2023 Ford Maverick Hybrid: multiple warning lights

Filed May 4, 2025 · Driver assistance, Engine · TN

While traveling 80 MPH using cruise control, the vehicle speed suddenly reduced and several warning lights illuminated. The three warnings were Pre-Collision Assist Not Available, Service Engine Soon Warning, and Powertrain Malfunction / Reduced Power. The accelerator pedal did not work but I was able to coast to the nearest exit. I stopped, turned the vehicle off and back on a few times but the warning lights would come back on. When I shifted the transmission into Drive the vehicle would take off on its own. I drove the remaining 30 miles just letting the vehicle accelerate on its own because the pedal did not work. It wouldn't accelerate over 35 MPH. The vehicle would still pull when I applied the brakes. Once home, I turned the vehicle off for an hour. When I turned it on the warning lights no longer illuminated and the vehicle drove normal.

Filed Jul 21, 2024 · Electrical, Fuel system · NC

Driving at approximately 65 miles per hour. Vehicle suddenly went into neutral I was forced to pull over on a busy highway. The dashboard was illuminated with several warning lights and messages. After one key cycle, I was only able to drive in a limited limp mode. After a second key cycle and waiting a few minutes, I was able to drive like normal but an engine light stayed illuminated.

Filed May 27, 2024 · Electrical · CA

Saturday [XXX] picked up maverick from dealer service at 11:00 am. Vehicle was reprogrammed for current recall, dash board was replaced, and oil change. After about 40 miles of driving the vehicle electrical systems shut down completely while driving on a busy 6 lane Blvd.. All systems went out nearly causing a collision. All warning lights and notices flashed quickly as the truck died. The last message told us to contact 911. Vehicle rolled a few more yards allowing us to get on a smaller side street before it came to a complete stop. Vehicle would not start or move. I had it towed back to the dealer at 5:00 pm. Service department closed Sunday and Monday [XXX]. Vehicle was left in an unguarded lot as instructed by sales manager on duty. I will be able to contact service department when they open Tuesday morning. This was a very serious event which could have easily lead to major injuries. We have planned a 1200 mile trip to Idaho this coming weekend to assist with family health issues. Now we will feel unsafe in our Maverick and can not use it due to our safety concerns. Now on line I see several reports of the same serious issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 6, 2024 · Acceleration, Engine · TX

Vehicle's engine suddenly cut out during driving ~15 mph. Multiple warning lights flashed. Vehicle ran on battery and was able to go at slow velocity but then transitioned to accelerating when pedal was not engaged. Hazard lights would shut off suddenly after driver turned them on. "Limp mode" is commonly used term for what happened.

Filed Apr 30, 2024 · Acceleration, Engine · GA

Approximately around [XXX] a.m, [XXX], I was on my way to on the [XXX] . I was going driving around 75-78 mph when all of sudden my 2023 Maverick drop in speed and power suddenly. I looked at my dashboard and saw mph dropped to around 50. I had no knowledge of what was taking place at the time. I tried to press my acceleration pedal and the mph still was dropping, so I managed to get over to the far right lane so I could get to the shoulder. During this event several warning lights flashed, such as check engine soon, crash assist not available, power train malfunction ect. I turned the vehicle off and back on - it still had the same messages- I managed to drive the 5-10miles I had left on my route to work @ 33mph. Once at safe location I contacted a tow truck to haul my vehicle to Hennessey Ford for diagnostic and answers. I've never had any of these issues to take place since owning my truck. Never experienced Loss of power ever in my life. This is truly a event that has left me stunned and wondering will this truly be taken care of and addressed. It's a constant reminder in my head and and it also has prompted me to thank God for my life as well as others because if I hadn't left home to go to work about 30mins earlier than normally due to the traffic which would be pretty thick I may not be here today to tell this story, because there was no warning whatsoever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 25, 2024 · Electrical · 7,000 miles · TX · 1 injury

The contact owns a 2023 Ford Maverick. The contact stated that while starting the vehicle, the contact observed a loud exploding noise coming from the speakers. Additionally, the contact stated that when the vehicle was turned off, she observed a loud crackling noise emanating from the radio. The contact stated that several lights on the instrument panel flashed on and off. The contact sustained ear injuries. Medical attention was not sought. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 7,000.

