The engine begins to idle rough, after a few days of driving a lot of cluster lights come on starting with check engine light, VSA as well as others. Disconnecting battery works to clear the the codes, engine will appear to idle ok but after a week of driving it will start idling rough again, then the cluster lights will light up as before. I believe this is due to Service Bulletin 20-100 or Service Bulletin A20-100 which states that issues with the fuel injectors were found relating to quality control. The TSB listed above states that if your vehicle is affected by these symptoms your warranty will be extended to 10 years of manufacture date or 150,000 miles. Our Pilot currently has under 80,000 miles on the odometer.
2016 Honda Pilot fuel system complaints
Page 5 of 8: complaints 101 to 130 of 195, newest first, as owners wrote them.
While stopped at a red light, with the auto start enabled, the car would not turn back on and placed the car in “neutral”. The dash info message prompted me to put the car in “park”. I did. It then instructed me to depress the brake and hit the “start” button to turn the car on. It did not after I tried a few times. Finally to get it started I pushed the “start” button with the key fob. It then turned on and allowed me to put it in “drive”.
The fuel tank leaks when it become near full which could put me and others at risk of fire. The vehicle hasn't been inspected and I notice this safety defect when I refill the gas tank
When idling at a stop light, the auto shut off feature engaged and turned off the engine. When I engaged the gas to start moving again, the engine would not restart. I applied to brake, put the car into park and then tried to manually restart the car using the start button on the dash. The car engine would not start. The auxiliary power to the accessories would not go off when I pushed the stop/start button on the dash, but the engine would not restart either. I attempted to restart the car several times. It did not attempt to turn the engine over, but did literally nothing. I paused and waited for a minute and then attempted to restart the car again with the stop/start button and the car engine finally turned on. The exact same sequence of events has happened and two separate occasions some weeks apart. This incident put my and my passengers’ safety at risk by stranding me at very busy intersections with no way to move the vehicle out of the road. The auto-shutoff feature has engaged while in stop and go traffic on the freeway and if this had happened then, the results could be catastrophic. I now always manually turn off this feature due to fear of this happening again and would disengage it entirely if possible, but was informed by the dealer that was not possible. No one has inspected the vehicle as the problem is not reproducible on demand, but I am willing for any necessary inspections to occur.
The problem has happened at-least 5 times won’t restart on its own from a complete stop at a traffic light or intersection with the stop-start feature in use.Brought to Honda dealership and they stated the do not see a problem. This is a safety problem that needs to be addressed. It stopped completely when i was in traffic also almost caused an accident.
While at a stop light, with the engine "Auto Start/Stop" switch engaged, I released my foot from the brake, and the car died. I was totally confused as to what occurred. After a minute or two I was able to restart the car. I was very concerned about being re-ended as when the light changed to green is when the car died. I had no advance warning of a problem, and it just died unexpectedly as I released my foot from the break. No lights on the dash either. I notified my dealer, who had never heard of this happening, and said when I can, please bring it in. In as much as the incident occurred in May 2022, and hadn't happened since, I did not take my car into the dealer. I can take my car in at any time to be examined.
Unknown. Background: Driving vehicle and engine warning came on. Looked up code and it was due to injector failure. Dealership changed injectors and reprogrammed. Now vehicle gets nowhere the gas mileage and the start/stop has stopped. That doesn't bother me as bad due to it shut off at light one day and would not start back for about a min. Then started and went it's way.
The contact owns a 2016 Honda Pilot. The contact stated that while operating the vehicle, the Auto START/STOP fuel-saving feature malfunctioned and the vehicle would not immediately restart after lifting off the brake pedal. The contact indicated that the failure had occurred on multiple occasions. The vehicle was taken to the local dealer who was unable to determine the cause of the failure and no service was performed. The manufacturer was not yet contacted. The failure mileage was 22,000.
