On XXXX, my 2016 Hyundai Santa Fe Sport AWD (VIN [XXX], ~89,151 miles) developed a flashing check-engine light while driving — an active misfire condition. An OBD-II scan pulled code P1326, Hyundai's knock-sensor detection code for connecting-rod bearing wear in the Theta II engine family, the same defect family covered by Hyundai's lifetime bearing-warranty extension under Service Campaign T6G (TSB 22-01-023H-1). The vehicle was towed to Grand Hyundai of Canton (repair order #XXX). The dealer performed the bearing clearance test (BCT, TSB 21-EM-004H-1) on XXX, and recorded only "PASS." The printed result from the dealer's own GDS diagnostic tablet shows PASS with no numerical clearance values, even though this is a measurement-based test. The knock sensor was NOT replaced, and a KSDS software update was performed. The final invoice was $0. I have asked, in writing and repeatedly, for the actual numerical clearance measurements from that test. I have not received them. What I have received instead is a contradiction: On XXX, at vehicle pickup, the dealership's service manager told my wife, [XXX], that the dealership does not have access to those results and that only Corporate has those measurement results. When she asked him to put that statement in the service notes, he refused — "we will not put that in the notes" / "she could not write it down." Service advisor [XXX] was present beside the manager, relayed the request to him, and relayed the refusal back; she witnessed both the statement and the refusal. The same manager had told me by phone that only Hyundai Corporate has the measurements. On XXX, Hyundai National Consumer Affairs Supervisor [XXX] wrote the opposite: that "diagnostic, testing and reporting results done by the dealerships are retained by the independent location" and only the servicing dealership can provide them. She refused to provide the numbers herself and said INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The worst 2016 Hyundai Santa Fe Sport problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Engine48
- Electrical7
- Brakes6
- Fuel system5
- Airbags4
- Transmission3
- Body2
- Suspension2
- Acceleration1
- Driver assistance1
- Lights1
- Seat belts1
- Steering1
- Visibility1
- Wheels1
Specific symptoms reported on the 2016 Hyundai Santa Fe Sport
Check engine light 20Engine failure 20Knocking 15Fire or smoke 11Loss of power 9Stalling 8
Trouble codes owners of the 2016 Hyundai Santa Fe Sport mention
P1326 6
Recalls 1
Latches/locks/linkages: hood: latch
- What is wrong
- Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
- Risk
- If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
- Remedy
- Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1‑855‑671‑3059. Hyundai's number for the recall is 163.
Recall number 17V358000 · Recall details
See all 1 recalls for the 2016 Hyundai Santa Fe Sport
Defect investigations
Hyundai and Kia ABS Module Fires
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V‑520, 20V‑543, 21V‑161, 21V‑160, 21V‑303, 22V‑056, 22V‑810, and 23V‑651. Kia recalls 16V‑815, 20V‑518, 20V‑519, 21V‑137, 21V‑331, 22V‑051, 22V‑800, and 23V‑652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
AQ23002
Loss of Motive Power
the federal safety agency received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitionersâ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODIâs evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to the federal safety agency which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. Â There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in the federal safety agency's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, the federal safety agency does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing the federal safety agencyâs reasons for denial of the petition will be published. The reference numbers for the complaints to the federal safety agency cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to
DP22003
Technical service bulletins for the 2016 Hyundai Santa Fe Sport 135
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Intermittent airbag warning light and diagnostic trouble codes (DTCs) may be set
- Intermittent airbag warning light and DTC(s) B1763 (OCS ECU Defect), and/or B1764 (OCS Mat Defect) may be...
- In certain areas, a vehicle’s underbody may exhibit corrosion due to road salt usage
- Underbody corrosion due to road salt usage
- Some Hyundai vehicles may be equipped with a parking distance warning (PDW) sensor(s) that may trigger...
- Higher-than-expected engine oil consumption
- Higher-than-expected engine oil consumption
- The federal safety agency has issued an urgent safety advisory regarding dangerous, counterfeit...
- The federal safety agency has identified the presence of substandard and dangerous driver’s-side airbag...
- In response to this trend, we engineered a software upgrade that addresses the social media theft method...
What 2016 Hyundai Santa Fe Sport owners say
Most recent owner complaints, unedited.
I was driving from Tampa to Wesley chapel Fl I was going about 70 and was pushing a bit then slowed down right away then I was speeding a little back up and my car was dropping to speed by itself I pulled over to the shoulder and it was leaking radiator fluid I was trying to crank it to see if I can make it work then it started smelling bad in the car so I turned it off right away and it was Smokey
While driving I smelled gasoline then it turned to a burnt smell, engine turned off. Got to side of the road and engine caught fire. Firetrucks and police arrived. Car is totaled entire engine bay was up in flames. Car has been towed.
Odometer Fraud. The contact purchased a 2016 Hyundai Santa Fe Sport. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the Facebook Marketplace advertisement and odometer reading were 114,841 miles. However, approximately one hour later, it was discovered that the title listed the mileage at 170,395.
