While driving highway speeds the vehicle suddenly lost power. Had to immediately pull to the shoulder of the highway with heavy traffic that got very close to my rear bumper due to the sudden decrease in speed. There was no advance warning of power loss. Upon stopping on the shoulder the vehicle was put in park and the key turned to the off position. After a short wait the ignition key was turned to the on position and was able to resume trip at highway speeds. Notified Ford close to my location and it was checked for fault codes and road tested with no defect found., Now concerned that the vehicle might fail again day or night leaving us stranded or causing a vehicle accident due to the sudden reduction in speed.
2023 Ford Maverick Hybrid transmission complaints
Page 2 of 5: complaints 11 to 40 of 114, newest first, as owners wrote them.
I am reporting a premature and dangerous failure of the front CV (Constant Velocity) axle assembly on my 2023 Ford Maverick. While driving at 50 mph the vehicle began experiencing violent, uncontrollable shaking and shuddering in the front end, particularly under acceleration. This is an issue which affects all Mavericks for this model year. Ford has recalled/reimbursed replacements for the 2022 model year but not other ones yet. This failure causes significant instability and compromises steering control, creating a high risk of a crash when merging into traffic or maintaining highway speeds. The vibration is severe enough to distract the driver and could lead to a total loss of motive power if the axle snaps or the joint fully separates.
When driving at higher speeds (60-70mph) and needing to pass another vehicle the clutch slips which triggers the accelerator to shut down. Leaving you helpless in the passing lane. All you can do is hope there is space to safely pull off the road and shut the engine off. This puts it in limp mode.
AUTOMATIC REVVING INCIDENT 1 DATE: November 25, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Slight rain, around 37º F VEHICLE STATUS: In Park, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. ICE engine immediately turned on and revved all the way, as if the accelerator pedal was pressed down all the way. Pedal was NOT under floor mats. Immediately turned key to off position, let sit for a moment. Turned key to on position again and issue seemed to be resolved. No check engine lights or other codes were showing on the dash cluster. AUTOMATIC REVVING INCIDENT 2 & 3 DATE: December 2, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Clear, around 27º F VEHICLE STATUS: In drive, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. Heat was on. Immediately turned dial to “D,” and engine proceeded to again rev all the way up. However, this time, full power was transferred to wheels, causing vehicle to attempt to lunge forward. Luckily, I was on an icy patch of the road, and the tires spun instead of gaining traction. I immediately slammed the brakes and turned the car off. Waited about 2 minutes and then turned key to on position, and the exact same thing happened again. No check engine lights or other codes were showing on the dash cluster. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The 2023 Ford Maverick Hybrid is experiencing a recurring safety failure of the Front CV Axle Shafts. The vehicle exhibits violent, uncontrollable shaking of the front end during acceleration at highway speeds (40–65 MPH). This severe vibration compromises vehicle stability and steering control, creating a significant safety risk during merging or overtaking maneuvers. The vehicle was previously repaired for this exact issue by an authorized Ford dealer on May 30, 2024 (at ~32,000 miles). However, the failure has recurred 18 months and 33,000 miles later. Inspection of the current failed parts reveals that during the 2024 warranty repair, the dealership installed obsolete, superseded part numbers (Series "NZ", specifically NZ67-3B436) instead of the updated, corrected design (Series "SZ") released by Ford to fix this known defect. Because the dealership replaced defective parts with the same defective/superseded design, the safety hazard has returned prematurely. The defect was previously confirmed by a dealer technician. The current failure is confirmed by visual inspection of the part labels showing the obsolete "NZ" code. No warning lights appeared prior to failure; the symptom is immediate mechanical vibration under load.
I had been driving for 2 hours on the interstate when the truck starts losing power and warning lights start flashing. I got the truck to the shoulder before it slammed to a stop. I turned the engine off and waited until all the power turned off before restarting. The truck would only run in limp mode at 35 mph. I drove on the shoulder of the interstate to the next exit. I disconnected the battery and reconnected which allowed me to drive it normally to the dealership. After two days the dealer called to say they didn’t see any codes and there wasn’t anything wrong with it even after I sent pictures of the warning messages. This is the 5th time this has happened under similar circumstances.