Every single time I get in my car to drive. I experience julting when I am speeding up but it mostly happens in between 30mph and 50mph. Sometimes in between 70mph and 80mph as well. It has been going on for a year and a half and no one can figure out what it is. There needs to be a recall because it is dangerous for myself and other drivers. To the point where I am going to sell this car and get a different make
Driving the vehicle started to quickly lose power for about 15 seconds and it stalled while at speed on an interstate. Luckily I was in the right lane and was able to pull out of traffic onto the shoulder. The car had all the lights flash on the dashboard. The check engine, the hill assist, the oil, power steering, etc...i mean all the lights. I turned the car off through its power button and waiting about a meeting and attempted to restart the vehicle. It would not restart. I repeated this action. After two more failed attempts i went and opened the hood to check to see if there was a visible problems or potential a lose sensor connection. The engine looked ok. The main sensors were connected. I again tried to restart the car. The car started and drove about half a mile before losing power again. I repeated all of the above. Again. After about 45 mins the vehicle started even though nothing had actually changed. I didn't do anything. I took the car with the check engine light still on to autozone where they plugged the computer in to tell me my fuel pump wasn't working. Code P0087 registered. The next day the computer cleared itself and has been running. My mechanic said Honda had released a TSB pertaining to the fuel pump with new lines. Unfortunately there is a nation wide shortage of those parts so my car cannot be fixed. I feel unsafe. I dont know if the car will work or not. Its terrifying
I received a letter in the mail from Honda North America in early 2022 stating that my vehicle/vin was covered under an extended warranty on emissions systems problems. HONDA TSB 20-100. I took my car in to the local dealer, dealer performed a software update, 2 days after software update, all warning lights turn on in dash and do not go away. Check engine light, Power steering problem , hill start assist, vehicle stability control, trailer assist, traction control. Took vehicle back to the dealership. The service advisor takes the car back and when I return a few hours later he states that his technician informed him the injectors must also be replaced when the software update is done. Then I am informed that due to previous salvage history (from 2017) the vehicle emissions warranty extension will not be covered by Honda and I will be required to pay roughly $1,500 for this repair. The TSB states that all 2016 Honda pilots are covered. The faulty injectors were an issue from the factory on every single last 2016 pilot that was produced. The dealership caused these lights to come on and now wants me to pay to fix the additional issues they caused.
Fuel lid keep looked or can't be closed.
Throughout last trip I noticed the transmission would make jerking shifts. While on the interstate during a pass travelling at 73 Mph the transmission down shifted and made a loud banging sound, engine lost power but was revving high, I could not accelerate to get away from surrounding traffic. A transmission error come up as I maneuvered the vehicle out of the road to avoid being hit by other vehicles. The AWD error came one and later an emissions error. Once the car was out of the road safely I was able to engage the e-brake then put it into neutral then park. AWD and emissions error remained on. After a minute turn car off then on, emissions error remained on and the car could operate. This scared the family as we could have been rare ended in traffic. Honda dealership in my town could not diagnose the issue. This is the second time this has happened.
Vehicle unexpectedly and unpredictably shuts down when stopped for a red light, at stop sign, or for an extended break period. Vehicle does not immediately restart after shutting off. Vehicle is available for inspection; however, given the safety concerns for our family and unanswered questions from Honda with no resolution in sight, we plan to buy a new vehicle. Vehicle has been disabled when it shuts down in the middle of intersections with cars swerving to avoid. It puts vehicle occupants and other drivers at risk of an accident. Dealer cannot reproduce. After the 1st instance, dealer claimed they found info that was sent to Honda corporate. Vehicle has been inspected by dealership with Honda corporate involvement 3 times. After the 1st time, Honda corporate/dealership replaced battery and state of charge sensor at no cost even though vehicle was not under warranty. After 2nd time, Honda said valves may need adjusting but refused to cover expensive ($1000) work and indicated they were not sure it would even resolve issue. If issue continued, they stated they would not refund money. They now refuse any resolutions without reproducing the car shutting down. There are no warnings, messages, or notifications that vehicle will shut down until it does. A variety of errors display after the vehicle shuts down and vehicle shifts on its own into neutral.
The contact owns a 2016 Honda Pilot. The contact stated that while stopped at a red light and after releasing the brake pedal the fuel-saving feature had malfunctioned and the engine did not immediately restart. During the incident, the message "put vehicle to park mode" had displayed. The contact indicated that the failure was very intermittent and when the vehicle was taken to the local dealer the failure could not be duplicated therefore no problem was found and no service was performed. The manufacturer was notified of the failure. The failure mileage was 30,000.
