2002 Ford Windstar tires problems

Filed May 25, 2018 · Tires, Transmission · 72,000 miles · NJ · fire

Tl* the contact owns a 2002 ford windstar. While driving 45 MPH, the tire warning indicator illuminated and smoke emerged from the rear of the vehicle. The contact called lilliston ford at (888) 397-9172 (833 n delsea dr., vineland, nj 08360) and was advised that the failure could not be repaired without a diagnosis. The vehicle was not taken to the dealer for diagnostic testing or repairs. The manufacturer was not notified. The failure mileage was 72,000.

Filed May 3, 2016 · Tires · 2,300 miles · TN · crash · 2 injuries

Windstar ford 2002 tires they just keep going down very quick no holes had a blow out an wrecked into a tree with these tires bad tires ended up seat belt cut my neck an seat belt cut my 1 year olds testacles

Filed Sep 5, 2013 · Tires · 105,000 miles · IN

Goodyear assurance touring tires dot lot identifier: mdxo jd1r 4109 size: p225 60 r16 purchased at sam's club, december 2010. I got four (4) of these tires on my 2002 ford windstar van, on december 23, 2010. Early in 2011, ford had my van for six (6) months (fixing several ford recalls with axles and suspension) so the tires didn't get much mileage until later in 2011. In 2012, I had one of the tires separate into chunks on the highway. There was no other damage, except the tire was history. I had it replaced with another tire of the same type/model. In july of 2013, I had two (2) more of the tires replaced because they were "cupping" and out of round. I had the van checked for camber, caster, and toe-in, and it was up to factory specs. No alignment necessary and tires were maintained with correct pressure. Today, (09/05/2013) I am having the 4th tire replaced, because it is becoming "out of round" and "cupping" (I believe). This failure causes a vibration that you would not believe. The last time sam's club replaced the tires (just two months ago in july 2013) the installer said that they "have had a lot of these tires spontaneously destroy themselves", and they opted to put goodyear assurance "fuel max" tires on, in lieu of the discontinued "touring" model. I checked goodyear's website, and the "touring" model is in fact, not discontinued. Maybe sam's club just stopped getting them because they're tired of replacing them? If sam's club has no confidence in the touring model (and is opting to replace them with the fuel max model) I am beginning to think that the last touring model tire (replaced in 2012) may destroy itself, as well.

Filed Nov 21, 2008 · Electrical, Tires · KY

While driving my 2002 ford windstar se van, the ABS, brake, trac control light comes on. I have had the unit checked and there are no codes in the computer and all seems fine. I have read about faulty parts and leaks resulting in fires. Also, my cruise control light does not light up any more. Sometimes it's working and I don't even know. The low tire pressure stays on. I had mechanic check it out and reset the sensor but it comes back on in a few days.

Filed Aug 16, 2008 · Suspension, Tires · 70,000 miles · OH

My 2002 ford windstar started riding really rough. The tires were checked and seemed to be fine. The back end of the van seemed to be riding very rough and my mechanic though it might be a strut issue. As it turns out, the rear axle broke completely in half while my father in law drove my two young children on the highway. What a scary experience. I've checked on the internet for similar experiences. Others have had this happen to them as well. This issue needs to be addressed by ford and should be a recall issued.

Filed Jun 30, 2008 · Tires · VA

My wife has a minivan that I had the tires replaced on within the past two years. I purchased a set of 4 high quality michelin tires with 75k warranty from sears at fair oaks mall in fairfax, va. Earlier this year my wife had a blow out and I took the vehicle back to sears for them to inspect the tire. Once they removed the tire there was no indication of a puncture anywhere on the tread or sidewall - I was a tire repair technician back when I was in college. I asked the technician why the tire would have blown if there was not a puncture, he didn't have an explanation. I asked if that should be covered under the manufacturer warrant and they seemed unwilling to help. I ended up buying another tire for $150.00. Then just this weekend as I was driving I heard a hissing sound coming from the left front tire. When I got out of the vehicle I noticed the tire was leaking air from the valve stem. I took the tire in to have the valve stem replaced and they mentioned to us there has been a recall on valve stems. I believe the previous incident was also caused by a valve stem issue since there was no other indication of a puncture. I'm planning to have all of the valve stems replaced on the remaining tires so that my wife will not suffer a blow out with our 3 children in the van. I think there needs to be a greater campaign on this issue to increase awareness as it could potentially impact all 4 tires on a vehicle.

