2023 Ford Maverick Hybrid transmission problems

Filed Oct 1, 2026 · Electrical, Transmission · CA

Bad CV axel causing shimmy and vibration while driving. The vibration makes the uneven tire wear, replace 4 tires around 21,000 miles. Battery getting low message all the times causing dangerous while driving.

Filed Sep 29, 2026 · Transmission · NY

Front axles are defective. Causes severe vibration under load. Dealer repaired under warranty however this is a wide spread issue and a recall should be issued. 2023 Maverick LXT 44K miles.

Filed Aug 24, 2026 · Transmission · TX

Truck started to shake when accelerating past 50 mph. The shaking would stop once the speed limit was reached and you let off the accelerator. Web search results showed 2022, 2023 & 2024 Ford Maverick hybrids are known for CV axle failures with those symptoms. Vehicle was around 48,000 miles. Dealership replaced both CV axles under the 5 year/60,000 mile warranty.

Filed Aug 12, 2026 · Transmission · NC

At around 27K miles the two front CV axles began to fail. I brought it to the Ford dealership and they confirmed that both needed to be replaced. It was a $1600 repair. There have been a lot of complaints from Ford Maverick owners who have had CV axle failures at very low miles on their vehicles. These parts typically last 100K to 150K miles and it's not unusual for them to last the lifetime of the vehicle. There is no reason both front CV axles should be failing with 27K miles on a vehicle. This should be covered by a recall.

Filed Jul 28, 2026 · Transmission · NY

Significant disruptive vibration upon acceleration at high speeds due to premature failure of front CV Axles. Confirmed failure of both axles by manufacturer at approximately 61,000 miles.

Filed Jun 21, 2026 · Electrical, Transmission · NJ

12 volt electrical system no power. Dealer changed battery cable wiring harness. Received vehicle back. One week later vehicle exhibited no 12 volt power. Informed that it could be the Thinkware dash cam. Which was purchased from Ford and Ford dealer installed. Now informed that it could be the dash cam itself. The dash cam was installed via the OBD port which is always powered. This will drain the 12 volt battery unless vehicle is driven for extended periods. Ford is aware of the issue but no remedy for over 3 weeks. I have told the Ford dealer to have the dash cam installed so that when the ignition is on the dash cam is also powered on and off when the ignition switch is turned off. Using this method negates the parking mode on the dash cam. Another issue is when the drivers side door is opened the interior lights do not activate. Ford notified. Problem not resolved. Low 12 volt battery issue?

Filed Jun 1, 2026 · Engine, Transmission · TX

Eninge started knocking, flashed warnings to pull over immediately. I did and had the vehicle towed to Westway Ford in Irving. Their investigation showed the engine needs a full rebuild and they are claiming it is not covered under warranty. They shared pictures & a written repair estimate. Doing an analysis of the pictures they took and their description of what happened, combined with what I experienced and observed, this appears to be a textbook case of the behavior and outcome of the mechanical failure described in recall 23S27.

Filed May 17, 2026 · Transmission · LA

While driving the vehicle at low speed (roughy 25mph) a loud sqeek was heard. This occured a few more times so I stopped to inspect. I countinued my trip after not finding the source of the noise. When it occured again, I pulled into a parts store and had them run codes. After finding none I purchased a code scanner so that I could monitor while under way. Once on the highway the sound became more frequent, after just a few miles warning lights appeared on my dash and the vehicle had a complete loss of power. I was able to coast to the side of the road. At that time the vehicle did have code P1061. Dealer diagnosted the truck with a failed transmission. I removed the trasmission and disassembled it. The main shaft had been stripped of it's splines on the gear that connects to the engine. I have a video of the gears and shaft here: [XXX] I saved the parts and will be happy to provide them for investigation if needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 19, 2026 · Transmission · CA

Both front CV axles on my 2023 Ford Maverick Hybrid are failing at approximately 60,000 miles. The vehicle experiences violent shaking and vibration during acceleration, most noticeably at speeds above 30 mph and on inclines. The shaking is severe enough to affect steering control and reduce driver confidence, particularly during highway merging and uphill acceleration. The problem was diagnosed and confirmed by San Leandro Ford dealership, which identified both front CV axles as defective and in need of replacement. No warning lamps or message appeared prior to or during the issue. The vehicle is available for inspection upon request. This appears to be a widespread manufacturing defect. Numerous owners of 2022-2023 Ford Mavericks have reported identical premature CV axle failures at mileages ranging from 10,000 to 60,000 miles, as documented in online forums and prior the federal safety agency complaints. Some owners have had axles replaced multiple times. The defective CV axles pose a safety risk as the severe vibration compromises vehicle control during normal driving conditions.

Filed Mar 20, 2026 · Transmission · 17,000 miles · CA

The contact owns a 2023 Ford Maverick. The contact stated that while driving 5 MPH and making a right turn, the vehicle lost power, and the transmission slipped into neutral(N). While driving 25 - 30 MPH and approaching a red light, the transmission slipped into neutral. The contact associated the failure with the federal safety agency Campaign Number: 24V330000 (Power Train) and 25V133000 (Power Train). The local dealer was contacted and confirmed that the VIN was included in the recalls. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 17,000.