2017 Hyundai Santa Fe Sport: check engine light

Filed Oct 15, 2026 · Engine · IN

Started car to reverse out of parking space and it started jerking as I accelerated. Drove jerkily the few blocks I had to go to make it home. Did not drive again but upon starting it the check engine light came on. Contacted Hyundai customer care who told me my car was covered under two extended warranties for a well documented engine failure on this exact vehicle - Hyundai Santa Fe Sport 2017. I’ve been researching and Hyundai knows about this problem and it had been through the courts after group legal action was taken. Hyundai refuses to pay for the car they know is a failure to be diagnosed. I cannot afford to have the car diagnosed especially not for a problem that Hyundai and half the world know (and have documented) is Hyundai’s fault. Vehicle can not be driven.

Filed Oct 12, 2026 · Electrical, Engine · FL

I was driving my car and it showed no signs of any issue but the engine light came on and started blinking so I pulled over and got it towed to a mechanic. He told me that I would need a new engine that would cost me $8000. I looked into it and found that there was a defect with my vehicles engine and that if I took it to a dealership, I could possibly get it covered 100% so I did that and then they covered it and when I got the vehicle back, it had an issue every time I drove it where it was kind of speeding up and jerking when I drove it, I took it back after I told them what happened and then they told me that my catalytic converter was bad and needed to be replaced. I ended up paying $1500 to get that replaced and when I got the car back again it’s still jerking and doing the same exact thing even worse. I contacted them. They told me to bring it back which I did and they told me that it needed a software update that was not available so that I would just have to be patient. They told me that anytime I wanted to drive it I had to let it warm up for 5 to 10 minutes and that it wouldn’t do that. I’ve had my vehicle back for over two weeks and it doesn’t matter if I warm it up or not it’s still doing the same thing. I do not feel safe driving this vehicle and I have not been giving any resolution by either the dealership or by the consumer affairs case manager that I have been working with on this. This has been an ongoing issue for three months now. It’s costed me hundreds of dollars in Ubers because I don’t feel it’s safe to drive.

Filed Jul 22, 2026 · Engine, Fuel system · TX

We have a 2017 Hyundai Santa Fe Sport with a refurbished engine due to a past class act settlement, we were notified by Hyundai to bring in the vehicle for Service campaign 9C2 to update the Engine Control Module (ECM) Software for vehicles equipped with the (2.4 GDI) Theta II refurbished engine, which we have. The morning after we updated the 9C2 software, after starting our car cold for the first time in the am, our car went into limp mode, shaking very badly, it would not accelerate above 20 MPH, it had a lot of trouble shifting from 1st to 3rd gear and acted like it was going to stall out and then die in the middle of the road while I was in the car with my 2 children. The dealership we took it to was not able to duplicate the limp mode, but has documented that they did witness hesitation and sluggishness while test driving it. I cannot validate that it was test driven cold immediately as requested as all their test drives were done without me. Due to the vehicle not accelerating as it should normally, I feel the vehicle is very unsafe and unreliable as well. I’m willing to provide more documentation, and our car is available for further inspection. I did request the help of a Hyundai customer relations case manager who stated Hyundai is aware of all of the drive-ability issues I have stated and he said they are hoping to provide another software update, but that time frame is unknown. Dealership mechanic stated the same thing and believes our issue is related to the 9C2 update. The manufacture has not inspected the vehicle, but we would absolutely love them to if they would. There have been no check engine lights come on before or after this update, only misfire codes came up after the update which dealership has those, and since the dealership was unable to witness it going into limp mode while driving it, they could not gain the much needed data that pinpoints the exact problem. We were advised to warm up car and rev up the RPM to above 2,000 before driving.

