a interstate highway causing the Ford f350SD, 6.7L Diesel to come to a stop in the outside lane of Interstate I81. Engine Shutdown happened again on a 2 lane highway while passing a slow farm tractor. The problem has been confirmed by Harrisonburg Ford, Harrisonburg, VA. The high pressure fuel pump is causing metal to be distributed throughout fuel system. The complete contaminated fuel system is required to be replaced by a High Pressure Fuel Pump KIT, which the Dealer ordered against the workorder for my truck. For over a month now, My truck is parked in the dealer storage and stating they are waiting on approval to start repair. Note I have Ford's Extended Warranty. I've read online that many other owners of 6.7L Diesel trucks are having the same problems. I my opinion, a RECALL is certainly justified for this issue.

Filed Jan 21, 2025 · Engine · WA

The contact owns a 2017 Ford F-350. The contact had received notification of the federal safety agency Campaign Number: 18V894000 (Engine), and the vehicle was taken to a dealer for the recall repair. The contact stated that recently upon plugging in an extension cord into the block heater, the plug started to melt. The contact discovered black plastic on his fingers because of the failure. Upon investigation, the contact linked the failure to the recall. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was unknown.

Filed Jan 1, 2025 · Engine · AK

During recent oil change at a Ford dealership, Ford warned of an Oil Leaknon the “Upper Oil Pan” that could cause a fire and total loss. This problem was due to the improper installation of a gasket sealant at the time of manufacture. 2020 variants of the same vehicle saw the silicone gasket previously being used replaced be a conventional gasket which has rectified the issues being experienced by these models. These affected vehicles could pose a major risk not only the owners but to other motorists in the event a fire spontaneously ignites. They should be recalled and a conventional gasket (as has been implemented by Ford themselves) installed.