2017 Ford Fusion Hybrid steering problems

Filed Oct 2, 2026 · Steering · FL

Component: Power Steering Module Rack and Pinion assembly The wheel locked up as described below in the middle of me taking a left turn, with the errors popping up as described. The problem has been diagnosed by the local Ford dealership. Three warning lamps that are intermittently on when I start the vehicle, though are not always there: Steering Assist Fault Service Required Service AdvanceTrac Hill Start Assist Not Available. While these are up, the steering wheel will not turn without incredible effort, requiring a massive amount of force to turn the steering wheel, which results in very little change in the direction the car is moving.

Filed Aug 28, 2026 · Steering · MO

The rack and pinion has failed twice within 2 and a half years. The steering has completely gone out twice while driving, causing extremely unsafe circumstances that could put multiple people in danger. After doing some research this is a common issue with Ford Fusions which is putting a lot of people in danger since it is a loss of steering issue. My wheel completely locked up while driving on the highway, how is this part not recalled yet? There are two separate safety recalls dealing with steering issues but the rack and pinion is not specifically mentioned so it is not covered under recall. This is extremely unsafe. Please look into this. Thank you.

Filed Aug 29, 2024 · Airbags, Steering · 21,600 miles · TX

The contact owns a 2017 Ford Fusion Hybrid. The contact stated while making a left turn, the steering wheel made a complete 360-degree turn; however, the vehicle failed to respond as needed. Additionally, the horn and the buttons on the steering wheel became inoperable. The contact pushed up on the steering wheel, applying a lot of pressure, to steer the vehicle while turning. Additionally, when the vehicle was started, the air bag warning light illuminated. The vehicle was not diagnosed or repaired. The contact believed that the failures were associated with the federal safety agency Campaign Number: 18V167000 (Steering). The manufacturer was notified of the failure. The failure mileage was approximately 21,600.

Filed Mar 6, 2024 · Steering · 100,000 miles · PA

The contact owns a 2017 Ford Fusion Hybrid. The contact stated that the steering wheel had fractured. The contact stated that due to the failure, the steering wheel had an abnormal up and down movement. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Filed Aug 7, 2023 · Brakes, Steering · SC

While traveling down the road, suddenly the steering gets hard to turn and the antilock brake system goes out. Usually, you can correct the problem by stomping on the brake or turning the car off and back on. Several warnings come up including Advancetrac failure. It’s a very dangerous situation when your power steering goes out while traveling down the road. This same issue has occurred more than 5 times.

Filed May 2, 2023 · Steering · TX

The steering wheel has been loose for a couple years and seems to be getting worse. There is a lot of play in the steering wheel. I know there have been recalls on other models and it seems like my car is affected as well.

Filed Oct 18, 2022 · Steering · GA

I had just left my sons school and was on my way to pick up my daughter. In the middle of making a left turn into oncoming traffic, my steering wheel locked on me making it hard to complete the turn. Cars were approaching from both directions and honking at me to get out the way. I looked at the dash and noticed a message saying service advance trac. Then another came on saying no bill start assist. Then the traction lights came on. I was able to safely move out the way. I had 2 mechanics look at it. One said it was the steering rack and another said the electronic steering wasn’t communicating with the cars computer system. The one that said the communication was off plugged the car into some type of gadget and the car was working fine for a month or so. Then it happened again. I need my car but I am also afraid to drive it because of this.

Filed Mar 4, 2022 · Steering · 125,000 miles · CA

The contact owns a 2017 Ford Fusion Hybrid. The contact stated while making left or right turns, the contact noticed a lot of play in the steering wheel. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the bolt inside the steering wheel to be tightened. The vehicle was not repaired. Upon investigation, the contact associated the failure with the federal safety agency Campaign Number: 18V167000 (Steering) however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 125,000.

Filed Jul 7, 2020 · Steering · 80,000 miles · NV

Bought the car used from hertz. Steering wheel is extremely loose and has lots of play when guiding the wheel. Recalls for this problem but not my VIN.

Filed Apr 7, 2020 · Steering · PA

Tl* the contact owns a 2017 ford fusion hybrid. The contact stated that while driving at low speeds, the steering wheel loosened without warning. The vehicle was taken to chapman ford of columbia (3951 columbia ave, columbia, pa 17512) where they inspected the vehicle and tightened the bolts around the inside of the steering wheel. Months later while reversing the vehicle into the driveway, the failure recurred. The vehicle was taken back to chapman ford. The vehicle was diagnosed and inspected. The vehicle was repaired but could possibly happen again. The manufacturer was notified of the failure. The failure mileage was unknown. *ln