2013 Hyundai Santa Fe Sport: engine stalls while driving

Filed Aug 10, 2026 · Engine · 136,434 miles · MI

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that after a routine oil change, while driving back to the residence, the vehicle stalled. The vehicle was towed to the dealer to be diagnosed. The contact was informed that there were metal shavings inside the engine. The vehicle was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was made aware of the failure and stated that the vehicle was not eligible for a recall repair because the engine software update was not performed. The failure mileage was approximately 136,434.

Filed Jul 30, 2026 · GA · fire

While driving a 2013 Hyundai Santa Fe Sport on a city street, the vehicle unexpectedly stalled and shut off while idling at a red light. The vehicle completely failed to restart. No dashboard warning lights, check engine lights, or fault messages illuminated prior to or during the stalling event. Immediately following the engine shutdown, a fire erupted under the engine hood. The fire rapidly escalated and completely engulfed the entire vehicle, resulting in a total loss. The local fire department responded to the scene to extinguish the blaze

Filed Jul 13, 2026 · Engine · TX

Vehicle is a 2013 Hyundai Santa Fe Sport with the 2.4L Theta II GDI engine. A Hyundai dealer documented excessive oil consumption in December 2025 (3 quarts consumed over 1,703 miles during a dealer-administered oil consumption test; repair orders on file and available for inspection). On April 19, 2026, at 160,913 miles, following a highway drive, the engine developed a pronounced knock and vibration at low RPM and began stalling within seconds of idling in Park, with check engine and charging warning lamps illuminated. An engine that stalls at idle presents a safety hazard in traffic due to loss of power braking and steering assist. The vehicle was removed from service the same day, has not been driven since, and remains available for inspection. Knock Sensor Detection System software (Campaign 953) was installed and did not prevent the failure. Manufacturer has been notified in writing and consumer affairs cases are on file.

Filed Aug 20, 2025 · Engine, Fuel system · NY

2013 HYUNDAI SANTA FE SPORT TURBO. PAST/PRESENT SAFETY-SENSITIVE DEFECTS, NOTED OVER THE PAST SEVERAL YEARS: 1. One Confirmed Open Recall [CAMPAIGN #/the federal safety agency RECALL #—Recall 251 / 23V651000] (To Be Scheduled ASAP). 2. RPM/Propulsion Limp-mode Conditions: Vehicle periodically loses RPM READINGS on Dash and goes into the Propulsion sputtering/restricted-speed limp-mode hesitation condition. This condition may occasionally normalize by stopping, turning off engine and restarting. This intermittent RPM/Propulsion condition sometimes occurs, signified by a temporary sputtering/bucking while driving vehicle. ❓️CHECK STORED CODES ASAP...To Do. 3. Several times the car failed to accelerate predictably. For example, as when trying to accelerate up to highway speed from the on-ramp, leading to a fear of a near-miss, stalling and getting rear-ended. On such occasions, since attention is directed outside of the vehicle for safety, the state of the RPM READING on the dash has not been noted. ❓️CHECK STORED CODES ASAP...To Do.

Filed Aug 18, 2025 · Engine · NY

2013 Hyundai Santa Fe Sport 2.4L GDI engine failure due to known Theta II defect. Engine developed severe knocking and is unsafe to operate. The vehicle has experienced engine failure consistent with Hyundai’s recalled Theta II GDI defect (metal debris and bearing wear). Hyundai has refused to replace the engine, citing incomplete oil change records from a prior owner. This denial is unreasonable, as the defect is a manufacturer issue, not ordinary wear or maintenance neglect. The vehicle is unsafe to drive and at risk of stalling/fire. I request the federal safety agency investigate Hyundai’s refusal to honor its recall and extended warranty obligations.

