Purge canister valve system failure. Car sputters and wont start when gas is put into the car. Car jerks. Check engine light stays on.
2016 Ford Focus fuel system complaints
Page 3 of 9: complaints 41 to 70 of 231, newest first, as owners wrote them.
The contact’s son owns a 2016 Ford Focus. The contact stated that while refueling the vehicle at the gas station, the contact had to wait for approximately 2-30 minutes before the vehicle would start-up. The contact stated that while the vehicle was parked, the RPM revved and fluctuated from high to low. The contact also stated that while driving from a stop light, the vehicle stalled. The check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed canister purge valve. The vehicle was not repaired due the cost. The manufacturer was notified of the failure and stated a previous recall was cleared due to the vehicle passing the canister purge valve test and the power train control module was updated. The failure mileage was approximately 160,000.
My ford focus had experienced a clutch slipping and is stuck in 2 gear. The car also had antifreeze leak during this event. This occurred on January 31,2023. My Ford dealership is quoted a $3,240 repair cost for clutch system on an automatic transmission. Ford case number CXH01481389.
After receiving a routine oil change in December 2023, my vehicle began malfunctioning. The oil, engine, and battery lights came on abruptly. I returned to the Valvoline location (approx. 1 mile from my home) and they redid the oil change and noted that there were no signs of a leak and advised that I send the car to get a diagnostic done. My car stalled twice as I was driving it home. I then had the car towed to the dealership I purchased it from (Hyundai owned). They advised that an oil tensioner belt near the engine had shredded and pieces had lodged in the engine. Shortly after, the recall was released. Since then Ford has been zero help. I understand that the parts for the new belt are needed, however I need a new engine now due to their negligence. I've contacted Ford directly on numerous occasions as well as my local dealership and they won't release any information because it is in advance notice. I'm expected to wait until April or May for repairs. That will put me at almost six months or more without a vehicle and no viable options. That is not a timely fix for such a dangerous issue.
My gas tank system my engine light came on so I took my vehicle to the nearest auto zone to put on the machine and it popped up a code for a canister purge valve piece. My safety was put at risk because it was messing with my gas can’t fill my take up so I can get stranded really quick especially if I’m far from a gas station that offers my gas which is E85. No it haven’t I tried but ford claim they didn’t see no recalls in my vehicle but I have pics from other ppl of the recalls .my engine light came on I don’t remember the date but it was a while ago still didn’t get it checked out yet
Two weeks after an oil change (not by Ford) my 2016 Ford Focus 5dr EcoSport engine lost power climbing a hill outside my home. On inspection two mechanics told me it needed a new engine. $8000 for me to pay. The local Ford dealer replaced the engine and gave me a 3yr unlimited mileage warranty. No symptoms prior to the failure, now that is a recall (Campaign/the federal safety agency#23S64/23V905) I would like Ford to reimburse all of us who are out of pocket.
Vehicle will stale after driving for some time engine light shows fuel system issue similar similar to other Ford focus models.
Check engine light keeps coming on and it give error EVAP control system fault/unable to bleed up fuel tank vacuum
Vehicle hesitates, stutters and stalls when accelerating at any speed. The dealership told us it is either a transmission module or fuel module problem. They don’t have parts to fix it. There’s been a recall and a lawsuit about this same year, make and model, but they tell us our Vin is not included in any of this. it continues to do this to this day. The dealership wants us to drop it off and leave it for 3 to 4 weeks. We can’t be without a car so we are struggling with it. We wrote Ford Motor Company a letter and they told us to contact you. The lawsuit that they lost, gave us an extended warranty, but they refuse to honor it.
The contact owns a 2016 Ford Focus. The contact stated that after starting the vehicle, he observed that the vehicle was idling abnormally rough. While driving at an undisclosed speed, the vehicle lost motive power and seemed to hesitate while shifting between gears. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that the canister purge valve was stuck in the open position. The vehicle was repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline). The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown.
The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that the fuel tank was deformed due to a stuck canister purge valve. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline); the VIN was included, and the repair was already completed. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 113,000.
