2016 Hyundai Santa Fe Sport: check engine light

Filed Nov 2, 2026 · Engine · GA

On XXXX, my 2016 Hyundai Santa Fe Sport AWD (VIN [XXX], ~89,151 miles) developed a flashing check-engine light while driving — an active misfire condition. An OBD-II scan pulled code P1326, Hyundai's knock-sensor detection code for connecting-rod bearing wear in the Theta II engine family, the same defect family covered by Hyundai's lifetime bearing-warranty extension under Service Campaign T6G (TSB 22-01-023H-1). The vehicle was towed to Grand Hyundai of Canton (repair order #XXX). The dealer performed the bearing clearance test (BCT, TSB 21-EM-004H-1) on XXX, and recorded only "PASS." The printed result from the dealer's own GDS diagnostic tablet shows PASS with no numerical clearance values, even though this is a measurement-based test. The knock sensor was NOT replaced, and a KSDS software update was performed. The final invoice was $0. I have asked, in writing and repeatedly, for the actual numerical clearance measurements from that test. I have not received them. What I have received instead is a contradiction: On XXX, at vehicle pickup, the dealership's service manager told my wife, [XXX], that the dealership does not have access to those results and that only Corporate has those measurement results. When she asked him to put that statement in the service notes, he refused — "we will not put that in the notes" / "she could not write it down." Service advisor [XXX] was present beside the manager, relayed the request to him, and relayed the refusal back; she witnessed both the statement and the refusal. The same manager had told me by phone that only Hyundai Corporate has the measurements. On XXX, Hyundai National Consumer Affairs Supervisor [XXX] wrote the opposite: that "diagnostic, testing and reporting results done by the dealerships are retained by the independent location" and only the servicing dealership can provide them. She refused to provide the numbers herself and said INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 10, 2026 · Engine · 105,225 miles · SC · fire

The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while driving approximately 65 MPH and attempting to overtake another vehicle, the vehicle lost automotive power and decelerated with the check engine, battery, and oil warning lights illuminated. The vehicle was parked on the shoulder of the highway, and smoke was coming from under the hood of the vehicle. The contact stated that after parking on the shoulder, the brakes erroneously activated, and the vehicle failed to move forward. The contact stated that moments later there were flames and smoke was coming from under the hood. The contact exited the vehicle. The Fire Department was called to the scene, and the flames were extinguished by the firemen. The vehicle was destroyed in the fire. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The manufacturer and local dealer were not contacted. The failure mileage was 105,225.

Filed May 27, 2026 · Engine · CO

The engine powertrain system, specifically the internal engine lubrication, timing chain, and camshaft sensors. The vehicle's Theta II engine suffers from systemic, excessive oil consumption, which starved the engine of lubrication. This caused the timing chain to stretch and mechanically fail, and compromised the camshaft sensors. The vehicle is currently un-repaired and is available for inspection upon request at Hyundai of Downtown LA. While driving, the engine suddenly stalled and completely shut off mid-drive without warning. This caused an immediate loss of motive power and a dangerous reduction in steering and braking control while surrounded by active traffic. Operating a vehicle that randomly shuts down on public roads presents an extreme, life-threatening safety hazard to myself, my passengers, and other drivers. Furthermore, the dealership is attempting to force me to drive the vehicle for an additional 1,000 miles in this stalling, un-repaired condition to complete a corporate oil test, compounding the safety risk. The failure and safety hazard have been physically confirmed and diagnosed by an authorized dealership: Hyundai of Downtown LA (3850 S Figueroa St, Los Angeles, CA 90037). Their service department mechanically diagnosed the physical failure of the camshaft sensors, a stretched timing chain, and severe engine oil starvation. There were absolutely no dashboard warning lights, check engine lights, low oil pressure lamps, or messages prior to the engine stalling and shutting off. The vehicle computer failed to trigger any diagnostic trouble codes (DTCs) or dashboard warnings to alert me to the low oil level or the impending mechanical timing failure before the vehicle completely shut down mid-drive.

Filed May 4, 2026 · Engine · NV

My car only has 93,000 miles on it. I was driving home from work and all of a sudden the check engine light came on while I’m on the freeway. I made it home and went to research then all of a suddenly the check engine light would just start flashing. I got it checked by a mechanic. They said that there was metal shavings in the oil which I have no clue how that would happen and that there was a code for knocking.

Filed Feb 17, 2026 · Engine · HI

The engine light started blinking and my car would not accelerate anymore. I took it to the mechanic immediately, who said that there was an engine recall. I contacted the dealership, but they cannot do an initial inspection for more than 2 months. It would likely take another 2-3 months after the inspection before the engine can be replaced. I called Hyundai and they confirmed that my vehicle should be covered under an extended warranty based on the service history and error code from my car (TXXI for the Theta 2 engine - knock sensor detection, code p1326). However, Hyundai will not provide any help until the vehicle is inspected by a dealership. The dealership completely refuses to look at my car as they are busy. I live on an island, so the only other Hyundai dealership is two hours away. They will not answer any of my calls. I'm expected to figure out how to commute to work alone for the next two months, but since I live in a rural area, there are no alternative transportation options. An independent mechanic confirmed and reproduced the issue. The car is unsafe to drive. The dealer will not inspect my component in a reasonable time frame, much less repair it despite the fact that it is covered under extended warranty. The car was driving normally prior to the issue, and I did not notice any problems until the engine light started blinking. I have the car available for inspection.

