2022 Hyundai Santa Cruz: engine stalls while driving

Filed Jul 10, 2026 · Engine, Fuel system · NC

October 2025 while driving the vehicle at highway speeds, vehicle started bucking, losing power and then stalled. The check engine light did not come on. I was able to get off the side of the road and had it towed to the dealer. Dealer found injectors to be leaking and replaced all 4 GDI fuel injectors-mileage was 29,598. On July 1, 2026, again the same issue while driving the vehicle at highway speeds, it started bucking, losing power and stalling when slowed. This time the check engine light came on. Again, it was undrivable and had to be towed to the dealer. Dealer found after 15,000 miles, some of the new injectors failed and were leaking and all 4 GDI injectors were replaced again-mileage 44,492. Both times there was no warning signs that the fuel injectors were about to fail. No other tests were performed on the engine to find out why the fuel injectors are repeatedly failing. I have filed a report with Hyundai National Consumer Affairs because the vehicle will be out of warranty by the end of 2026, and the underlying issue has not been investigated nor resolved. I am concerned that once vehicle is out of warranty, a major issue with the engine will be found that caused repeated failure of the fuel injectors. I did request an extension of the warranty, but was told that normally doesn't happen.

Filed Feb 28, 2025 · Acceleration, Engine · OH

On the interstate mid-route, the engine light went on and the car started acting sluggish and slightly shaking on the interstate and would not respond to pressing the gas to accelerate and started to slow down. When I pulled over to the berm it was vibrating as if it was going to stall out. I turned the car off and returned to the interstate with no issues for the rest of my ride (the engine light remained on). On the next trip to the dealership for an appointment to have it checked, I was merging onto the interstate, and again, the car was not responding to me putting on the gas and would not accelerate. Could not push the car over 35MPG, and had to ride to the dealership with the car varying in speed anywhere from almost a complete stop to 30MPH on the berm where I could with flashers, often it felt as if it would stall out. It was a very dangerous & unsafe ride. FYI - The dealership replaced all 4 fuel injectors to fix

Filed Jul 30, 2024 · Engine, Transmission · CA

On 6/22/24 I had issues with my car not picking up speed and shaking while driving a major freeway. The same day I had an issues starting the car. When it finally started the engine light came on with a notice on my screen. Dealership replaced fuel injector. Stating that was the problem. Again, on 7/27/24 the same issues happened. Another fuel injector replaced by dealship. The car is 2 and half years old, under 30,000 miles. 2 of my fuel injector have been replaced. I do not feel safe for other drivers and myself driving the freeway with the hyundai santa cruz. Due to the fuel injectors that randomly keeps giving out. They replace 1 at a time. I feel like hyundai is waiting for a big accident before they replaced all of them. There are multiple complaints that I have seen regarding this problem. They need to be investigated thoroughly, people's lives are in danger. I don't know much about vehicles, but if a car continues to stall, vibrate and stop at anytime it will cause an accident.

Filed Feb 14, 2023 · Engine, Transmission · 25,000 miles · AR

The contact owns a 2022 Hyundai Santa Cruz. The contact stated while driving 40 MPH, the vehicle independently started to decelerate. The contact stated that unknown warning lights were illuminated. The contact was able to enter a parking lot before the vehicle stalled. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with a seized engine. The vehicle was not repaired. Upon investigation, the contact associated the failure with the federal safety agency Campaign Number: 22V746000 (Power Train) however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 25,000.

Filed Dec 30, 2022 · Transmission · 8,220 miles · NC

The contact owns a 2022 Hyundai Santa Cruz. The contact stated that after starting the vehicle, the transmission would not engage when shifted to reverse. The service engine warning light was illuminated. The contact stated that the vehicle stalled while entering the dealer. The vehicle was diagnosed, and the contact was informed that the failure was related to the federal safety agency Campaign Number: 22V746000 (Power Train) and that the transmission needed to be replaced. The vehicle was not yet repaired. The failure mileage was 8,220.

Filed Dec 24, 2022 · Transmission · IL

I brought in my 2022 Hyundai Santa Cruz to its first oil change at one of my local Hyundai dealers. the technician right away stated they needed to perform a software update otherways they would not be able to perform the oil change, I agreed to it, after 3 and a half hours I walk up to service technician and complained it was already taking too long, when I finally got my car the car would not work properly it would stall and on stop it would rev up still does that to this moment. I have to constantly keep foot on brake pedal otherways risk hitting the car in front of me. took the car to dealer where it was purchased and after 2 hours service technician stated there was nothing they could do for me, he stated Hyundai is aware and are working on a solution, he stated the car was not safe to drive and I should just park the car, my response was I did not purchase a car to have it parked in my driveway.