Have been dealing with error codes for cpv, something about fuel, and air intake. The vehicle continuously stalls. Difficult to get it to start after fueling up. Sputters at various different speeds from 5mph to about 50mph. The vehicle will totally shut down on me out of gas even at over a quarter tank to half tank full according to the gauge. I dont have dates for the incidents because they are consistent at this point.
the car shut off doing 60mph it was very scary took it to mechanic it had 2 codes the check engine light was on they cleaned the throttle body it ran but was struggling and rough idling drove to work and it wanted to stall multiple times put it in neutral to get idle up at a light then it stalled at a light drove home very afraid that it would shut off again took to the same mechanic to explain what happened have appt for estimate to fix . i need this car for work and am very scared to drive it as is never know when it will shut off called the dealer that sold me the car and all they said was theres no recalls and bring it in. i had an extended warranty but they said i was over by 1000 miles so no warranty i wont drive it there its a long drive. driving for many years i have never felt unsafe in a vehicle before this is very dangerous and needs to be resolved asap . also still have a loan for this car that i cant drive along with the repair costs my wife called ford directly and they said theres no recall and werent helpful at all
I was driving about 45 mph when my car started 2 shack and buck like it was about 2 die. So I pulled over and then it died and took forever to start back. So I took it 1 Midas and they said it was something to do with the vacuum in my gas take. So they reset the computer and told me if I had anymore issues being it back. Well today I stopped at the gas station and filled my car up and it would not start back. So I had it towed back to the shop and they pushed my gas tank flapper open 2 relief the pressure.
Issue with CPV. Car stalls when getting gas due to ventilation issue. Has manufacturer code P1450 which is recalled for similar cars
The contact owns a 2016 Ford Focus. The contact stated that the vehicle failed to immediately start up after refueling. There was no warning light illuminated. The contact also stated that the vehicle stalled without warning while driving at various speeds. Upon investigation, the contact discovered the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline). The dealer was notified of the failure and an appointment was scheduled to have the vehicle serviced. The contact was later informed by the dealer that the vehicle was not included in the recall. The manufacturer was notified of the failure, and the contact was provided a case number. The vehicle was not repaired. The failure mileage was unknown.
The contact owns a 2016 Ford Focus. The contact stated while driving 40 MPH, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined there was an excessive vacuum in the fuel system. The vehicle was not repaired. After investigating the failure, the contact related it to the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 107,000.
Having issues with the purge valve canister causing the vehicle to stall while driving on a highway late at night. Knowing that this is an issue with other vehicle made in the same year and knowing there is a recall for those parts but not on my vehicle is confusing to me.
The contact owns a 2016 Ford Focus. The contact stated while driving 65 MPH, the vehicle suddenly began to surge and shake erratically. The contact was able to exit the main roadway, after which the vehicle stalled and failed to restart. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the canister purge valve. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 51,000.
My car has become hard to start after I fill up with gas. It also randomly loses all power. While driving everything in the car stops. It displays a message that says transmission is not in park, like I turned the key off but I did not. After this it won't start and displays a message on the dash that says "system start up fault". If I wait a few minutes it starts again . This has happened 3 times. I had a mechanic pull any codes. The only code is for a gasket in the evap system. The mechanic told me that Ford had a recall for this problem so I had the car towed to a Ford service center. The Ford dealer told me that my car is not included in the recall. I looked up Ford recalls and my car exhibits all of the problems described in the recall.
Have tried repeatedly to get the CPV recall performed however all dealerships or authorized repair locations have been giving me multi month waits since it started showing the alarm code for it in Dec. 2021. Due to it being the only vehicle my family has we were out in a wait list to bring it in when they had the parts and never got called back. Now the Transaxle is not engaging 4/5/6th gear intermittently. Was informed that it would be 3K for a new transaxle even though I have not had the vehicle for that long.
Almost a year ago I noticed my check engine light came on and so I checked the codes which is P1450 - Unable To Bleed Up Fuel Tank Vacuum - Ford - Powertrain. Everytime I fill the gas tank the engine studders and fails upon startup, usually on the 3 or 4th start the engine finally idle and I'm able to change gears. I thought this was the issue that was supposed to be resolved back in 2019 when I took my car into Ford to have the recall issue fixed. Well whatever they did back then didn't fix it and looks like I'm not the only one this is happening to.
