2016 Honda Pilot body problems

Filed Oct 9, 2026 · Body, Suspension · 101,600 miles · NY

The contact owns a 2016 Honda Pilot. The contact received notification of the federal safety agency Campaign Number: 26V365000 (Structure, Suspension); however, the front subframe had a hole caused by corrosion. The contact stated that while driving approximately 5-10 MPH, the front end of the vehicle made clunking sounds. The vehicle was taken to an independent mechanic for suspension wear and tear repair, and it was determined that there was a hole in the front suspension. The manufacturer was notified of the failure by phone and stated that the recall repair was only for the rear subframe. The failure mileage was approximately 101,600.

Filed Jun 2, 2026 · Body · MA

Taligate is rusting through near the handle as well as around the right taillight. Another recall for this exact issue is in place for the same year/make/model, yet my vehicle is not included in the recall. Faulty seals allow water to get into the tailgate and rust from the inside-out. Honda has told me they won't help even though it is a known issue (recall).

Filed May 4, 2026 · Body, Fuel system · NV

no incident : recall that was done on hood. gas cap/lid doesn't close tightly Hood looks like it going to open , left side front end lifts when driving on freeway, Honda of the Desert replaced latch but it did not solve the problem

Filed Feb 4, 2026 · Body, Locks · 100,000 miles · CA

The contact owns a 2016 Honda Pilot. The contact stated that while driving at slow and moderate speeds, the transmission was slipping, and the vehicle lurched and jerked. The failure was more evident while driving uphill. The vehicle was taken to an independent mechanic, where it was diagnosed, and determined that the torque converter had failed and needed to be replaced. The vehicle was repaired. Additionally, the contact stated that while driving and exceeding 40 MPH, the hood was flapping. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to the federal safety agency Campaign Number: 21V932000 (Structure, Latches/Locks/Linkages); however, the VIN was not included. The failure mileage was approximately 100,000.

Filed Oct 16, 2025 · Body · MI

The white paint on my 2016 Honda Pilot (White Diamond Pearl, NH-603P) is peeling and flaking off on the roof and tailgate, exposing the primer. The vehicle has never been repainted or damaged. Honda confirmed my VIN isn’t covered, but this is the same factory paint defect affecting other Pilots and Hondas with the same color. The issue keeps spreading and reduces resale value while exposing metal to corrosion. This is a clear manufacturing defect, not wear or neglect. I’m requesting that the federal safety agency investigate and push Honda to expand coverage for all affected VINs.

Filed Jul 15, 2025 · Body · CA

The tailgate paint started to peel. I took the vehicle into the Honda Collision shop. They said I missed the extended warranty by a few months. I called America Honda and they said there is nothing they can do about even though they are aware of the issue with the white paint. This was about a year ago. Now the roof of the vehicle is peeling. This is a hazard because of the potential of rust and weakening the structure of the vehicle.

Filed Aug 1, 2024 · Body · VA

When I reach interstate speeds the hood starts to rattle and makes a very loud noise. It shakes as if it is going to come open. It also does then when I am behind a large tractor-trailer where the wind coming off whips the front of my care. I have checked to see if the hood needed a height adjustment but that isn't the issue. It is up as far as it can go and if I lower it any it gets even worse.

Filed Jun 19, 2024 · Body · NV

At highway speeds, especially in wind or drafts from trucks, the hood vibrates/flexes by inches. At higher wind levels it creates a tremendous roar and vibrates the whole car. The latch seems loose. A recurring problem which first occurred in 2017 just after we bought the car. I have taken it in to the dealer several times but the problem remains. When the car was recalled I hoped it would fix the problem but it did not.

Filed May 29, 2024 · Body · 98,000 miles · PA

The contact owns a 2016 Honda Pilot. The contact stated that while driving at 35 MPH, the roof railing trim detached from the vehicle. The contact recovered the trim from the roadway. There were no warning lights illuminated. The vehicle was taken to the local dealer, who informed the contact that the replacement was not covered. The vehicle was not repaired. The contact stated that the failure was related to Technical Service Bulletin: 18-040. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 98,000.

Filed May 2, 2024 · Body · CT

I purchased this vehicle a little less than two months ago… this vehicle is babied and I make sure to stay on top of everything possible as it’s a primary transportation to bring my toddler to his many appointments. While operating on the highway, everything was smooth sailing as expected, until I heard a noise. I glanced in the rear view mirror to see a part flying off of the car and colliding with the vehicle behind me. I couldn’t locate where the item came from. Today, I went to pick my son up from preschool and noticed the entire piece on the roof was hanging outward, right off and over the side of the vehicle. Had I not noticed, it could’ve caused further danger to others. I hopped up to look at my roof to realize the rear trim is the piece that flew off, and the following straight part is what was now dangling over the side. On top of everything else, on the same side, the trim along the side my of windshield is upraised and I am absolutely torn. How dangerously this could’ve ended had I not noticed. I’ve seen other pilot-owners discuss how their trim pieces have caused trouble and even further dented some trunks. This needs to be brought to attention, I didn’t spend $$,$$$ on a vehicle that is not safe.