All lights on the dash board lights up and the car stalls with no chance to pull over
2016 Honda Pilot fuel system complaints
Page 3 of 8: complaints 41 to 70 of 195, newest first, as owners wrote them.
Failure causing an engine cylinder misfire, flooding and possibly prevent the engine from running.
ECM Failure with fuel rail/system pressure code. Safety issue due to no prior issue and all of a sudden engine stalling in the middle of a busy intersection and taking 10 mins to get started and shift gears to get out of the way of oncoming traffic with all dashboard lights illuminated to include check engine light, trailer stability assist problem light, hill assist problem light, LKAS light, and ACC light.
Gas gauge doesn't read correctly and estimated gas mileage continues to reduces with each fill up by 5 to 30 mileage for the total miles on one tank.
The contact owns a 2016 Honda Pilot. The contact stated that the vehicle failed to start at the initial attempt. The contact stated that the vehicle eventually started after several attempts. Additionally, the contact stated that the vehicle hesitated and failed to accelerate properly while depressing the accelerator pedal. The contact stated that while driving at an undisclosed speed, the vehicle stalled and lost motive power with several unknown warning lights illuminated. Due to the failure, the vehicle was towed to a dealer to be diagnosed. The contact was informed that the high-pressure fuel pump was defective and needed to be replaced. The manufacturer was notified of the failure and the contact was provided a case number. The vehicle remained with the dealer unrepaired. The failure mileage was 115,043.
Fuel pumps has gone bad twice, transmission slips gear makes clunking noise
Vehicle's motor stopped running in traffic
For the last few months we have been smelling fuel in the cabin when driving at slow speeds. Also when the fuel tank is topped off, we smell fuel when parked in the garage for 1 to 2 days afterwards. Took the vehicle to independent shop who advised they see signs of small fuel run-off from top side of tank. They performed a system pressure test and the evaporative side of the fuel tank failed the pressure test. The vehicle is officially not part of recall listed by honda technical service bulletin 16-051 or 17-021. The replacement tank part no. 17044-tg7-a00 or 17044-tg7-a01 is not available from any honda oem dealer due to backorder without any dates. We were advised to ensure vehicle is parked outside of garage for fume and fire safety. Called honda automobile customer service recall line, they only can escalate as a goodwill request for this safety issue.
High pressure and low pressure fuel pumps were defective.
My Transmission went out on my 2016 Honda Pilot I bought it on 8/25/24 with 68,000 miles on it, six months later I have 81,000 miles on it and I’ve been quoted $9222 to install a rebuilt transmission at the dealership. 3 mechanics & transmission specialist do NOT even work or offer to replace transmissions on this model of honda pilot due to its known issues in the 6 cylinder V6 3.5 L. My car was in excellent condition, low miles, always well maintained. 2/21 It started rough/delayed shifting, during gear changes, hesitation when accelerating, unusual noise like quiet whining, on 2/22 the check engine & emissions & transmissions system lights came on I immediately took it to the Honda dealership/service on 2/22/25 I dropped it off and left it after hours (weekend Mon. 2/23 they diagnostic performed $200 transmission fluid flush and software update $500 it did not fix a thing. They evaluated & diagnosed on 2/24/25 Error codes stored P0776 & P0777. Recommending a rebuilt transmission for $9222. I got second and third opinions from experienced, highly recommended mechanics & transmission specialists who won’t even touch the 2016 honda pilot because it is considered problematic model/year with frequent reports of glitches & complex issues which can be make the job time consuming & potentially costly for the mechanic due to the need for speciality parts & diagnostics. Ive contacted American Honda & service/dealership inquiring “goodwill” program with no resolution. I have personally owned a 2005 pilot, 2011 pilot, 2007 odyssey, my parents & sister both currently own two Honda pilots & a Honda Ridgeline to say we’re loyal Honda customers is an understatement. I regret buying this 2016 Honda Pilot 6 cylinder V6 3.5 L I believe honda made a huge mistake and recalls must be issued. Show some integrity and take accountability this is unacceptable. If consumers & mechanics want nothing to do with it you should probably follow the evidence. From a very disappointed customer.