The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact used a portable scanner and retrieved DTC codes regarding the fuel rail pressure - Low. The contact’s husband replaced the canister purge valve (CPV); however, the contact stated that the failure reoccurred, and the vehicle was jerking, and losing motive power, and hesitating to restart. The vehicle was diagnosed again, and the contact retrieved fault codes for the fuel rail system again. The vehicle was then taken to a local dealer, where it was diagnosed that the fuel pump needed to be replaced. The contact's husband completed the repair; however, the contact stated that after refueling and driving at an undisclosed speed, the low fuel warning light illuminated. The contact referenced the failures to the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The failure mileage was 100,000.
The contact owns a 2016 Ford Focus. The contact stated while driving at various speeds, the vehicle lost motive power and stalled. Additionally, the vehicle stalled occasionally after refueling. The check engine warning light was illuminated. The contact was able to restart the vehicle occasionally after several attempts. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the canister purge valve remained open causing the failure. The contact stated that the failure was related to the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 79,000.
7 year old car requires full engine replacement due to lost compression. For the 2 1/2 years I've owned it 1 entire year has been spent either stranded on the insterstate or at the dealership service repair. Fuel gauge does not monitor or distrubute correct fuel available. I have spent $600 in tows to the dealership . Multiple reports/complaints have been filed against this model & year includeing with the federal safety agency. "Common problems found on the 2016 Ford Focus include the transmission shuddering, engine failures, as well as issues with the power steering system. Overall, these problems are more severe than in other compact cars, leading to expensive repair bills when parts fail" Please investigate quickly as this is safety related as well as consumer gouging
Hello this complaint is in reference to recall #18S32. I had issues with my vehicle telling me I had gas when it was really empty. The dealership got me in, said it was a recall and repaired it quickly for me, This was in 2019. The past couple months my vehicle is stalling when I get gas. It's usually always associated with me getting gas. I had some mechanics check it out and they all said it was the purge evaporator valve. They informed me to contact the dealership because there should be a recall on this issue. I contacted them and was told there isn't. So I haven't gotten it fixed because well money. I looked it up and there is a recall on that specific thing but the dealership is claiming it was "fixed" in 2019, and they cannot fix it again. I contacted ford and they told me the same thing. I'm just at a lost and concerned because I do not know who to contact or where to go from here since this issue is still tied to a recall issue that was supposedly "fixed"
Car stalled at stop sign after filling up on gas. Completely shut off. Would not start back up for 30 seconds. No check engine lights on. It has done this multiple times and I have taken it to the shop but they can’t find a problem. I know there was a recall on the 2.0 but this is a 1.0
The contact owns a 2016 Ford Focus. The contact stated that he noticed that the vehicle was experiencing excessive fuel consumption. The contact stated that after fueling the vehicle, the vehicle consumed three quarts of fuel within 20-30 miles. The vehicle was taken to the dealer, where it was diagnosed that the Canister Purge Valve (CPV) was malfunctioning, causing an excessive vacuum in fuel vapor management system. The dealer informed the contact that the vehicle could not be repaired under the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline) as the VIN was not included. The canister purge valve was replaced at the contact's expense. Additionally, the contact stated while reversing out of the driveway, the check engine warning light was illuminated. The contact stated that upon attempting to reverse out of the driveway on another occasion, the gear shifter was moved into reverse (R), but the vehicle failed to respond. The contact shifted into neutral (N) and pushed the vehicle out of the driveway. The contact was able to drive the vehicle, however, the message "Car Overheating. Stop Safely" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed that the transmission clutch was defective. The contact related the failure to the federal safety agency Campaign Number: 18V845000 (Power Train). The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 86,000.
There is a recall with Ford of 2018 Ford Focus Recall Item Affected: FUEL SYSTEM, GASOLINEDate Announced: 10/22/2018 The description of this recall is what is happening to my car, but because my vin doesn't show up they won't look at it. There are no codes, but as I turn on the car and go to drive within 45 seconds it's stalls, in traffic or wherever. I need help.
The contact owns a 2016 Ford Focus. The contact stated while driving from a complete stop, the vehicle hesitated to respond. There was no warning light illuminated. The contact stated that the failure reoccurred increasingly. Additionally, the vehicle would sometimes shudder and stall. The contact related the failure to the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline). The vehicle was taken to the dealer and the contact was informed the contact that there was a failure in communication to the powertrain control module (PCM). The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the federal safety agency Hotline. The failure mileage was 143,613.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Ford Focus?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history