This exact situation has occurred twice in the past 6000 miles driven. Both occurred while driving at highway speeds, once on I85N and once on I75N in GA. Our 2023 Ford Maverick XLT Hybrid suddenly and unexpectedly loss power and shutdown. This forced us to make an emergency stop and attempt to pull over in high speed, heavy traffic in both instances. The vehicle eventually restarted and was drivable with a check engine light illuminated. The DTCs were read with an OBDII scanner and were recorded as P0811, P0E71 and P1920. The first time this occur the vehicle was taken back to Ford under warranty and they said they reprogrammed the PCM and another control module and assured us it was repaired. Obviously that is not the case. The vehicle is currently with Ford being diagnosed. Please follow up on this one. We're not the only Maverick Hybrid owners to have this unfortunate and very unsafe experience. This situation of a vehicle suddenly dying in heavy traffic is going to get someone killed. Thanks in advance for your consideration in this matter. We would like a better explanation from Ford besides "We reprogrammed a computer".
PREMATURE CV axle failure due to regenerative braking. This cause violent wobble leading to the death wobble
At 20k miles the vehicle starts shaking back and forth and rattling while accelerating and I brought it to the dealership and its being serviced under warranty to get both front CV axels replaced. It was shaking so badly and vibrating the whole vehicle, the dealership told me it was unsafe to drive when they saw how badly the axels failed. There were no warnings or check engine lights. Especially dangerous because it doesn't shake at low speeds only when accelerating and at high speeds.
Truck shakes when accelerating and limits acceleration and safety. Belief is the CV axles failing.
Vehicle started shaking during acceleration above 40 mph. Felt like the wheels were going to come off. The issue is that the front axle drive shafts are very corroded and failing.
At approximately 37,000 miles, the CV axles on my 2023 Ford Maverick Hybrid required replacement due to premature wear. Now, at around 62,200 miles, the vehicle is experiencing excessive vibration and shaking during acceleration, particularly noticeable at moderate to high speeds. This issue appears to be related to the powertrain or suspension system and may indicate a recurring or unresolved problem with the CV axles or associated components. The vibrations are severe enough to affect vehicle control, especially during lane changes or merging onto highways. When accelerating to merge into highway traffic, the vehicle shakes and vibrates so profusely that it feels like the car is going to shake apart. This makes it difficult to accelerate normally and safely, putting both the driver and surrounding vehicles at risk. The shaking could lead to loss of traction or steering instability, increasing the likelihood of an accident. This issue has been widely reported by other Ford Maverick owners and has been a frequently discussed problem in forums and owner communities for over a year. Despite its prevalence, there appears to be no long-term fix other than replacing the CV axle assembly with the same OEM part, which may be the root cause of the problem. That is why I feel it is important to bring this to your attention — it is a known issue with no real correction, and it continues to affect vehicle safety. No warning lights or messages appeared prior to the onset of the problem. The component is available for inspection upon request.
Both front axles had to be replaced at 62000 miles. Just about of fords power train warranty. Have read multiple issues of these trucks having the same problem.
2023 Maverik Hybrid at around 30,000 miles Vehicle would start shaking while accelerating. I took it to the dealership and they had to replace all the components in the front end of the truck. I know have about 60,000 miles on the vehicle and I'm having the same shaking problem while accelerating. It looks like this is a common occurrence with this vehicle. It is no longer under warranty and is going to cost a lot to get fixed. Not excited about having a major repair every 30,000 miles.
Cv axles went out at 55k causing shaking at highway speeds while accelerating. Frequently when starting the car the steering wont activate right away even after the car begins to move for 5-10 feet. Dealer cant replicate because it doesnt happen every time. But it is still doing it and may cause a crash in the future....
The contact owns a 2023 Ford Maverick Hybrid. The contact stated while driving 65 MPH, the vehicle unintendedly decelerated to 35 MPH while driving downhill and decelerated to 6 MPH while driving uphill. The message "Engine Repair" was displayed, and the power train warning light was illuminated. The vehicle was taken to the dealer, where the diagnostic trouble codes were cleared; however, the vehicle was not diagnosed or repaired. The contact stated that the PCM was previously updated under an unknown recall in 2024; however, the failure recurred while driving. The vehicle was taken to Maguire's Ford of Hershey, Inc. (100 N Thistledown Dr, Palmyra, PA 17078); where the diagnostic trouble codes were cleared; however, the vehicle was not diagnosed or repaired. The contact related the failure to the federal safety agency Campaign Number: 25V158000 (Power Train, Electrical System); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the dealer and to the federal safety agency Hotline for assistance. The failure mileage was approximately 400.