In the past 4 months, each time my Honda Pilot is stopped at a light or in slow traffic, the idle stop will engage and shut off the engine. In order for the engine to turn back on, we have to put our foot on the brake, place car in park, and push the start button to get it to start again. Each time we have taken it to the dealer or a car repair shop, they test the battery and it is fine. While we have not had an accident yet, we have come close due to cars behind us not knowing our vehicle is having an issue. The most recent time occurred in a toll booth line leaving NYC with a line of traffic behind us. Another issue we have experienced is with our fuel injector. Our Pilot was manufactured when there were known failures with fuel injectors. The fuel injector malfunctioned while driving with our three kids down a hill. The car lost power and we had to coast down a hill. Thankfully, an exit was nearby and we were able to come to a stop. Vehicle was serviced at a local dealer. Although there were know issues with fuel injectors, we still had to pay for the replacement and the vehicle's manufacturers warranty was still valid.
The components that have failed are the fuel injectors and catalytic converter. This is according to the Honda dealerships diagnostics. Whenever I press the gas the car hesitates, shudders, shakes, and wont accelerate. This has been an ongoing issue for the past 4 years when the car was 1 year old. It has gradually become worse.My children's safety as well as my safety are put at risk every time I drive. But one example was when I was entering the highway, I tried to speed up and couldn't and almost crashed with another car because my car wasn't functioning correctly and I wasnt able to merge correctly. The dealership has confirmed the issue but wont take responsibility on fixing it. They want me to pay out of pocket. No it has not been inspected by the manufacturer, police, etc. At first there were no warning lamps, but there was a slight hesitation. Eventually, when the car started getting worse, the emissions light as well as check engine light came on. Took it it to the dealership and they got Catalytic converter P0430 error code. However, the dealership kept saying it was fuel injectors issue since it was no longer under warranty and they wanted me to pay for it. Fuel injector warranty is covered until 36k miles and I was at 60k miles.I did replace the fuel injectors with a different mechanic and that didn't fix the problem. Still drove the same. Now that I am over 100k miles on my vehicle, they are saying it's the catalytic converter because that warranty ran out at 80k miles and I would have to pay for it. I am not the only 2016 Honda Pilot owner having these issues and Honda is aware of it but wont take responsibility for it. I cannot afford to get a new car. This year model came out faulty and Honda has made bulletins regarding the issue, but wont cover the cost to fix the cars. They should be held responsible.
Recurring problem with idle stop feature causing car engine to shut off completely (even when disabled), resulting in an error message and requiring the car to be turned off and on. This is a safety issue while driving, especially if in an intersection while turning. Https://www.carproblemzoo.com/honda/pilot/car-stall-problems.php https://www.piloteers.org/threads/elite-shuts-off-at-stop-light.157005/page-13
Vehicle stationary. Auto engine idle engaged. Car losses power. Been happening for several year. Dealer says nothing wrong. Now on two occasions, car has stalled when brake released to re-engage engine. Car going into shop. Car is stationary and basically stalls. Sometimes power loss disables collision mitigation systems
Twice in the last week my honda pilot has shut off when auto-idling at a stop light. The car should remain in drive but when I looked down it had shifted to neutral. The first message on the dash briefly flashed 'crash mitigation problem' and then instructed me to put the car in park and push the engine start button. After this incident, I turned off the crash mitigation system. A couple days later (today), the same thing happened. No crash mitigation system flash but instructions to put the car in park and press then engine start button. Both times the engine was on and in drive. Auto idling was enabled. I have only owned this car for two months.
My 2016 honda pilot is giving me problems on filling up my gas tank. My car has 46000 mile and I don't think any parts are damaged cause it only 5 yes old. I tried looking for answers in the web but no one had a clue yet there was lots of people familiar with this problem. Is there anyway you guys can help me with this. It happens every time I try to fill my gas tank it stops filling as if it's full but it's not. It takes me a long time to fill it up.
Check engine light on and when diagnosed by the repair shop the code p0456 which is very small evap leak. This should have been taken care of with the recall on this car. The repair shop printed all of the recalls and told me most likely it would need the fuel tank replaced which is cover under a recall. They told me to go to the dealership and see of the recall work has been completed. The dealership advised that the recall was done in the past.