Filed Aug 13, 2025 · Engine · WA

Driving at about 80 mph the engine stalled. Check engine and oil light turned on Dealer said there were no lights and no codes present and simply changed oil. 18 miles later engine light was flashing and engine started making horrible noise. Towed back to dealer and vehicle failed bearing test

Filed May 14, 2025 · Engine · MI

Just started stalling , internal engine damage

Filed May 12, 2025 · Engine · 105,000 miles · NJ

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated while driving at various speeds, the vehicle was jerking abnormally. Additionally, the contact stated that while accelerating from a complete stop, the vehicle responded after several attempts and was significantly sluggish while responding. There was no warning light illuminated. The vehicle was taken to the dealer, where the engine was replaced under an unknown recall; however, the contact stated that the vehicle had stalled several times while driving. The contact was able to pull to the side of the road. The vehicle was able to restart within 45 minutes after several attempts. The vehicle was taken to the dealer, where the contact was informed that the failure could not be duplicated. Additionally, the contact stated that the air conditioning system was inoperable. The vehicle was taken to the dealer, where it was diagnosed that the A/C hoses had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 105,000.

Filed Apr 22, 2025 · Engine · PA

2013 Hyundai Santa Fe Sport - [XXX] [XXX] System failed or malfunctioned: Sudden Engine Failure while driving at highway speed. Indication: Illumination of flashing warning light, while operating the vehicle on the highway. The vehicle entered into “protection mode”, driving at a slower acceleration and limited engine speed. Safety risks: Defective Engines: A manufacturing defect in the engine, particularly in the connecting rod bearings, can cause them to wear out prematurely. Potential for Stalling: the bearings wear, they can fail, potentially causing the engine to stall unexpectedly. Risk of Crash: a sudden stall while driving can significantly increase the risk of a crash. Engine Fire: in some cases, a damaged connecting rod can puncture the engine block, leading to oil leaks that can ignite on hot engine surfaces, causing a fire. Recalls: there have been multiple recalls related to these engine issues. Hyundai Motor America, the automaker has issued recalls for vehicles with these defective engines. Other Potential Issues: some 2013 Santa Fe Sports have been recalled for a potential fire risk due to a faulty ABS module. The problem has been inspected and identified by a certified Hyundai Dealer. The vehicle has not been directly inspected by the Manufacturer. Warning lamps, messages or other symptoms of the problem prior to the failure: Illumination of flashing warning light, while operating the vehicle on the highway. The vehicle entered into “protection mode” INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 21, 2023 · Engine · 58,000 miles · OH

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated while driving 25 MPH, the vehicle inadvertently stalled. There was no warning light illuminated. The vehicle failed to restart and was towed to an unknown dealer to be repaired under the federal safety agency Campaign Number: 17V226000 (Engine and Engine Cooling); however, the dealer charged a fee for the diagnostic testing. The contact declined to pay the fee and towed the vehicle to her residence. The manufacturer was notified of the failure and referred the contact to the dealer. The vehicle was towed back to the dealer, who informed the contact that there was sludge in the engine and charged a fee for additional diagnostic tests. The contact declined to pay the fee. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 58,000.

Filed Oct 2, 2023 · Electrical, Engine · 172,000 miles · MO

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that after starting the vehicle, several warning lights illuminated and remained illuminated. The contact stated that after restarting the vehicle several times, the warning lights turned off. The contact stated that while driving approximately 35 MPH, the vehicle lost motive power and stalled. The vehicle was towed to an independent mechanic who diagnosed the vehicle and determined that the engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were not contacted. The failure mileage was 172,000.

Filed Jun 5, 2023 · Engine · 190,000 miles · CA · fire

The contact owned a 2013 Hyundai Santa Fe Sport. The contact stated while driving 70 MPH, he detected fumes inside the vehicle and saw black smoke coming from the front of the vehicle. The vehicle lost motive power and stalled. The contact stated he was able to coast to the side of the roadway; however, upon exiting the vehicle, the contact saw flames coming from under the hood of the vehicle. The contact stated that the California Highway Patrol extinguished the fire. Neither a Fire nor a Police report was filed. The vehicle was towed to a tow yard. The vehicle was destroyed. The manufacturer was not made aware of the failure. The approximate failure mileage was 190,000.