Vehicle started jerking bad and all the lights on the dash started rotating through the error messages. Took care to shop and confirmed fuel pump was bad. There is a recall on 2016 Honda Pilot Fuel Pumps but not for this particular model.
Car started surging while driving in rush hour traffic was very scary and almost caused me to be rear ended at a high speed. It cost 3200.to repair and when I spoke to the dealer they said they were under recall for all models 2017-2024 and it has been an ongoing issue since 2014 I think they should pay to fix it not just let us eat it on the repair because the vehicle is older not that old and it’s a safety issue
The contact owns a 2016 Honda Pilot. The contact stated that while driving at various speeds on several occasions, the vehicle started sputtering and lost motive power. On another occasion, while driving 65 MPH, the contact stated that the stability assist, power steering, Hill Start assist, fuel emission,s and a few other unknown warning lights illuminated. The vehicle then stalled. The vehicle was towed to the residence and then to an independent mechanic where it was diagnosed that the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 138,000.
We have always taken great care of our Pilot, regular oil changes, tire rotations, checking the fluid levels. Just before we went on vacation, our Pilot's check engine light came on and started blinking under normal driving conditions. When we hooked up the code reader, it was for a misfire in the second cylinder. Having changed the spark plugs about 30-40k before this incident, we tested the plugs and assumed it was the coil. We changed the coil. After returning from vacation, we drove the car minimally yet after about 40-50 miles, the code returned with knocking sound. We had the car towed to our residence...to find the same code. We inspected the plug and coil, no issues were present and the code was cleared. The next day, the code came back on and the engine was knocking very loud and had definite performance issues. I checked the Honda recall page and our car had no open recalls. I noticed that other Pilots with the V6 engine in our model year range were included an investigation by the federal safety agency. Our mechanic drove our pilot for 30 feet and immediately called me to tell me that he would not suggest even spending money on diagnosing the problem....as he believes the engine is a total loss. It seems unfair that Honda would not address this issue as it seems a wide spread problem after a simple google search.
I was driving down the highway when I started to hear a knocking sound at certain RPM. No check engine light and I was unable to safely pull over. As I continued driving looking for a safe place to park the vehicle, within a few minutes the noise in the engine got worse and then suddenly the vehicle completely lost power and would only drive in limp mode. Luckily I was able to pull off to an offramp and get the vehicle into a gas station parking lot. I called for a tow truck and had the vehicle towed to the nearest dealership. At the dealership they inspected the vehicle and found that it was damaged similar to the Safety recall related to the federal safety agency Action Number: RQ24013 and advised me to have it towed Calgary Honda. I called the Honda Dealership and they informed me that it did not qualify for the recall at the time but the issue sounded familiar. I had them and the current dealership quote me the pricing and decided that I would proceed with the repair from Honda directly. It took awhile to get a replacement engine in and I had to wait several weeks but I was finally able to have it replaced at Calgary Honda in November of 2024. It cost me $10,000 to replace the engine as well as have the work done to repair the alignment after the power failure and replace the battery due to the vehicle sitting for weeks in the cold. I believe my vehicle is part of the same issues as: the federal safety agency Action Number: RQ24013 and wanted to submit my report to hopefully get reimbursed by Honda for the engine and all other costs associated with the Recall
Fuel pump inside the fuel tank failed while driving and caused my engine to stall and almost causing an accident in the highway. Several 2016 Pilots had a recall but my specific VIN does not show in the recall even though I had an issue with the Fuel Pump in 2023.
A few years ago I was told my fuel injectors needed to be replaced. Last month, I was told that my suspension needed to be replaced and it wore out. Shortly after that my struts were leaking and making noise. I do not drive my car over rough terrain, just regular street driving and I get my vehicle maintained regularly.
