2020 Honda HR-V problems

Filed Nov 9, 2026 · Transmission · SC

My daughter's 2020 Honda HR-V experienced a serious transmission malfunction at approximately 117,000 miles. While traveling approximately 64 mph on Highway 378 in South Carolina, where the posted speed limit is 60 mph, the vehicle suddenly stopped accelerating, and ALL dashboard warning lights illuminated. This unexpected loss of acceleration at highway speed created a dangerous situation, placing her safety and the safety of surrounding motorists at risk of a serious collision. The vehicle was subsequently towed to an authorized Honda dealership. The dealership confirmed diagnostic trouble code P0793 (Intermediate Shaft Speed Sensor "A"). During inspection, the technician drained the transmission fluid through a filter and discovered metal flakes. Additional metallic material was detected using a magnet, indicating internal transmission damage. The dealership determined that the entire transmission required replacement at an estimated cost of $7,942.57. Honda previously acknowledged premature CVT belt deterioration affecting certain 2016–2020 Honda HR-V vehicles through Service Bulletins 21-046 and 21-047. However, Honda advised that my daughter's VIN was excluded from the extended warranty coverage. Honda subsequently denied goodwill assistance, citing the vehicle's age, mileage, and an asserted absence of similar complaints. I am concerned that this sudden loss of acceleration may be related to premature CVT deterioration previously documented by Honda. I request that the federal safety agency investigate whether this failure is related to a known transmission defect and whether other 2020 Honda HR-V owners face similar safety risks. The dealership's diagnostic findings and repair estimate are available. Availability of the failed transmission for inspection must be confirmed with the dealership.

Filed Nov 5, 2026 · Electrical, Engine · 115,000 miles · CA

The contact owns a 2020 Honda HR-V. The contact stated that while driving approximately 65 MPH, the vehicle lost motive power. The lights on the instrument panel were illuminated during the failure. There was a beeping sound during the failure. The vehicle failed to accelerate but the driver was able to move over to the shoulder. The vehicle was towed to the residence. The vehicle was later towed to the local dealer, who confirmed the failure but informed the contact that the VIN was not included in Technical Service Bulletin: 21-046. The transmission belt had deteriorated. The Honda manufacturer was contacted by phone and confirmed there was no warranty coverage on the vehicle. The contact was concerned that other vehicles were being repaired but the vehicle was excluded because of the VIN. The failure mileage was approximately 115,000.

Filed Oct 29, 2026 · Electrical, Steering · IL

Honda HR-V uses a battery current and voltage sensor (part of the Battery Management System) attached to the negative battery terminal to monitor electrical flow and optimize fuel efficiency. It helps determine alternator output. If the voltage sensor degrades or fails, the vehicle's electrical system voltage may be too low to operate the electric power steering. If this happens, the steering wheel suddenly becomes very difficult to turn. It may result in loss of control of the vehicle. Luckily this happened at low speed. There are no codes or warning lights. Repair shops have been unable to diagnose it correctly and want to replace unrelated parts. A Honda dealer refused to look at it because they did not believe the driver's claim of an issue.

Filed Oct 20, 2026 · Transmission · OH

The CVT is defective and failed while driving, causing immediate loss of motive power. This has been diagnosed and confirmed by the dealer. Honda has a voluntary extended warranty in place for this exact issue for certain VIN's, but because this particular VIN was assembled at a location where less VIN's were assembled with the faulty CTV it is not covered. This should be a mandatory safety recall as losing motive power while driving can easily cause an accident. There were no warning signs, just a loud sound and immediate loss of motive power while driving. For us this happened in a busy intersection, but could easily have happened on the highway causing a serious safety hazard. Honda is not denying that the CVT is defective, but this particular VIN is not covered in the extended warranty due to the location the vehicle was assembled.

Filed Sep 28, 2026 · Airbags · 53,000 miles · NY

The contact owns a 2020 Honda HR-V. The contact stated that while entering the vehicle, there was abnormal white smoke inside the cabin of the vehicle, and the contact stated that a white cakey substance was in the smoke, which the contact inhaled. The vehicle was taken to a dealer to be diagnosed; however, the failure could not be duplicated. The contact was concerned that the air bag might deploy unintendedly. The manufacturer was notified of the failure. The failure mileage was 53,000.

Filed Aug 20, 2026 · Transmission · VA

While on the highway vehicles warning light illuminated and the vehicle immediately slowed down and would not go over 20 miles per hour. Prior to the warning lights illuminating there were no warning lights already illuminated and no drivability issues. You could hear a griding noise when driving at low speeds and the vehicle would not go above 20 miles per hour. Ended up pulling over and towing the vehicle to the dealership. The dealership mentioned after diagnosis the transmission internally failed and needed to be replaced. They did find metal debris from the transmission belt when draining the fluid and found the fluid to be clean. Found the TSB - Warranty extension from NHSTA website showing all 2016-2020 model year Honda HR-V's with 2WD and AWD included in this warranty extension but when reaching out to Honda Customer Service they denied the warranty extension and called it a goodwill denial and were careful to not mention the warranty extension submitted to the federal safety agency. The cost would be over $10,000 to replace the transmission with a remanufactured one quote by the dealership. The TSB - Warranty Extension number is 21-047.

