Honda CR-V windshield crack problems

Filed Nov 2, 2026 · Visibility · GA

I purchased this vehicle new on July 25, 2026. In roughly three months of ownership, the windshield has been damaged three times by small road debris during normal highway driving. The first damage was repaired by Safelite through my insurer. The second and third occurred within weeks of that repair. During the most recent inspection, Safelite also identified additional cracks along the perimeter of the windshield that had not been noticed and did not appear to originate from a visible impact. My previous vehicle, a 2025 Honda HR-V, was driven on the same routes by the same drivers for about two years and never sustained a chip or crack. The frequency of damage on this CR-V suggests the windshield glass or its design is unusually susceptible to chipping and cracking. A cracked windshield impairs driver visibility and can affect the windshield-mounted Honda Sensing camera that controls lane keeping and automatic emergency braking. I am requesting that this be recorded as a potential defect in the windshield glass on the 2026 CR-V.

Filed Oct 27, 2026 · Visibility · OH

I am reporting a potential windshield safety defect involving my 2026 Honda CR-V EX-L AWD, leased new on June 30, 2026. Within approximately four months, I experienced two separate windshield cracks, both developing near the edges of the glass. The original factory-installed windshield developed a crack near its edge and was replaced by Safelite through Progressive Insurance in September 2026. Approximately six weeks later, the aftermarket replacement windshield also developed a crack near its edge. I did not observe any rocks or other objects striking the windshield immediately before either incident. However, Safelite subsequently identified a small impact point on the replacement windshield and denied warranty coverage. The precise cause of the repeated cracking remains unknown. I brought the vehicle to an authorized Honda dealership for evaluation. The service representative briefly examined the windshield visually but did not take the vehicle into the service bay or perform a detailed inspection. I was informed that the aftermarket windshield was not covered under Honda's warranty. The original windshield is no longer installed. The replacement windshield remains on the vehicle and is available for inspection. My safety concern is that repeated windshield cracking could compromise visibility and potentially affect the windshield's structural integrity. I have encountered reports from other Honda owners describing similar windshield issues, although I cannot confirm whether the causes are related. I am requesting that the federal safety agency document these incidents and evaluate whether there may be an underlying issue involving windshield stress, installation, or vehicle body structure. No manufacturing defect has been confirmed.

Filed Jun 29, 2026 · Visibility · IL

Windshield cracked without any trauma being done to cause it to crack. This is the second Honda CRV windshield to crack spontaneously

Filed May 15, 2026 · Visibility · SC

Formally lodging a complaint regarding a severe manufacturing defect in my newly purchased 2026 Honda CR-V and to demand an immediate windshield replacement under the New Vehicle Limited Warranty. I purchased this vehicle less than six months ago. It currently has under 6,000 miles on the odometer and has been driven exclusively on local back roads, not highways. Despite this exceptionally light and careful use, a hairline stress crack has spontaneously developed on the windshield. The crack originates completely hidden beneath the black frit at the extreme edge of the glass and spread inward without any external impact, rock strike, or user error. Extensive research indicates that this is a widespread, documented engineering failure on Honda's part, not an isolated incident. The automotive industry and consumer protection forums are flooded with identical complaints regarding the 2023–2026 CR-V generations. To meet weight and fuel economy metrics, Honda is clearly utilizing excessively thin, lower-quality glass that cannot withstand the standard structural flexion of the vehicle's frame. This exact phenomenon of spontaneous edge-stress fracturing has been the subject of extreme consumer backlash, ongoing the federal safety agency database trends, and prior class-action litigation (such as *Hasan v. American Honda Motor Co.*) targeting Honda’s refusal to honor warranties for this exact structural defect. A vehicle less than six months old should not suffer a spontaneous windshield failure, nor should the consumer bear the financial burden of replacing substandard factory materials. Furthermore, the failure of this glass inherently compromises the forward-facing Honda Sensing camera, posing an active safety and calibration risk.

Filed Jan 20, 2026 · MI

January 18, 2025 Subject:  Request for Review – Windshield Crack on 2025 Honda CR-V Hybrid Dear Honda Customer Relations Team, I am writing to respectfully request a review of a windshield issue on my wife’s Subject 2025 Honda CR-V Hybrid, which we purchased new in the summer of 2025. The vehicle currently has approximately 16,000 miles. Recently, a crack developed in the windshield measuring roughly four inches in length. The crack originates at the driver-side edge near the frame and began with a very small divot. There is no visible impact crater or evidence of damage from a foreign object. Based on its location and appearance, I believe this may be consistent with an stress-related edge crack rather than road debris. Our local dealership has declined coverage, which I understand may be standard procedure at the dealership level. However, given the vehicle’s age, mileage, and the nature of the crack, I am respectfully requesting that Honda Corporate review this matter for possible warranty consideration or goodwill assistance. My wife and I have been Honda owners for over 20 years. We have consistently chosen Honda vehicles for their quality and reliability, and we have also purchased Honda vehicles for our children, who continue to drive them today. Our loyalty to the Honda brand has always been rooted in trust—trust in engineering, and trust in standing behind the product. I am not seeking special treatment, only a fair review of the circumstances. We value Honda and hope to continue that relationship for many years to come. I have attached four photographs of the windshield, including both full-view and close-up images of the crack for your review. Thank you for your time and consideration. I appreciate your review and look forward to your response. Sincerely, [XXX] [XXX] 
 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 25, 2025 · MD

The front windshield on my vehicle was cracked on four different occassions. Three times when a small stone/gravel hit the winshield while driving. And once while parked outside. My safety was at risk because while driving i was startled when the object hit the windshield and i immediately focused my eyes on the damage when my attention should have been keeping my eyes on the road at all times. Each time i filed a claim with my insurance company. In my opinion i believe the glass does not meet or nearly meet industry standards. Further, I'm retired and do not drive my vehicle every day or long distances. Also, the cracked windshields were replaced with Honda windshields. Finally, i fail to believe I am that unlucky to have had my windshield replaced four times within six years.

Filed Jun 28, 2025 · Visibility · TX

Windshield cracked with a small rock, vehicle is brand new and only has 150 miles on it. I’ve read several complaints from others with this same issue. Their glass seems to be very thin or poorly made. Very frustrating. Did not happen in my previous cars.

Filed Apr 30, 2025 · Visibility · CA

Windshield cracked without visible impact.

Filed Sep 21, 2023 · Visibility · MO

Windshield has cracked on its own. There are no Windshields in stock for extended periods of time. There are multiple complaints of this being a problem with this specific year.

Filed Jun 22, 2023 · Electrical, Visibility · MI

Display screen regularly & unexpectedly malfunctions while the vehicle is in motion. During these times, the display screen dims, goes dark, freezes, or goes into full bright mode. This continues throughout a cycle until the can can be stopped & restarted. Also, the windshield continues to crack along the base from side to side without any noticeable damages prior & I continue to have it replaced.