Filed Jan 30, 2026 · Engine · 132,000 miles · FL

The contact owns a 2016 Hyundai Santa Fe Sport. While driving at an undisclosed speed, there was an abnormal odor coming from the vehicle. The contact stated that the engine was consuming an excessive amount of engine oil. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that on a separate occasion, while driving at an undisclosed speed, there was an abnormal sound coming from the engine. The vehicle was pulled over to the side of the road; and the check engine warning light illuminated. A handheld scanner was used to retrieve DTC: P1326 (KSDS – Connecting rod bearings failure). The vehicle was towed to the residence, and then towed to the dealer. The dealer diagnosed the vehicle and informed the contact that the rod bearings had failed, causing engine failure. The dealer notified the manufacturer of the failure; however, the manufacturer declined to repair the vehicle. The manufacturer informed the contact that the prior owner had submitted a complaint regarding the failure in January of 2024. The vehicle remained at the dealer unrepaired. The failure mileage was approximately 132,000.

Filed Dec 3, 2025 · Engine · IN

September 3rd, 2025, my engine failed, for the second time and left me stuck at a busy intersection, in the middle lane and can't move. The first time my engine failed (2022/same vehicle), I was about the get on the highway and it just stopped in the middle of the road right before getting onto the highway. Both times I've had to get out in traffic in order to move my vehicle. I'm causing a stop to traffic or a stop in the flow of traffic. In September when this happened, I had cops, mechanics and pedestrians stopping to help (thank goodness), but that caused a stop in the flow of traffic. Any of us could have been struck by a vehicle. It was also around 10/11pm at night There is an open recall on my vehicle and more specifically, the Theta II engine in my vehicle. It does not show when my VIN number is put in, but it's nationally known that there is an open recall and also a class action suit that was just settled in 2021 granting all customers with "Class vehicles" a lifetime extended warranty on the engines. They make it so that it's not that easy to just search and see there is a recall, but there is. My car has been at the Hyundai dealership since 9/4/25. So, yes it has been inspected by the manufacturer, and they confirmed that the diagnostic came back as positive for the recall. Yes, my check engine light would come on and off starting the end of 2024. Starting in April of 2025 I started having smoke come out of my exhaust and oil burning in days. All the while I have no puddle of oil underneath my car. I took it into Hyundai at that point, and they told me until my engine light was flashing and my car had stopped, they wouldn't be able to do anything in regard to the engine. Now my car has been there, I've provided service receipts that show proof of regular maintenance, I have the KSDS system installed, and they are denying my claim to replace my engine.

Filed Nov 25, 2025 · Engine · GA

There was no low oil indicator light, no smoke, and no oil on the garage floor. My wife was driving the vehicle on I-285 in Atlanta, returning from the ATL airport, when the vehicle began to lose power and started jerking and surging; the check engine light began flashing. She had to take surface streets to get home because the loss of power made the vehicle unsafe to drive on the freeway. When she arrived home, I checked the engine oil dipstick and it was completely dry. I took the vehicle to the garage that performs my oil changes, and they mentioned this is an ongoing issue with Hyundai—the vehicle is burning oil. The low oil level caused the knock sensor to trigger, which in turn caused the check engine light to flash and reduced power in an attempt to protect the engine. I never received any notification regarding a recall for this issue, and now my motor is more than likely damaged since I can still hear knocking when the engine runs at higher RPMs. My vehicle has over 100K miles, and I have never had an issue with it until now.

Filed Sep 9, 2025 · Engine · 130,000 miles · MA

The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while driving uphill, the vehicle failed to accelerate above 10 MPH. There was a burning odor coming from the vehicle with the check engine warning light illuminated. The contact stated that the engine had previously been replaced, but the failure persisted. The vehicle was towed to the dealer, who determined that the knock sensor needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.

Filed Aug 22, 2025 · Engine · GA

Engine siezed, causing me to have to tow my vehicle. I was moved in the military to Germany in 2019, I had to have no open recalls on the car before I shipped it overseas. I completed a recall on the 5th of January 2019. On the 10th of January, Hyundai activated another recall on the vehicle. I was unaware of this recall and shipped my vehicle to Germany on the 16th of January 2016. The car returned from Germany in September of 2023. I had zero issues with this vehicle while I was over there, no check engine lights, no warning lights, nothing. I always changed the oil when told to do so, and when I returned from Germany it was the same thing, no issues and always completed oil changes when it was needed. I had no idea of the recall, Hyundai was sending it to an address I no longer lived at. I had no reason to take my vehicle to Hyundai to check for recalls. On [XXX], my vehicle engine stopped working at 84622 miles, and Hyundai said that it would be covered under warranty, but because I did not complete the recall that was activated on the 10th of January 2019, they denied the warranty and now my car is worthless. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 24, 2025 · Engine, Fuel system · NC

My engine seized at approximately 80mph on the interstate [XXX] ). The engine light came on only after I lost power. I only avoided a multiple car accident due to quick reaction and taking an exit ramp. Police came to my stalled vehicle and helped my push it off a major road to a nearby parking lot. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 16, 2025 · Engine · CA

The vehicle lost power, and the engine started to make a knocking noise, and the check engine light came on. I plugged in the obd2 scanner and the p1326 code came out. It was a knock sensor that needed to be replaced. I replaced the sensor that the issue got worse. I looked up online about this issue and then I found a video of that explained the incident. The manufacture of the crank at the factory did not properly clean the holes of the oil passages. When they machined it, all the files they don't clean them good enough, so they go to one side and plug up the oil passages and it doesn't get oil. we were on the highway when this issue started and it lost power. The problem has not been solved because the Hyundai dealer and the corporate office did not want to help me with this issue. They claim that my title is salvaged but I contacted the DMV, and they confirmed that my title is clean and there is no issue. The second time they said the vehicle was used as a rental and that automatically disqualifies the vehicle's warranty. The vehicle has not been inspected. No warning at all until the day it happened. I just purchased this vehicle seven months ago for seven thousand dollars and this happened.