Filed Aug 10, 2026 · Fuel system · MI

AMENDMENT TO SAFETY COMPLAINT: FAILURE OF RECALL REMEDY / USE OF LEGACY PART Vehicle: 2020 Honda HR-V the federal safety agency Recall Campaign Number: 23V858000 (Low-Pressure Fuel Pump) [The 2020 Honda HR-V is under an active, massive federal safety recall for low-pressure fuel pump failure.] Chronological Safety History: •January 2025: Mandatory fuel pump safety recall performed at an authorized Honda franchise. •September 2025: Catastrophic engine stall occurred at highway speeds. •June 12, 2026: Second catastrophic engine stall occurred at highway speeds. Critical Update: Following these severe stalling events, I presented the vehicle to franchised dealer Zeigler Honda. The dealership service department engaged in fraudulent diagnostic practices to evade liability. They falsely claimed the stalling was due to "bad gas," refused to perform a secondary repair, and released a hazardous vehicle back onto public roads. Due to the immediate threat to public safety, I brought the vehicle to a certified independent mechanic. Upon replacement of the system, a component breakdown revealed that the recall part installed in January 2025 was actually an identical, low-density defective legacy component subject to the original recall. The independent mechanic's invoice factually confirms a total mechanical failure of this fuel pump component [The 2020 Honda HR-V is under an active, massive federal safety recall for low-pressure fuel pump failure.]. The system breakdown confirms the plastic impeller deformed and jammed, completely disproving Zeigler Honda's fabricated "bad gas" diagnosis [Honda’s official recall documentation states that the low-pressure fuel pump fails because the plastic impeller absorbs fuel, deforms, and jams against the pump housing, causing the vehicle to stall.]. Regulatory Request: I request that the Office of Defects Investigation (ODI) audit this dealership immediately. Zeigler Honda is actively falsifying safety diagnoses to cover up the defective fuel pump

Filed Aug 4, 2026 · Driver assistance, Electrical · NJ

LKAS lights all came on and ACC warnings. Brake system and auto high beams. Mechanic seems to think it’s the camera, car only has 84,000 miles on it and very well taken care of. This seems to be a big common issue with a lot of HRVs and it’s expensive to fix.

Filed Jul 20, 2026 · Electrical · PA

Instrument Cluster Failure Complaint – 2020 Honda HR-V VIN [XXX] I am reporting an intermittent instrument cluster failure affecting a 2020 Honda HR-V. The digital display that contains the fuel gauge, odometer, and mileage information intermittently becomes heavily pixelated or goes completely blank. I have been dealing with this issue for over a year. The car has 83K + miles. The problem occurs most often during cold weather but has also occurred during warmer temperatures. More rececntly it is happening daily. The display begins functioning again after the vehicle has warmed up, although the failure remains intermittent and unpredictable. Because the display fails without warning, the driver cannot reliably determine the vehicle's fuel level or view odometer and trip information while operating the vehicle. This creates unnecessary distraction and could present a safety concern, particularly during longer trips or in unfamiliar areas where accurate fuel level information is important. After researching this issue, I found numerous reports from other Honda HR-V owners describing nearly identical symptoms involving the instrument cluster on vehicles of the same generation. The consistency of these reports suggests that this may not be an isolated incident but rather a common manufacturing defect. I respectfully request that this matter be investigated to determine whether the instrument cluster failure is widespread enough to warrant corrective action, including the possibility of a Technical Service Bulletin or safety recall. Thank you for your consideration of this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 29, 2026 · Transmission · CT

On 3/15/26 the CVT transmission on my 2020 HRV EX-L failed while driving on I-95 near Fairfield, CT. My dashboard lit up like a Christmas tree and the car decelerated and would not go past 20 miles per hour. My safety was put at risk because this happened suddenly doing 60 mph highway. There was no indication of an issue with the transmission when I visited the Honda Service center on Friday, 3/13 to repair a lose panel. They saw no issues. There were two Service Bulletins 21-046 dated 4/27/21 and o6/1/21, respectively that listed certain HRV VIN numbers that had the warranty extended to cover the full replacement cost of the CVT transmission. My VIN is not included. Many of the steps taken by the dealer to determine the transmission failure came from those service bulletins. I would like the federal safety agency to look into this issue and contact Honda in order to extend the warranty in order to have the full replacement cost of the transmission covered.