Filed Nov 23, 2022 · Engine, Fuel system · IL

When accelerating from a complete stop the transmission skips within the first few RPMs. This also happens when coming to a complete stop. It feels like a stall or a stutter. Also does it when put into reverse.

Filed Oct 22, 2022 · Transmission · PA

My residence is located in a dip..I can't say valley..this new Santa Cruz won't go up the hill even with the turbo engine the grade is not much.. a honda accord goes up easily.. the Santa Cruz revs and petty much stalls and I have to pump the accelarator and not sure what is going on with it.. there are no recalls and so I don't know what is wrong with it.. now I am forced to think of selling it and getting another one..

Filed Oct 7, 2022 · Electrical · TX

My new car with less than 2000 miles stalled at a traffic light on Southlake Blvd. in Southlake, TX. It just died and would not start. All the electrical warning lights were flaring. Every time I tried to restart it, it would try, shudder, and die. I was lucky not to get run over on that busy street. It was towed to the dealership and has been there a month exactly. They cannot figure out what is wrong.

Filed Sep 24, 2022 · Acceleration, Electrical · NY

I was driving on the highway (55mph) with my two children in the backseat. My vehicle started slowing down quickly even with my foot on the gas. There was no warning, no lights on the dash lit up warning me there was anything wrong with the car. The rpm’s we’re going up but it was like there was no power to the car. I got off the highway onto a side road as fast as I could do I wouldn’t get hit. Then I pulled off to the side of the road. I put it in park and turned it off. I tried to turn it back on and it would start. After a second attempt it turned on but was really rough and felt like it would stall. I used blue link to call for a tow truck. Then I called the dealership to tell them since I’ve only had the car for 9 months. I tried to turn the car back on and the dash said battery discharging due to electrical and it turned off before I could read the last word. Tonight checking my email blue link sent an email stating a possible condition with the engine control system. The vehicle was towed to the dealership where I bought the car.

Filed Aug 27, 2022 · Engine, Fuel system · TX

Problem 1 - The vehicle has stalled twice at low speed (less than 5 mph). Both times I had just pulled away from a parking space, coasting (or slowing) before a STOP sign and the vehicle dies. It beeps loudly, says shift to Neutral and restart. It did restart both times. This happened both times while being in SMART mode. I drove it about a month in NORMAL mode between stalls and the issue did not happen. Maybe a coincidence, maybe not. I have had the Santa Cruz less than 2 months. Problem 2 - While accelerating away from a stop, it seems the vehicle revs and does not accelerate, almost like it is not in gear.

Filed Aug 15, 2022 · Engine, Transmission · FL

On 08/13/2022, I was driving from Miami, FL, already 2 hours on the road and like 9:45 PM I was driving with my wife on the Interstate I-95 in the City of Melbourne, state of Florida, and stop at the I-95 North Bound Rest Area to use the rest rooms and change driver seat with her. Then 10 minutes later we resume our travel and after entering the I-95 again, the vehicle suddenly went into some type of limp mode and lose power while merging in the I-95 and I had to do an emergency maneuver to the right shoulder to avoid being hitted by another vehicles. After stoping, I turned off the ignition and back on again, since I was on a place not too safe I continued the driving back home. No Check Engine Light was on whatsoever. The vehicle was driven normal for the next 20-30 minutes, then while driving State Road 192 and while driving 65-70 MPH, the engine stalled again. I had to stop in the middle of the darak and empty road on the right sholuder with my Emergency Lights on. I tried restarting the engine and the limp mode still and I got the Check Engine Light on and steady. I called pushing the button for the Hyundai BlueLink inside the car and nobody answer the emergency number. I verified the BlueLink application on my phone and then noticed a code for the malfuntion. DTC: P030100, DTC System: Powertrain, DTC Sub System: EMS After 2-3 minutes I was able to continue driving home, when I pushed the pedal I felt the condition like loosing cylinder power this time and I pushed hard, the vehicle then suddenly was able to accelerate as normal and I was able to get home. After that I was able to drive the vehicle but I am not sure it is safe or not. I contacted the dealer Holler Hyunday at Winter Park Florida, and they gave me an appointment for 08/23/2022. I need my transportation issue resolved before that date since is my only vehicle needed to work and make wages. As a note this happened driving in Smart Mode. I will contact Hyundai to escalate this case.