The front of the vehicle started shaking with acceleration. This shaking became worse and vehicle was unsafe to drive. The vehicle was brought to ford dealership and they will be replacing the front half shafts and brackets.
On Tuesday, [XXX], my wife and I were driving her, new to her, 2023 Ford Maverick Hybrid XLT, that we purchased from Stuckey Ford in Bellefonte, PA on [XXX]. She was behind the wheel. We were heading west on [XXX] and had just passed into Pennsylvania by crossing the Delaware River. The check engine light and battery lights went on suddenly & we immediately lost power. The power steering was no longer working, but the brakes were. As we were in the passing lane going 65 mph & there was an 18-wheeler in the right lane, we could not cross two lanes to reach the Matamoras exit ramp. She steered into the median between lanes to our left. The Maverick would not start. We were about 6" off the left hand white line of the west bound passing lane. I called 911 who sent a PA State Trooper to park behind us with his flashers on. We were towed off the [XXX] exit ramp to a garage. We tried to start the truck five times, it would not start. The sixth time it did start but when the tow truck operator tried it, the truck only started intermittently. We called the nearest Ford Dealer, Healy in Goshen, NY. We were towed to Healy the same afternoon. They said their diagnostics could find no problems. Their invoice is attached. Since the event on [XXX], the Maverick has not turned on when the key is turned & brake pedal depressed multiple times. When this happens the same two lights (check engine & battery) stay on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
On acceleration from a stand still or in motion, the vehicle will start to shake/wobble pretty violently. It will go away when letting go of the gas. Seems to be coming from the front end wheels. Going under the car and checking all connecting points, the CV axle has a lot of play. You can move it around.
While traveling 80 MPH using cruise control, the vehicle speed suddenly reduced and several warning lights illuminated. The three warnings were Pre-Collision Assist Not Available, Service Engine Soon Warning, and Powertrain Malfunction / Reduced Power. The accelerator pedal did not work but I was able to coast to the nearest exit. I stopped, turned the vehicle off and back on a few times but the warning lights would come back on. When I shifted the transmission into Drive the vehicle would take off on its own. I drove the remaining 30 miles just letting the vehicle accelerate on its own because the pedal did not work. It wouldn't accelerate over 35 MPH. The vehicle would still pull when I applied the brakes. Once home, I turned the vehicle off for an hour. When I turned it on the warning lights no longer illuminated and the vehicle drove normal.
2023 Ford Maverick Hybrid XLT lost all engine power at highway speed in the left lane of [XXX] . Red Warning Triangle with notice to pull over and Check Engine light with codes P0811, P0E71 and P1920. Truck then went completely dead, no electrical indication on the instrument panel and would not start. I towed it to the dealer and they said they reset and reloaded software on the PCM and BCM, but no explanation of what caused the issue to occur. Very unsafe for everyone if these hybrid vehicles can just go dead like this with no warning and no prior issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I am experiencing a serious safety issue with my 2023 Ford Maverick Hybrid, which involves powertrain malfunction and sudden loss of power while driving. The issue first appeared on [XXX], when I received a Powertrain Malfunction / Reduced Power warning in the FordPass app and noticed that the vehicle was losing power intermittently. Since then, I have taken my vehicle to the dealership three times for diagnostics and repairs, but the issue persists. Service history and failed repair attempts: [XXX] – I visited Folsom Lake Ford to address this issue, but the dealer claimed the vehicle was “operating normally.” [XXX] – I took my car to Future Ford of Sacramento, requesting diagnostics and repairs for the transmission. The dealership replaced the CV axles but did not acknowledge or resolve the powertrain issue. [XXX] – The same error occurred again, and I returned to Future Ford of Sacramento. The dealer once again failed to find or fix the problem. [XXX] – Hours after picking up the car, the Powertrain Malfunction / Reduced Power error reappeared in FordPass. Possible Link to Known Ford Maverick Issues: Ford has already issued recalls for similar problems affecting Ford Maverick (2022–2023) and Bronco Sport models related to 12V battery failures that cause power loss. However, my VIN is not included in any official recall, despite showing the same symptoms. This issue is extremely dangerous, as the vehicle unexpectedly loses power while driving, creating a serious risk of an accident, especially on highways. Suspected Fraud by the Dealer: Despite multiple service visits, the dealership has not provided a detailed diagnostic report. I suspect the dealer is simply resetting the error codes instead of fixing the problem. Investigate whether this is a widespread issue among 2023 Ford Maverick models. Determine if Ford should issue a recall for this powertrain problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The truck shutter when accelerating. The truck currently has 39,000 miles. It seems like it’s a suspension problem.
