My 2022 Honda Civic Sport is affected by the federal safety agency Safety Recall 24V‑744 (Honda Campaign SJS) for the steering gear. On SXXX, an authorized dealership (Honda City Chicago) officially diagnosed my vehicle with an "INTERNAL FAILURE CAUSING A KNOCKING TYPE OF SOUND" within the steering rack assembly, indicating it requires a complete replacement estimated at $4,680.27. Despite having an open recall for this exact steering gear defect, Honda Corporate (Case Manager [XXX], Case #XXX) formally denied covering the repair, falsely claiming that the problem is not covered and that the vehicle is out of warranty. The vehicle experiences a permanent knocking noise when turning the steering wheel from a stop. This defect has caused severe, uneven, and premature wear on all 4 tires (Walmart purchase less than a year old), completely destroying them and making the vehicle lose alignment immediately after service. Honda is refusing to perform the mandatory safety recall repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Honda Civic knocking problems
74 of the 16,048 owner complaints about the Honda Civic describe engine knocking or ticking, most of them for the 2022 model year.
- owner complaints
- 74
- worst model year
- 2022
- typical repair cost reported
- $1,700
- typical mileage
- 60,000
By model year
Often reported together
Steering noise 5Jerking 5Engine failure 4Whining noise 2Steering lock-up 2Shudder 2Premature wear 2Ball joint 2
What owners say
My 2022 Honda Civic has developed an intermittent sticky steering condition. The steering wheel becomes difficult to turn around the center position and requires additional force before it moves normally again. This occurs during normal driving and makes it difficult to maintain smooth and predictable control of the vehicle. I am concerned that this could increase the risk of losing control, especially if an emergency steering correction is needed. In addition, I hear a knocking/tapping noise coming from the front of the vehicle whenever I turn the steering wheel at low speeds. The vehicle has never been involved in any accident, collision, or steering-related damage. There are no warning lights displayed. The problem developed during normal use and has become repeatable. The vehicle has not yet been diagnosed by a Honda dealership, but based on the symptoms and numerous similar owner reports involving 2022 Honda Civics, I believe this may be related to a defect in the steering system. I am submitting this complaint because I believe this is a potential safety issue and request that the federal safety agency investigate.
Steering wheel makes clicking noise and becomes difficult when making small adjustments . After holding the steering wheel steady for a few seconds, there is increased resistance when trying to turn from the center position. Once the resistance is overcome, the steering suddenly moves more than expected, which can cause overcorrection. In addition, there is a clicking, light ticking, or binding sound when turning the steering wheel.down
I am reporting a severe steering safety defect on my 2022 Honda Civic that matches the symptoms of the federal safety agency Campaign Number 24V‑744 and Honda TSB 23-037.At highway speeds (40–70 mph), the steering wheel "sticks" or "notches" in the center position. To make small lane adjustments, I must apply significant force to "break" the wheel loose. This causes the car to jerk or overcorrect, creating a high risk of a collision. Additionally, there is a metallic clicking/knocking noise coming from the steering rack during low-speed maneuvers.I have contacted Honda Corporate, but they denied a repair because my specific VIN has not yet been uploaded to the 24V‑744 recall database, despite the vehicle exhibiting the exact manufacturing defect (swollen worm gear/high friction) described in the recall. The vehicle has approximately 62,000 miles and the issue has been persistent since 40,000 miles.I am requesting that the federal safety agency investigate why my production batch is excluded from the current recall despite having an identical steering gearbox failure that renders the vehicle unsafe to drive.
Knocking sound from engine
I am the owner of a 2023 Honda Civic Sport equipped with a CVT transmission (Honda M-CVT). While the transmission has not yet failed outright, I am reporting a serious safety and consumer risk created by the design and business model surrounding these units. Honda CVTs are sealed, non-serviceable by design. Dealerships and third parties are unable to replace individual internal components or inspect wear inside the CVT without replacing the entire unit. The fact that Honda refuses to sell parts for these CVTs essentially makes them disposable powertrains. This creates a dangerous precedent ans owners cannot plan for long-term ownership or safety. CVTs in these cars often fail outside of warranty with no prior warning, and consumers are left without options other than full replacement, which many cannot afford. I am reporting this as a safety issue because when these CVTs degrade, they: Hesitate when accelerating from a stop (which has happened to me) Cause unpredictable power delivery Create unsafe situations during merging or turning Honda’s refusal to allow proactive service or repair (such as belt inspection or internal cleaning) forces owners to operate on faith, which is not acceptable for a mission-critical safety component like a transmission. This is compounded by the fact that these CVTs are installed across Honda’s most affordable trims, affecting working-class people disproportionately. Dealerships confirm no individual repair options exist. The issue is “normal” until failure. Transmission fluid changes are the only service allowed. Occasional hesitation and inconsistent acceleration. No dashboard warning lights have been triggered. This is a case of planned obsolescence leading to unavoidable safety risk. This design forces cars to enter the used market with a major mechanical failure already ticking down. This is a case of planned obsolescence leading to unavoidable safety risk.