Filed Apr 19, 2024 · Acceleration, Engine · TX

Vehicle lost power while driving at highway speed. Pulled over and restarted vehicle. Vehicle proceeded to accelerate without driver input. Multiple warning lights/systems activated including: POWERTRAIN MALFUNCTION / REDUCED POWER; SERVICE ENGINE SOON WARNING; PRE-COLLISION ASSIST NOT AVAILABLE. Similar to issue described in the federal safety agency Campaign Number: 24V267000

Filed Apr 18, 2024 · Engine, Transmission · CA

Travelling around 60-70mph on the highway when a warning appeared saying there is a powertrain issue and engine issue. This forced my truck into low gear and I lost the ability to accelerate. This forced me to pull to the side of the highway with no acceleration capabilities which is highly dangerous. Multiple warning lights remained on the dashboard. This first event occured on Mar 10 2024, then happened AGAIN on April 12 2024.

Filed Apr 16, 2024 · Driver assistance, Electrical · OH

I was driving down the road at roughly 45 mph when all of the sudden my car went into neutral I was no longer able to accelerate. I was in the middle of a four-lane road with a traffic light coming up in cars coming from the opposite direction. I happen to be very lucky and right next to the Ford dealership when this happened, but this could be a major safety issue as others would not be so fortunate when vehicle was thrown into neutral. All the dash lights came on the check engine light came on. Wrench icon popped up on the instrument cluster as my car began to slow down as I pulled over once I got to roughly 5 mph the parking break engaged and came to a screeching halt. I was not able to disengage the parking break and could not move the vehicle into the drive position anymore. As stated before I was right next to the Ford dealership when this happened so I walked over and talked to the service center, they didn’t see any errors on my vehicle so I walked back to it started it up and the only remaining light was the check engine light and I was able to drive it over to the Ford dealership at which point the gentleman said he was able to see the errors. I have done a lot of reading online and this is called limp mode but is doing nothing to acknowledge this or proactively fix this on vehicles. From my understanding, this issue does not happen until after there are recalls done on the vehicle. I took my car into the shop at 9200 miles. Had it serviced for an oil change at which point Ford did two service recalls and now I’m experiencing this issue

Filed Apr 12, 2024 · Brakes, Driver assistance · PA

All of a sudden, in the rain while driving home, suddenly the (Drive) Shift knob light was flashing, warnings started flashing, hill start assist not available, service vehicle soon, pre collision assist not available, service advance Trac, and parking brake applied automatically and total loss of power…. I almost got into an accident in the rain and traffic because the people driving behind me were going fast and my truck just suddenly lost power and I had those cars coming from behind that had to swerve out of my way. I managed to get it pulled off to a side street and turned it off and back on and still had no power and all the lights/warnings were still on. When you press on the gas, it wouldn’t go…. No throttle response. Could not go. Almost in an accident and it could have been worse if this happened with more traffic.

Filed Mar 26, 2024 · Electrical, Engine · OK

While driving the following warnings all came on: Gear Selected Will Engage at Low Speed Powertrain malfunction/reduced power Pre-collision assist not available Service engine soon warning Service AdvanceTrac Hill assist not available Vehicle came to a stop and parking brake automatically engaged. Driver could not control acceleration, gas pedal had no control, and vehicle moved on it's own under electric power. Vehicle would continue accelerating, and the only want to try to control speed was used the brake. Symptoms persisted for several drive cycles, until all the warning lights went off (except for checking engine light), and vehicle went back to normal. After several more drive cycles the check engine light went off. This is the third time this potential life threatening issue has occurred. Dealer has not been able to resolve the issue.

Filed Mar 19, 2024 · Acceleration, Electrical · TX

Was traveling at around 60 mph and multiple lights and warnings came up on the dash “powertrain malfunction” and “service advancetrac”. Power was reduced to a limp mode and I was forced to pull over on the highway. This happened within a week of having multiple software recalls carried out by a ford mobile technician. I was able to reset the codes with an obd scanner and haven’t had an issue since but I have read about this happening to multiple people with the same hybrid vehicle after having these recalls done.