Car was shuddering and vibrating on acceleration brought to dealership and was told I needed front axles with 16k on odometer . It took over a month to get parts and the dealership was kind enough to give me a car while Parts came in. These new parts are Likely also faulty as the vibrations are starting again under acceleration .The car now has 29k I will be bringing the car in again soon for other recalls and repair but this shouldn’t be happening . Heaven knows what other damage is being done . We need a part redesign and a recall asap . Thanks
CV axles both going bad at 50,000 miles
While driving down US-69, while attempting to pass a vehicle at about 80 mph, the vehicle shut off and proceeded to stop accelerating, as well as started to slow itself down. The instrument cluster flashed quickly before shutting off, and the radio also shut off. The cabin lights came on, and I had to switch to the right lane to quickly get onto the side of the road where it gradually slowed itself down and threw itself into park. I had taken the key out, and simply turned it back on, and everything seemed to work as normal after the fact. There were no indicators that this would happen, it was sudden and almost caused me to get rear ended by a semi truck.
My Maverick had to have both CV joints replaced at 18,000 miles. Bad shaking vibration when accelerating. I told Byers Ford of vibration they said both CV joints needed replacement. I was told this is a common problem with Mavericks.
Loss of motive control ongoing issue. This is documented problem being investigated by NTHSA, R2Q4014. Functional issue: • Engine flips into Neutral unexpectedly. Vehicle coasts to a stop, where it flips into Park on its own. • Vehicle requires a restart to move gear out of Neutral. After restarting vehicle, vehicle can operate on limited power that maxes out at about 35 mph. Acceleration is dramatically reduced, gradually ramping up as the vehicle continues to drive — the acceleration pedal does not control speed. Coming to a complete stop while driving with the vehicle in this reduced power mode requires another gradual ramp up to speed, making typical street driving difficult because it may take 30-45 seconds for the vehicle to ramp up to adequate speed (ramp from zero to 35mph), frustrating other drivers behind he vehicle who may think the slow speed is intentional. • After the vehicle has sat powered down for a number of minutes, it can be started up again at full power. I have seen this refractory period as low as 15 minutes and as high at 45-ish minutes. This issue has happened to me multiple times, 9 as of last count. Ford has attempted a fix twice now, and the issue persists. I would be happy to discuss full experience and how Ford has responded, or rather not responded, with your investigative team. Thank you for looking into this issue.
Upon accelerating from about 40 to 50 mph violent shaking was occurring , took to dealership CV axels were found to be the problem and were replaced at 17,000 miles now at 29,000 miles they are doing the same thing and need to be replaced again took to dealership waiting on new CV axels to be replaced again
On 1028/24, driving at approximately 55 mph in the right lane of a local highway, the front collision braking system engaged almost totally stopping my vehicle. There were no vehicles, animals, nor pedestrians in front of my vehicle. I was able to pull to the shoulder. The collection detection icon appeared on the screen, as well as the check engine light, and the wrench. Then a message saying collision warning system unavailable, then service vehicle immediately. The drive gear dial remained in drive (D) position and was flashing. From there, with my warning light activated, I was able to get the vehicle to go up to 25 mph in order to drive to the Ford dealership nearby. I was told by the service department that they operate on appointments only, I would "try to look at it soon." The Ford Pass App states a powertrain malfunction, pre-collision assist not available, and service engine soon warning. Even if the system resets itself when vehicle turned back on, it is totally unsafe to drive in traffic not knowing if these systems will unexpected fail again, causing an accident and injury. I understand that this problem has occurred with other drivers on this model in the recent past.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2023 Ford Maverick Hybrid?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history