2018 GMC Sierra 1500: engine stalls while driving

Filed Jun 2, 2026 · Brakes, Engine · NJ

Incident description: On three occasion I have had the same catastrophic Engine failure putting myself and my family along with the general public in harms way. Starting March of 2022 while driving at approximately 60 MPH on the West Shore Expressway my truck experienced a sudden and total loss of motor power. My engine stalled out and I lost my ability to safety steer and stop my vehicle. This all happened during rush hour while driving in the left lane of traffic. This sudden loss of power forced me to maneuver the vehicle to the right shoulder of the expressway across the right lane of traffic. As there was no shoulder to pull over on the left side of the highway. This created an immediate crash risk for myself and other drivers. Upon inspection at the authorized GMC dealership where I purchased the truck new, a certified mechanic determined that the engine experienced a complete failure requiring replacement or rebuilding of the engine. I paid to have the engine rebuilt at the dealership. The second instance was similar to the above incident. Once again I paid for the repair. The third instance was more dangerous as when my trucks engine failed it almost caused an accident. As of today my truck is still sitting in the dealership for over 6 months and no one from the dealership or manufacturer will give me an answer on what has to be done now. This patter of sudden repeated engine failure clearly indicates a systemic safety defect that extends beyond normal wear and tear. I urge the federal safety agency to open a defect investigation into the 2018 GMC Sierra 1500 engine systems.

Filed Jun 12, 2025 · Engine, Fuel system · 133,742 miles · TN

The contact owns a 2018 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed and depressing the accelerator pedal, the vehicle failed to accelerate as intended. The message "Reduced Power" was displayed, and the RPMs increased. Additionally, the vehicle jerked, and the contact noticed that there was smoke coming out of the exhaust pipe. The vehicle was driven to the contact's residence. The vehicle was taken to an independent mechanic, where it was diagnosed that the starter, the battery, the fuel pump, the oil pump, the oil pump sensors, and the fuel injectors had failed and needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that while driving at an undisclosed speed, the vehicle stalled. There was no warning light illuminated. The vehicle was able to restart; however, the failure recurred. The vehicle was driven to the contact's residence. The vehicle was not repaired. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 133,742.

Filed Jun 5, 2025 · Electrical, Engine · TX

Engine lifters failed. Heard ticking noise first day truck was purchased that gradually got louder but was told by gmc service shop it was normal to hear the ticking noise. Also when cruise control is on and you are decending a hill the rpms raise and you lose engine compression this will cause your speed to drop to around 20 mph and has happened nunerous times.. as well when making a turn sometimes or just driving the vehicle turns off while in motion and you have to coast to the side of the road and turn the key off and back on to start driving agsin.. the loss of power is a complete blackout no dash.. no engine nothing. As result of the lifter issue the engine also hard shifts in and out of slow gears.. I have not driven my truck in about a year and still owe 22k on it. The issues with this vehicle are the same as the recalled 6.3 v8 engines.

Filed Apr 3, 2025 · Driver assistance, Electrical · CA

While driving my truck and making low speed turns the dashboard (including center console) cuts off, along with my power steering. The truck has also shut off completely making u-turns causing me to almost crash. This also happened while driving around 60mph on the freeway, the entire dashboard went out, loss of steering, and truck shut off, almost causing an accident. When it does happen, it will cut out in 1 second intervals and steering will work again for 2 seconds then cut out again for 1 second, this causing me to stall. There are no check engine lights, or service lights that stay on. However, I will get a message stating: You are memory setting 3 in the system (wording may be different). In some cases the stabilitrak light will come on, the park assist warning stating it shut off comes on dash, and trailer break. I have a full service AUL warranty and had vehicle checked at certified dealership and no codes were recorded. I replaced battery and the problem is still happening. This is unsafe and should be part of the previous recall as my symptoms are the same exact symptoms as the other 2018 recall.

Filed Feb 5, 2025 · Transmission · AR

Knocking, stalling, shaking, lost of power and steering problems. Serviced transmission twice and I was advised to serve every 30000 miles!!! I owned several types of vehicles but I never heard such things before. Technician told me that apparently many GMC customers reported same problems.

Filed Oct 29, 2023 · Electrical, Engine · FL

The electric power steering failed while accelerating into a turn from a stop at an intersection. The wheel was jerked from my hands, and the engine stalled, all electrical failed momentarily. Within a couple of seconds everything returned to normal. This has happened several times since I purchased this vehicle. Also the electrical power steering drops out quite often at low speeds, such as in parking lots. No warnings have ever been given. In May of 2021 the dealer replaced the steering rack, the problem has continued intermittently to this date. I have researched for recalls on this problem and found that GMC issued a recall for years 2014-2017, and am amazed that they could just declare the problem fixed, and leave such a dangerous problem unresolved!

Filed Jun 17, 2021 · Steering, Transmission · 47,184 miles · IL

The contact owns a 2018 GMC Sierra 1500. The contact stated while driving at various speeds, the vehicle lost power steering assist causing the steering wheel to become firm. The steering wheel jerked while turning and the vehicle stalled on several occasions almost causing a collision. The vehicle was taken to the dealer and the dealer informed the contact that the failure was related to Technical Service Bulletin 18-NA-161. The vehicle was not repaired. The manufacturer was made aware of the failure. The manufacturer promised to provide a callback. The failure mileage was 47,184.

Filed Sep 13, 2020 · Engine, Fuel system · 35,692 miles · AZ

After long periods of running and idle, vehicle stalls out has a hard time restarting. Gas paddle being press helps sometimes. Check code p2635 plus others (random secondary codes), come on. This has taken place in az where the ambient air temperature typically is over 100. Vehicle has been to gm dealer who says its vaporizing the fuel in the lines. Tsb pip5507b dose not include 2018, however the design hasn't changed. Conditions; long idle, hot weather, low speeds under 25 MPH or idle. Location; az sonrona dessert, off-road, jobsite, city streets.