Tl* the contact owns a 2009 ford f-650 sd. The contact stated that while driving at approximately 40 MPH, the brake pedal was depressed but the brakes failed to respond. The contact had to make a sharp left turn to avoid crashing into a vehicle. The emergency brake was activated and shifted the gear shifter into slow range to be able to continue driving the vehicle. The vehicle was taken to a dealer where it was diagnosed that a control unit failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 17,000. Updated 05/19/17*lj
The worst 2009 Ford F-650 SD problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Brakes1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Brakes1
Recalls 3
Engine and engine cooling
- What is wrong
- Ford is recalling certain model year 2008-2009 f-650 and f-750 trucks equipped with caterpillar c7 engine. The #5 and #6 fuel lines may crack at the fastening point to the common fuel rail and cause a fuel leak.
- Risk
- A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
- Remedy
- Ford is working with caterpillar to notify owners and repairs will be performed by authorized caterpillar dealers free of charge. The safety recall began on september 8, 2010. Owners may contact caterpillar toll-free at 1‑800‑447‑4986 or ford at 1‑866‑436‑7332.
Recall number 10V398000 · Recall details
Exterior lighting
- What is wrong
- Ford is recalling model years 2009 f-650 and f-750 trucks. The chassis wire harness may have been assembled without a connector seal if this seal is missing, the connector terminals may corrode affecting the proper illumination of the vehicle's rear brake lamps, tail lamps, turn signal lamps or trailer lamps (if equipped.) also, the function of the anti-lock brake system may be affected.
- Risk
- Inoperative lamps may increase the risk of a crash.
- Remedy
- Dealers will inspect the connector and repair the main and rear chassis wire harness if necessary. A missing seal will be replaced and electrical grease applied to prevent future corrosion. The safety recall began on december 16, 2009. Owners may contact ford at 1‑866‑436‑7332 or through the internet at www.fordowner.com.
Recall number 09V476000 · Recall details
Engine and engine cooling: engine: diesel
- What is wrong
- Ford is recalling 2,811 my 2008-2009 f-650 and f-750 trucks equipped with c7 or c9 caterpillar diesel engines. The fuel pump outlet check plug may be cracked which could cause fuel to spray and leak.
- Risk
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- Remedy
- Ford is working with caterpillar (please see 08e042). Caterpillar will replace the fuel pump plug free of charge. Owners may contact caterpillar at 1‑800‑447‑4986, or ford at 1‑800‑343‑5338 (fleet owners) or 1‑866‑906‑9811 (motor home owners).
Recall number 08V428000 · Recall details
Technical service bulletins for the 2009 Ford F-650 SD 26
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless...
- All accessory stick-on keyless entry keypads come with a wallet card containing the master code
- Some 2005-2017 f-super duty 4X4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit...
- Loose mounting bracket due to poor rivet retention.
- Exterior mirror
- Torqshift Transmission
- Exterior Mirror
- Ford: after rocker pedestal replacement, some diesel trucks are experiencing knocking engine, rough runs,...
- Ford: diesel engine runs rough, engine knocking, hard start, crank but no start due to height of improper...
- Ford 2009-2013 F650,F750: service information regarding diagnostic trouble codes: U041:68 and U0401:82 in...
What 2009 Ford F-650 SD owners say
Most recent owner complaints, unedited.
Compare the 2009 Ford F-650 SD
Other model years
Questions about the 2009 Ford F-650 SD
Is the 2009 Ford F-650 SD reliable?
Owners have filed 1 complaint about the 2009 Ford F-650 SD, fewer than a typical F-650 SD model year.
What is the most common problem with the 2009 Ford F-650 SD?
Brakes, with 1 complaint.
How many recalls does the 2009 Ford F-650 SD have?
3 recalls, covering engine and engine cooling and exterior lighting.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2009 Ford F-650 SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history