The contact owns a 2016 Honda Pilot. That contact stated while driving 35 MPH, multiple warning lights were illuminated. The contact stated that the gear shifter failed to move. The contact stated once the vehicle was stopped the transmission failed to shift. The contact took the vehicle to an independent mechanic where it was diagnosed. The contact stated that several unknown repairs were performed. The manufacturer was notified of the failure, and the contact was referred to a local dealer for assistance. The contact related the failure to the federal safety agency Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included. The failure mileage was 140,000.
The contact owns a 2016 Honda Pilot. The contact stated that while driving on the highway at 40 MPH, the vehicle lost automotive power and shut off in the middle of the highway. The contact stated that all the warning lights had been illuminated. The vehicle was not able to be restarted. The vehicle was towed to a local dealer where the vehicle was diagnosed; however, the dealer found no cause for the failure. The vehicle was not repaired. The contact linked the failure to the federal safety agency Campaign Numbers: 23V751000 (ENGINE AND ENGINE COOLING) and 23V858000 (FUEL SYSTEM, GASOLINE). The manufacturer was notified of the failure. The approximate failure mileage was 124,000.
My vehicles engine will stop running sometimes while the car is at a complete stop and sometimes while it's in motion. Sometimes the vehicle restarts immediately and sometimes it struggles to restart. The problem happens sporadically sometimes going weeks between occurrences. This has caused me to be stalled in busy traffic and has also caused more dangerous situations where the vehicle loses power while in motion. I have taken the vehicle to a dealer and a local repair shop and neither were able to reproduce or confirm the problem. They each performed what they thought could be helpful maintenance procedures but these did not seem to work. Other than the local repair shop and the dealer nobody else has inspected the vehicle.
Car keeps hesitating to accelerate, stalled a few times & is burning through gas extremely quickly. Error code "engine emissions problem" came up, believe this is part of the recall
Driving our well-maintained 2016 Honda Pilot with 133K with cruise control set at 65 on [XXX] in Kingman, AZ in October 2024, when the "check engine" light came on. I pulled off as soon as I could on the exit ramp 1.5 miles later. By that time, the engine was ticking and clicking loudly and all of the various system errors were flashing on the dash. The engine then started vibrating and sounded like a box of marbles being shaken violently. At that point, the engine had 10% of less of the normal acceleration. The local shop in Kingman, that I managed to limp to, said the engine had blown. I had it towed to the Honda dealer in Kingman (Anderson Honda) and they confirmed that a new or rebuilt engine and quoted me approximately $19K or $13.5K, respectively. They made no mention of the existing recall for three weeks of Pilot production, but I found that on my own, along with many frustrated Pilot owners. I'm now weighing whether I should have the work done by the Honda dealer in Kingman, whether I should have the Pilot towed to Phoenix, Arizona, where I live and there are more repair options, or whether I should wait and see whether the federal safety agency forces Honda to expand the existing recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Vehicle has strong fuel smell after driving. And took to mechanic and fuel is leaking out
I was driving on the interstate last March of 2024. I have a Honda Pilot 2016. Im going 70 miles an hour or so and my engine just stalls and quits. So many alerts come up on my vehicle as well. Check engine lightTrailer Stability Assist Problem, Power Steering System EPS Problem, Trailer Stability Assist Problem, Hill Start Assist Problem, and others. I make it to the off ramp coasting this is a huge problem because I could have killed someone or someone could have killed me or provided Serious injury. I get it towed and I called the dealership and no recalls. I take it to my Mechanic and discover it was reading Code (P0087) The fuel pump not working at all. I had to replace it to drive the car. I am so livid as I see on the Honda Service Bulletin of a Safety Recall for 2016-2021 Pilot Fuel Pump Motor. This revision supersedes the previous recall of the Fuel Pump Motor from July 19th, 2024. I can see why their wasn't a recall when I checked. Cars from those years are now having this problem and should not be subject to certain VIN# on cars. I called Honda today 10-18-24 and was told this isn't covered.because my VIN wasn't in covered cars. How the heck does a VIN number cover or not cover you. Those years are what matter and my safety was at risk and could have proven fatal. Not warning was given it just happened as I going down the interstate 121 in Texas.Lucily I did not go over a high bridge which was another way to get home and one of the most dangerous interstates in the area I-25E. I could have flipped over the bridge and killed someone else going a descent speed. Im usually really careful on super high bridges cause they are scary. Getting stalled on that bridge is deadly. I'm really Upset over this and gave up my awesome Toyota 4Runner for a Honda Pilot and now this happens. I also stalled 3 to 4 other times after I turned on my hazards and restarted the car. it was 7pm and dark so it was quite scary my vehicle out of nowhere just quit on me.