Filed Jun 28, 2008 · Tires · VA

I purchased new 4 tires from sears auto center in dulles, va on 1/46/07 which they installed on our 2002 ford windstar. My wife, 3 year daughter and myself were traveling on interstate i81on 4/24/08 with this ford windstar experienced a front passenger side tire blow out. It was a good thing I was the driver and not my wife as this could of been tragic!! I quickly pulled it on the highways shoulder after traveling at 70 MPH. I replaced the blown tire with the temporary spare. We then proceeded to have it replaced. The sears auto center in winchester, va told us they did not carry that exact tire and did not have one with the same speed rating and can not legally install one the doesn't match the rest. We needed to get home to our two children who were coming home from school, therefore, we were forced to purchase two new tires along with fees associated with doing so. We didn't know what caused this tire blow out and the sears technician was baffled as he said he found no holes or puncture in the blown tire. The two front tires are now new and the two rear tires were still in place from the original 4 tire purchase on 1/6/07. On 6/12/2008 we experienced a sudden loss of tire pressure on the passenger side rear tire and the tires valve stem was hissing from a sudden crack that had formed. I had the stem replaced at walmart in front royal, va. On 6/27/08 I had the last of the original tires have a sudden valve stem failure causing instant pressure loss. I was now suspecting the valve stems must have a major flaw and requested that the walmart technician give me the failed valve stem after he replaced it. After I returned home from getting this repaired, I researched on the internet for any tire valve stem recalls and I discovered the tech international recall under your investigation campaign id 08t018000. I have saved this remaining stem with the part number dill-acp tr413 on the base.

Filed Jun 12, 2008 · Brakes, Tires · 180,000 miles · AL

Abs light and tire pressure light are constantly coming on. This has all been checked and there doesn't seem to be anything wrong with either. Cruise stopped working while driving with it on. I have now read many reports from consumers with the same ford winstar with the same problems. The cruise control concerns me because of the recall of the cruise control switch on one of their trucks and the incidence of fires started because of the cruise control switch in the ford winstar vans.

Filed May 22, 2008 · Acceleration, Brakes · 80,000 miles · NY

I have a 2002 ford windstar that we purchased 2 yrs ago, ...morning after delivery battery was dead, took back to dealer and they checked it out and said should be fine. Occasionally still dies and has to be charged, alternator & battery check out fine. The most dangerous problem is that the ABS light is on and ABS doesn't work properly. We continuously have to add brake fluid (at least once a month) and can not find any leaks on the ground. Had the vehicle in for service on several occasions can not diagnose. The dealership hooked vehicle up to machine to read code and can not get any readings from system. Dealership seemed to think that it could be a wiring problem or ABS module. Abs will occasionally go out/work but not properly, ABS will kick in on dry roads not wet/snow covered. Tire pressure light is illuminated and tire pressures are all correct. Has been reset but comes back on after driving a few miles. Occasionally it will go out on its own but then the speedometer will bounce around (if going 55 will jump to 70,80). When opening the rear tailgate hatch and closing,the dash light stays on like it is still open and dome lights will not work properly. When driving the door chime will sound and the door ajar light will go out and works properly until gate is opened again. When driving the door light and chime will come on lights stay on. The door ajar light also comes on and off intermittently when using the driver side door controls to put windows up/down you hear louder then normal clicking. Also dims the lights when putting windows up/down. We can also smell what seems to be wires burning at times but can not find anything. We are at a loss of where to begin. We will not drive this vehicle any further then 50 mile radius from our home for fear of what will happen if we do. If we go further we rent a vehicle. Now to the point of purchasing a cheap, reliable vehicle (not ford) and parking this one until we can pay down enough to trade in.

Filed Apr 13, 2007 · Suspension, Tires · 100,000 miles · 00

1. Driving in good conditions, on highway 25 going north, 2 miles north of highway 5. Saturday the march 31, 2007 at 2:00 pm. 2. Suspension spring failure, front driver's side with busted tire. 3. Parts replaced and repairs made at my cost.