The contact owns a 2022 Honda Civic. The contact stated while driving at various speeds, the steering wheel was shaking with an abnormal ticking sound coming from the steering. There was no warning light illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,000.
Jerking/sticky steering issue. I have heard many other drivers discuss the same with 2016-2023 Civics. Essentially anytime when I am driving, my car may jerk any direction and I have to re-adjust. This makes driving EXTREMELY dangerous. I have noticed similarly to other drivers that whenever my steering jerks in one direction when I turn it back, it makes a knocking noise (like knocking on wood). Very concerned about this issue as I don’t have any money to fix it.
The contact owns a 2022 Honda Civic. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking, rattling, and ticking sound coming from under the hood. The vehicle was drifting and shaking. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who determined that the failure was due to the pulley and power steering. The vehicle was taken to another independent mechanic, who scanned the vehicle and retrieved codes for the EPS malfunction power steering. The driver's side front and rear tires were replaced. The contact received notification of the federal safety agency Campaign Numbers: 24V744000 (Steering) and 23V704000 (Steering); however, the part to do the recall repair was not yet available. The local dealer was contacted. The dealer completed the recall repair of the federal safety agency Campaign Number: 24744000 (Steering). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 100,000. Parts distribution disconnect.
Went to my local dealer on January 11 to have my car checked due to a possible knock in my engine or transmission. They checked it but was not able to find a code or the actual cause after changing the oil of transmission and running it. It still continues to have issues They told me “might need to leave your car overnight because their master technician is not here until Monday “ To me I didn’t like much that answer because I spend too much for a no fix or cause. Also they could not provide me a loaner as well which was not a good idea No codes in the system or lights in the dashboard , it started a day before I took it to the shop
Related recalls
Engine and engine cooling: engine
- What is wrong
- Honda (American Honda Motor Co.) is recalling certain model year 2016 Civic vehicles manufactured September 22, 2015, to February 3, 2016 and equipped with 2.0L engines. The affected vehicles have engines with piston assemblies that may have been manufactured without a piston wrist pin circlip or with an incorrectly installed piston wrist pin circlip.
- Risk
- If a circlip is missing or incorrectly installed, the piston wrist pin may not be secure and may drift and damage the engine cylinder causing the engine to seize, and increasing the risk of a crash or a fire.
- Remedy
- Honda will notify owners, and dealers will inspect and replace the piston assemblies and damaged engine components, as necessary, free of charge. Parts are expected to be available in the Summer of 2016. Owners were mailed an interim notification beginning March 31, 2016, and will be mailed a second notice when parts are available. Owners may contact Honda customer service at 1‑888‑234‑2138. Honda's number for this recall is JX9.
Recall number 16V074000 · Recall details
Engine and engine cooling: engine
- What is wrong
- Vehicle description: passenger vehicles. During the assembly process, the air cleaner box cover may have been damaged, and a broken plastic piece could travel into the intake chamber.
- Risk
- If the plastic piece lodges in the throttle body, the throttle could stick in a partially open position. Although the driver can always stop the car by applying additional brake force, or by taking other actions (I.e., shift into neutral, turn off the ignition key, etc.), if the car continues to maintain speed when the driver is expecting it to slow, a crash could occur.
- Remedy
- Dealers will inspect the air cleaner box for damage. If damage is found, the dealer will locate and remove the broken plastic piece, and replace the air cleaner box lid. Owner notification began on october 25, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact honda at 1‑800‑999‑1009.
Recall number 01V329000 · Recall details
Questions about the Honda Civic knocking
Which Honda Civic years have engine knocking or ticking problems?
The model years with the most reports are 2022 (10 complaints), 2006 (6 complaints) and 1999 (5 complaints).
How much does it cost to fix engine knocking or ticking on the Honda Civic?
Owners who mentioned a price put the repair at about $1,700 (median of 6 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Honda Civic?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history