The contact owns a 2016 Honda Pilot. The contact stated that while driving at 70 MPH, all the warning lights were illuminated. The contact was able to veer to the side of the highway where the vehicle stalled and restarted. The contact stated that the failure was related to the federal safety agency Campaign Number:Â 23V858000 (Fuel System, Gasoline). The vehicle was taken to an independent mechanic, who determined the failure was due to the fuel pump. The vehicle was taken to the local dealer, where it was diagnosed that the fuel pump needed to be replaced. The vehicle was not repaired. The dealer informed the contact there was no recall coverage. The manufacturer was not contacted. The failure mileage was approximately 135,000.
The contact owns a 2016 Honda Pilot. The contact stated that while driving at various speeds, the vehicle would either hesitate or stall upon the depression of the accelerator pedal as the check engine light would appear on the instrument panel. The contact initially stated that the vehicle would restart after multiple attempts and resume normal driving; however, after a recent failure, the vehicle failed to restart. Due to the failure, the vehicle was towed to a dealer where it was diagnosed with a defective fuel pump. Upon investigation, the contact linked the failure to the federal safety agency Campaign Number: 23V858000 (Fuel System, Gasoline) but the vehicle was not included in the recall. The vehicle remained in the possession of the dealer and had yet to be repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 105,000.
On 9-4-2024 my 2016 Honda Pilot was being driven on a city street when the engine stopped. The vehicle re-started and was driven to my residence. Messages had appeared on the dashboard. I scheduled an appointment with Courtesy Honda for the next day. On 9-5-2024 the vehicle started and I proceeded to drive it the 6 miles to Courtesy Honda. About halfway there the engine died. Multiple messages appeared on the dashboard. My wife had been following me in her car when the Pilot died. She helped me by steering the Pilot as I pushed it off the busy street manually to a side road. It was a hazardous situation. The Pilot would not start . I called a towing service to tow it to the dealership. At Courtesy Honda a service technician examined the vehicle and diagnosed the problem as “ high pressure fuel pump failure and low pressure fuel pump failure.” He recommended replacement. I approved the repair. It was completed for a total of $1754.46. I researched Recalls Of Honda Pilots For Fuel Pump Failure. I found there was a massive recall of thousands of Honda Pilots from 2016 and beyond. Letters were sent from Honda to owners authorizing replacement of fuel pumps. My VIN number was not included in the recall. It should have been.
In 2021, my 2016 Honda Pilot had routinely had restart issues from when going idle at stop. In some situations, it simply would not start again and had to be jumped off. I ended up getting the battery replaced multiple times, but on [XXX] I went to my vehicle to start up and it was dead yet again. I then hooked up a jumper and the vehicle instantly started smoking from under the motor. Within 20 seconds, fire had started under the hood and it caused extreme damage to my home. The car was also destroyed. There seemed to be some sort of electrical system issue. I was able to get my 1 year old daughter safely away and nobody was hurt. However, this caused extreme losses. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The vehicle will delay driving with auto turn off enabled almost causing collisions. Then vehicle delays switching gears. Not daily The vehicle smells like gasoline occasionally after a fill up. O2 censor replaced twice. Electrical system issue
Car shuts off when idle or when ac is used Car vibrations Car not trying to start Engine light on and off
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Honda Pilot?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history