2023 Ford Maverick Hybrid engine problems

Filed Oct 14, 2026 · Engine, Suspension · CA

I’ve been noticing that when I am on the freeway and I am increasing my speed to highway speed and between 55 mph to 65 mph the vehicle vibrates like possible suspension issue. This morning at about 2:13 AM when I had just got to a stop sign and my foot was physically on the break. I noticed that the engine revved up so because I was concerned I made sure I stayed where I was with my foot on the break until the engine came back down to the proper idle.

Filed Jun 1, 2026 · Engine, Transmission · TX

Eninge started knocking, flashed warnings to pull over immediately. I did and had the vehicle towed to Westway Ford in Irving. Their investigation showed the engine needs a full rebuild and they are claiming it is not covered under warranty. They shared pictures & a written repair estimate. Doing an analysis of the pictures they took and their description of what happened, combined with what I experienced and observed, this appears to be a textbook case of the behavior and outcome of the mechanical failure described in recall 23S27.

Filed Mar 18, 2026 · Engine · 45,300 miles · PA

The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was a fuel odor on the exterior and interior of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a fractured fuel seal. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The contact was informed that a diagnostic test was needed to determine the cause of the failure. The dealer declined to provide a free diagnostic test. The contact referenced the notification of the federal safety agency Campaign Number: 23V380000 (Engine); however, the VIN was not associated. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 45,300.

Filed Mar 17, 2026 · Engine · TX

Per the dealership my vehicle is throwing the same codes P1061 and P032F as the recall that is less than a month from when my vehicle was built. My vehicle knocks and then the speed drops to less than 35 miles and it happened to me in traffic. It is very dangerous and again this is the same issue as the recall for my 2023 that is for other 2023 vehicles. I have called Ford to get help and file a complaint but am getting zero help. Again this is a very dangerous event that is happening and could cause damage not only to my vehicle but to others. I have to work so driving the vehicle is my only option right now and I can't afford the $9,000 to fix something that is a Ford issue. Please review and have Ford pay for the safety issue they already know they have. Thanks

Filed Dec 2, 2025 · Acceleration, Engine · MI

AUTOMATIC REVVING INCIDENT 1 DATE: November 25, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Slight rain, around 37º F VEHICLE STATUS: In Park, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. ICE engine immediately turned on and revved all the way, as if the accelerator pedal was pressed down all the way. Pedal was NOT under floor mats. Immediately turned key to off position, let sit for a moment. Turned key to on position again and issue seemed to be resolved. No check engine lights or other codes were showing on the dash cluster. AUTOMATIC REVVING INCIDENT 2 & 3 DATE: December 2, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Clear, around 27º F VEHICLE STATUS: In drive, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. Heat was on. Immediately turned dial to “D,” and engine proceeded to again rev all the way up. However, this time, full power was transferred to wheels, causing vehicle to attempt to lunge forward. Luckily, I was on an icy patch of the road, and the tires spun instead of gaining traction. I immediately slammed the brakes and turned the car off. Waited about 2 minutes and then turned key to on position, and the exact same thing happened again. No check engine lights or other codes were showing on the dash cluster. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 5, 2025 · Electrical, Engine · GA

This exact situation has occurred twice in the past 6000 miles driven. Both occurred while driving at highway speeds, once on I85N and once on I75N in GA. Our 2023 Ford Maverick XLT Hybrid suddenly and unexpectedly loss power and shutdown. This forced us to make an emergency stop and attempt to pull over in high speed, heavy traffic in both instances. The vehicle eventually restarted and was drivable with a check engine light illuminated. The DTCs were read with an OBDII scanner and were recorded as P0811, P0E71 and P1920. The first time this occur the vehicle was taken back to Ford under warranty and they said they reprogrammed the PCM and another control module and assured us it was repaired. Obviously that is not the case. The vehicle is currently with Ford being diagnosed. Please follow up on this one. We're not the only Maverick Hybrid owners to have this unfortunate and very unsafe experience. This situation of a vehicle suddenly dying in heavy traffic is going to get someone killed. Thanks in advance for your consideration in this matter. We would like a better explanation from Ford besides "We reprogrammed a computer".

Filed Oct 31, 2025 · Engine, Fuel system · GA

The car have a Big vibration when speed up over 45 MPH

Filed Aug 20, 2025 · Engine · 80,000 miles · WA

The contact owns a 2023 Ford Maverick. The contact stated that while driving approximately 65 MPH, the check engine warning light illuminated, and the "Service Engine Immediately" message was displayed. The contact stated that the vehicle started losing motive power. The accelerator pedal was depressed, but the vehicle decelerated to 5 MPH. The contact stopped and had the vehicle towed to a dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The contact stated that the failure reoccurred. The contact used a handheld scanner and retrieved DTC: P1061 (Faulty Rod Bearing). The vehicle was towed to the same dealer, but the dealer was unable to duplicate the failure. The vehicle was not repaired. The contact stated that the failure reoccurred, and the vehicle was towed to the same dealer where it was determined that the long block needed to be replaced. The vehicle was not repaired. The contact spoke with a mechanic and was informed that the failure was related to Customer Satisfaction Program: 23N06 (Long Block Replacement). The manufacturer was contacted for confirmation that the vehicle was covered under the CSP; however, the contact was informed that the vehicle was not covered under the CSP. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 80,000.

Filed May 4, 2025 · Driver assistance, Engine · TN

While traveling 80 MPH using cruise control, the vehicle speed suddenly reduced and several warning lights illuminated. The three warnings were Pre-Collision Assist Not Available, Service Engine Soon Warning, and Powertrain Malfunction / Reduced Power. The accelerator pedal did not work but I was able to coast to the nearest exit. I stopped, turned the vehicle off and back on a few times but the warning lights would come back on. When I shifted the transmission into Drive the vehicle would take off on its own. I drove the remaining 30 miles just letting the vehicle accelerate on its own because the pedal did not work. It wouldn't accelerate over 35 MPH. The vehicle would still pull when I applied the brakes. Once home, I turned the vehicle off for an hour. When I turned it on the warning lights no longer illuminated and the vehicle drove normal.

Filed May 3, 2025 · Electrical, Engine · GA

2023 Ford Maverick Hybrid XLT lost all engine power at highway speed in the left lane of [XXX] . Red Warning Triangle with notice to pull over and Check Engine light with codes P0811, P0E71 and P1920. Truck then went completely dead, no electrical indication on the instrument panel and would not start. I towed it to the dealer and they said they reset and reloaded software on the PCM and BCM, but no explanation of what caused the issue to occur. Very unsafe for everyone if these hybrid vehicles can just go dead like this with no warning and no prior issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)