2005 Ford Ranger suspension problems

Filed May 15, 2020 · Body, Suspension · 57,000 miles · MA

The leaf spring bushings pushed threw the rotted frame and poked holes in the bed of the truck .the spare tire was hanging on the ground when I got home one day. Now my inspection station wont put a inspection sticker on it because they say its to dangerous.toyota had this problem and ether repaired the vehicle or replaced it.

Filed Oct 22, 2019 · Suspension · 58,000 miles · MA

The leaf spring shackles rotted threw the frame and the spare tire holder dropped the spare tire while driving this is dangerous

Filed Aug 1, 2019 · Suspension · 59,000 miles · MA

Tl* the contact owns a 2005 ford ranger. While driving approximately 35 MPH, an abnormal noise was coming from the rear of the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that both leaf spring shackles were rotting through the frame and needed to be repaired. The vehicle was not repaired. The dealer and manufacturer were not contacted. The approximate failure mileage was 59,000.

Filed Jun 1, 2019 · Suspension · 59,000 miles · MA

The repair shop informed me my leaf spring shackles could not be repaired due to severe rot of the frame in the rear.truck only has 59000 miles on it and was well taken care of.the rest of the truck is in very good shape. This should not happen is there a recall I dont no about? Thankyou

Filed Apr 21, 2019 · Body, Suspension · 117,000 miles · NY

The passenger side rear shackle rusted completely off and the leaf spring almost went through the bed of the truck. The truck was not drivable until the passenger side rear shackle was replaced. This was discovered after driving over a bump in the road, hearing a loud bang and experiencing a jolt. Once parked the truck was completely looked over, which lead to more discoveries. A giant rust hole has formed in the frame behind the shackle on the driver's side rear area of the truck. This truck has been well maintained throughout the years and was professionally under coated a couple years ago with no holes in the frame or visible rust at that time. The frame has deteriorated rapidly. Luckily I did not try to tow anything with this truck because the rear part of the frame likely would have been ripped off, losing what was being towed and potentially causing an accident. There is also a large hole forming in the bed of the truck.

Filed Apr 12, 2019 · Suspension · PA

Severely rusted frame. While the spare tire has not fell off yet, I had the truck up on a rack at patrick airforce base to change the oil. I've known for a while that the frame is bad. The truck only has 81,000 miles on it, but looking at the frame, it won't last much longer.

Filed Aug 1, 2018 · Body, Suspension · 160,000 miles · MA

Frame rotted away in the back side, rear leaf springs fell off, spare tire ready to fall off.

Filed Jun 29, 2018 · Body, Suspension · 65,000 miles · MA

The under carriage of my vehicle has a lot of rust underneath and on the dorrs I have seen a few complaints not sure if this is safe or not

Filed Aug 12, 2017 · Body, Suspension · 146,000 miles · KY

The frame under the truck especially the rear is literally rusting away. The cross members that hold the fuel tank are severely rusted and over halfway gone on the right side of the vehicle.

Filed Jul 17, 2017 · Body, Suspension · NJ

Vehicle has 37850 miles looks like new and the frame has rotted away spring hangers and the complete frame itself you can put your fingers through it and gas tank straps also gone