The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while the vehicle was parked, there was an abnormal knocking sound coming from the engine compartment. The vehicle was towed to a dealer where it was diagnosed that there was coolant in the engine and that the knock sensor detection system needed to be replaced. The dealer made the contact aware of Manufacturer Campaign Number: 953 and stated that the vehicle was not previously serviced under the campaign, so the vehicle could not be repaired. The manufacturer was notified of the failure. The failure mileage was approximately 111,000.
Was traveling along a city street with parked cars on the passenger side of my vehicle. Axle or wheel broke and veered into parked vehicle severing the engine wiring harness not allowing the airbag to deploy.
The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while driving approximately 65 MPH and attempting to overtake another vehicle, the vehicle lost automotive power and decelerated with the check engine, battery, and oil warning lights illuminated. The vehicle was parked on the shoulder of the highway, and smoke was coming from under the hood of the vehicle. The contact stated that after parking on the shoulder, the brakes erroneously activated, and the vehicle failed to move forward. The contact stated that moments later there were flames and smoke was coming from under the hood. The contact exited the vehicle. The Fire Department was called to the scene, and the flames were extinguished by the firemen. The vehicle was destroyed in the fire. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The manufacturer and local dealer were not contacted. The failure mileage was 105,225.
my BSD sensor would go on and off for the last several months when no one was around me. I work early and even when I was alone on the road the BSD would flash for 2-3 mins and go off.. then my fan for my air conditioner stopped. When I removed the glove compartment to see the wire connecting to the fan is "melted". When i called bob king hyundai, I was informed there was no recall. So, I attempted to fix the issue myself only to find the fuses (under the hood) are almost all bad. The tips of the fuses will not pull out. only the body of the fuse. With all this happening over the last several days and by the way, the vehicle passed inspection. I wanted to reach out as this is definitely a fire hazard and a huge concern.
The engine (2016 Hyundai Santa Fe 2.0L/2.4L Theta II GDI engine) suffered a catastrophic internal mechanical failure, specifically related to the known connecting rod bearing defect. The vehicle is currently un-driveable and is located at Serra Hyundai in Trussville, AL. The vehicle and its failed engine are available for inspection upon request. The engine suddenly failed and lost all power while driving at highway speeds in active traffic. I was forced to coast a dead vehicle across multiple lanes of traffic to the shoulder without any acceleration capability. Yes. The vehicle experienced a complete failure, cannot be restarted, and is currently parked at an authorized Hyundai dealership The vehicle is currently at an authorized Hyundai dealership awaiting a formal corporate inspection and evaluation for engine replacement approval. It has not been inspected by police or insurance. There were no long-term warning lamps, messages, or symptoms prior to the incident. The vehicle was operating normally until the exact moment of the failure, when the engine suddenly began knocking loudly, lost power, and stalled within seconds.
The vehicle is a 2016 Hyundai Santa Fe Sport. It had previously been included in an engine-fire-related recall/service campaign, and Hyundai replaced the engine between approximately October 2024 and January 2025 at about 113,000 miles. About 10,000 miles and 14 months later, the vehicle developed engine/performance problems. A Hyundai dealership service center performed about $6,500 in repairs, including installation of a new transmission, and represented that the engine and transmission had a lifetime guarantee. One day after the vehicle was returned from the dealership, the engine compartment caught fire while the vehicle was being driven. The fire rapidly escalated, the vehicle exploded/burned, and the vehicle was destroyed down to the frame. The occupants escaped, but the incident created an immediate risk of serious injury or death. The failed component appears to involve the engine, engine compartment, fuel/oil/electrical systems, transmission-related repair area, or another drivetrain component. The vehicle remains may be available for inspection depending on insurance/tow/storage status. The vehicle had recently been repaired and inspected by a Hyundai dealership service center. This incident raises concern that the recall-related engine-fire risk, replacement engine, recent dealership repairs, transmission installation, or related components may have failed and created a serious fire hazard.
Compare the 2016 Hyundai Santa Fe Sport
Other model years
Questions about the 2016 Hyundai Santa Fe Sport
Is the 2016 Hyundai Santa Fe Sport reliable?
Owners have filed 72 complaints about the 2016 Hyundai Santa Fe Sport, fewer than a typical Santa Fe Sport model year.
What is the 2016 Hyundai Santa Fe Sport year score?
The 2016 Hyundai Santa Fe Sport scores 79 out of 100 (average). The score compares it with the other model years of the Hyundai Santa Fe Sport: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2016 Hyundai Santa Fe Sport?
Engine and cooling, with 48 complaints, typically around 105,225 miles. Next is electrical (7).
How many recalls does the 2016 Hyundai Santa Fe Sport have?
1 recall, covering latches/locks/linkages.
What year does the Hyundai Santa Fe Sport have bad engine?
The Hyundai Santa Fe Sport model years with the most engine complaints are 2017 (221 complaints), 2018 (208 complaints) and 2013 (121 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Hyundai Santa Fe Sport?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history