Check engine light (cel) appears, randomly when parked or in motion, indicating a problem with emissions system. Cel began to appear at approximately 77,000 miles. Car now has over 85,000 miles. I purchased the vehicle used, when it had 68,000 miles. I have never driven outside of the u.s.. Cel appears at various speeds between 0 and 60 MPH. When in motion and cel is displayed, engine hesitation occurs causing me to increase vehicle speed and engine RPM to ensure I have sufficient power to: complete a turn, pass another vehicle, or make it up a hill. I am never sure I will have enough power. Additionally, the mileage economy display changes from shades of green to solid white. Cel remains visible on dashboard until it randomly disappears. Cel will remain lit ranging from 30 minutes to several days and disappear at various speeds. When it disappears, engine hesitation stops and economy display returns to shades of green depending on whether accelerating or decelerating. I first believed it to be a problem with the fuel tank cap. However, the cap is a hinged flap that returns to the closed position after I have finished refueling. I predominantly use e87 octane with ethanol. But e89 fuel makes no difference because the cel and hesitation randomly still occur. I have not taken to a repair shop because I have not had the opportunity to when the cel is displayed. The repair shop stated they can only diagnose when the cel is displayed. Similar descriptions from other honda pilot owners can be found at https://www.piloteers.org/threads/emissions-system-problem-check-engine-light.157705/.
When my car fuel went down to empty the light came on and I pulled over to get gas. When I pushed the automatic release button my fuel door would not open. I searched up possible causes and found a video of a man demonstrating where you can find a manual lever to pole to release the fuel door. I found the lever and pulled it at the door would not open. Thankfully I was not too far away from home and drove home on my empty tank. If I had been somewhere far away this could have been disastrous. I took it to the honda dealer who had to pull apart half of my car to get to the place to fix it. I had also read online that this has happened to other honda pilot owners. It seems dangerous.
Tl* the contact owns a 2016 honda pilot. The contact stated while driving 65 MPH, the emission system warning light was illuminated. The contact drove to his destination. The vehicle was taken to an independent mechanic and was informed that the oxygen sensor needed to be replaced. The vehicle was repaired however, the failure persisted. The vehicle was taken back to an independent mechanic and was informed the fuel injector and catalytic converter needed to be replaced. The vehicle was taken to autosport honda (1201 us-22, bridgewater township, nj 08807; (908) 722-5566) to be diagnosed. The contact was informed that the fuel injectors needed to be replaced. The contact also stated the ABS sensor, 4 wheel drive, trailer stabilizer warning light were illuminated. The vehicle was not repaired. The manufacturer had been informed of failure. The failure mileage was 80,000.
When pressing the gas pedal, the vehicle has a hesitationin to it. My foot remains on the gas pedal and still has the hesitation or jerking motion, which can be felt in the front passenger seat. We had the oil changed the week before we left to go out of state. It has continued on since then.
A known tsb# 18-025 (fuel injector problem) was outside our warranty and honda would not replace it. Due to the fuel injector issue the vehicle burns excessive amounts of gasoline per tank. I have recorded approximately 160 miles per tank of fuel. In addition to throwing emissions related check engine codes.
My car will die after being stopped (ex. At a red light, stop sign) and will not restart right away. Sometimes it doesn't die completely. When it does you are unable to put the car into park or engage the emergency lights. This has happened where we were stopped at a red-light and the car died and would not restart. A car behind us was approaching the light and saw that it was green, quickly came up behind us honking their horn and lucky was able to move to the other lane to avoid hitting us. This seams to happen when we forget to turn off the auto idle stop. This is something you have to push everyone you start the car. I took the car to the dealer they put in a new transmission and changed the timing belt. Previously I had the cars fuel injectors replaced. After all this work the car is still dying and it is happening more frequently. The dealership says they have heard of this problem but don't know of a fix yet.
Bought my honda in february a month later a emission system started popping up I have replaced all 4 sensors maf map sensors still isnt fixed they are telling me it's the fuel injectors and I have no warranty said it's a honda thing and needs recalled can cause poor driving honda really needs to fix it and the awd light pops up and goes away and comes back no mechanics can figure that out
I've had several issues with my 2016 honda pilot in the past few months. I currently have 110k miles on my vehicle but my problems began at around 80k. My check engine light and several other lights illuminate constantly. At first they would light up and go away. Brought it to service. They said there were no recalls and they change my spark plugs and told me to drive my car on at least a half tank of gas. Problem continued and then my car started running rough and idling rougher. I brought it in again and was told I needed to replace my fuel injectors. That was taken care and I still have a check engine light illuminates along with emissions system problem warming and my car still runs rough and has trouble accelerating. Song with all of these issues I've also had to replace my ignition and key fob and my auto start is not working. I have over a100k on the car which I understand can cause wear and tear but all of these problems far exceed the definition of normal wear and tear. I'd like to know if there is a recall on anything and what can be done to remedy these situations. My car is at service yet again trying to find out what is causing it to run so rough. Any feedback would be greatly appreciated. Thank you.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Honda Pilot?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history