2022 Ford F-350 SD: false forward collision warnings

Filed Jul 6, 2026 · Driver assistance, Electrical · CA

While traveling with my fifth-wheel camper attached, my 2022 Ford F-350 Super Duty (6.7L Power Stroke) suddenly developed a complete no-crank condition. Prior to the failure, the vehicle displayed multiple electrical warnings, including U0100 (Lost Communication with PCM), High Engine Temperature, AdvanceTrac, Blind Spot System Fault, Hill Start Assist, and Pre-Collision Assist warnings. The vehicle ultimately became disabled and would not crank or start, leaving me stranded away from home while towing a trailer. Repair Description After troubleshooting the vehicle, I discovered severe internal corrosion inside the under-hood Battery Junction Box (BJB). The corrosion appeared consistent with Ford Technical Service Bulletin 23-2133 regarding moisture intrusion into the Battery Junction Box on certain 2020–2022 Super Duty trucks. I purchased a genuine Ford replacement Battery Junction Box from a Ford dealership and installed it. Immediately after replacement, the vehicle started normally and all warning messages disappeared. I retained the failed Battery Junction Box and have photographs documenting the internal corrosion. Safety Concern My concern is not simply the repair cost but the safety implications of this failure. The vehicle became completely disabled while towing a fifth-wheel trailer during travel. A sudden electrical failure affecting the Battery Junction Box can leave occupants stranded and may create hazardous situations if it occurs in remote locations or during travel. Because Ford has issued a Technical Service Bulletin addressing moisture intrusion into the Battery Junction Box, I believe this condition should be evaluated to determine whether additional action is warranted.

Filed May 11, 2026 · Acceleration, Driver assistance · NY

Charging System Fault. Caused multiple error messages like Forward camera not available, collision avoidance not available. Then Radio goes black and reboots. Several cycles later the dash board goes DARK. No speed or RPM anything visible for 5-10 secs, and on some reboots this Dark dash lasted 30 seconds. Thankfully while traveling at midnight the head lights and tail lights remain on, just no interior lights during these Reboots. New batteries made no difference.

Filed May 3, 2025 · Driver assistance · MO

I was driving on [XXX] in St Louis County Missouri during rush hours traffic. I experienced a blow out on my drivers front tire. I was surrounded by lots of heavy traffic from passenger cars to tractor trailer going more than 60 mph. I slowly got to the right shoulder. Modot and the state highway patrol blocked the traffic away from us while AAA changed my tire. After I was ready to leave I noticed my traffic early collision warning, and other safety warning systems were not working now. I also noticed my rear view camera was not operating either. This was the first time I noticed any issue with my safety systems. I got. Ew tires and changed them all 6 out. Still my rear view camera is not operating. I did notice Ford was getting ready to put in a recall for rear view camera for F350’s from 2015 to 2025. I do have a 2022 so I feel I am in the recall. Please let me know if I should go to my dealer for repairs under the recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 26, 2024 · Brakes, Driver assistance · 100 miles · GA

The contact owns a 2022 Ford F-350 SD. The contact stated that while hauling a trailer, the brakes failed to operate as needed. The vehicle was taken to the local dealer, who updated and replaced the Auxiliary Power Interface Module (APIM) several times. The vehicle was repaired, but the failure recurred. Additionally, the radio turned on without driver interaction. The contact stated that the Forward Collision Avoidance system and the mirrors were turning on and off, the crash alert was engaged, and the brake was applied without driver input. The steering wheel was vibrating. The manufacturer was contacted and declined a buyback of the vehicle. The failure mileage was approximately 100.

Filed Mar 22, 2023 · Body, Driver assistance · OR

My 2022 Ford F 350 platinum truck came optioned from the factory with the Ford winch, and collision avoidance as well as adaptive cruise control. Ford has included the collision avoidance sensor in the bracket for the winch. Ford is aware that the bracket can be distorted by the winch which disables the collision avoidance, adapative cruise, and abnormal cruise creating a safety issue. Ford refuses to correct the issue