Filed Jun 22, 2026 · SC

What component or system failed or malfunctioned, and is it available for inspection upon request? Multiple systems have failed sequentially — engine (replaced at ~84,000 miles), catalytic converter (replaced post engine replacement), and transmission (currently stalling, pending replacement authorization from Hyundai Corporate). The vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? The vehicle stalls during the first few miles of every drive before stabilizing. This creates an immediate risk of accident on public roads, particularly at intersections, highway on-ramps, and in traffic. Despite this known safety hazard, the dealership returned the vehicle to me unrepaired on June 22, 2026, and deemed it safe to drive. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Fort Mill Hyundai (805 Gold Hill Road, Fort Mill, SC 29708) has confirmed they can physically feel the stalling issue but stated they do not have sufficient data to submit to Hyundai Corporate for transmission replacement authorization. An independent mechanic also previously confirmed the engine issue that the dealership initially dismissed. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes. Fort Mill Hyundai, an authorized Hyundai dealership, has inspected the vehicle multiple times over several years. The dealership is actively coordinating with Hyundai Motor America Corporate regarding the transmission replacement. Invoice reference: [XXX], dated June 22, 2026. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Check engine and brake warning lights first appeared at approximately 64,000 miles. These lights recurred repeatedly every ~1,000 miles despite multiple dealership visits. Subsequent symptoms included engine hesitation and loss of power, fol INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INF

Filed May 12, 2026 · Engine · NY

I was driving on a main road at 55-60 mph with my daughter and grandchildren in the car and had a sudden loss of power. I was almost hit from behind. The check engine light started blinking. And the car went into limp mode. I had to limp it to the nearest place to safely get off the road so as not to put my family in any other danger.There is not enough shoulder on the road to pull over safely. It was very stressful. Was able to get it in someone's driveway and then eventually towed to Auburn,NY Hyundai/Chevrolet where it is currently. It would not turn over to start again. It does have battery power. I am waiting to hear from the service techs as to what they think is wrong. They advised me that there is a $199 per hour diagnostic fee. I also told them that we noticed metal flakes in the oil when we checked it. I feel I should mention that the vehicle went into limp mode a few weeks ago also and the dealership told me the knock sensor was bad. I had that replaced at that time.

Filed May 5, 2026 · Engine, Transmission · NY

COMPONENT FAILED: Theta II 2.4L GDI engine connecting rod bearings. Vehicle has 95,000 miles. Engine available for inspection in [XXX] . SAFETY RISK: Engine knock + limp mode at 1500 RPM caused sudden loss of power on highway. Oil consumption 1L/700km risks catastrophic engine seizure while driving. CONFIRMED BY DEALER: Independent service center confirmed DTC P0010 from metal debris. Hyundai Motor America Case #42623761 confirmed recall coverage but refuses remedy. INSPECTION: Manufacturer aware via Case #42623761. Local Hyundai dealers non-responsive. No police/insurance inspection. WARNING SYMPTOMS: Engine knock started at ~94,000 miles. Check Engine Light with DTC P0010. Progressive oil consumption. Limp mode activated at 95,000 miles. HYUNDAI VIOLATION: Hyundai confirmed via email they refuse to honor Safety Recall 162 / Service Campaign 966 Lifetime Warranty for VIN [XXX] despite all symptoms matching recall description. Request the federal safety agency compel Hyundai to authorize Bearing Clearance Test and engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 20, 2026 · Engine · GA

We have a 2017 Hyundai Santa Fe with 130k miles on it. It has the 2.4 engine with known manufacturing defects. We are the 2nd owner and timely & proper maintenance was completed on it since it was new. My [XXX] driver was operating the vehicle on Interstate 75 in Middle Georgia when the vehicle started running very rough, slowed down dramatically and the check engine light started blinking. She was blessed that a large truck didn’t run her over as she tried to move to the side of the roadway. We called a tow truck to take it to the nearest Hyundai dealership- ALM Hyundai of Warner Robins, GA. They inspected the vehicle and stated that the engine had messed up and they wouldn’t replace it since the vehicle had 130k miles and outside their window for 120k mile replacement. We purchased the vehicle from the original owner in 2022. We verified that it had timely and proper maintenance on it. We were also aware of a potential engine issue but verified with a Hyundai service advisor at Five Star Hyundai in Macon, Ga that the vehicle would be eligible for engine replacement if it messed up due to a manufacturing defect as long as proper maintenance was completed. We noticed that the vehicle was significantly burning oil at around 110k miles and regularly had to put oil in it to make sure it would not run dry. We did have the safety recall performed on it for the engine knock issue that Hyundai mandated. These vehicles are a major safety hazard on the roadway and these effected engines should be replaced by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 5, 2026 · Engine, Fuel system · NC

Component: Engine (Theta II 2.4L GDI) / connecting rod bearing-related failure risk with abnormal internal oil loss. The vehicle is available for inspection upon request (engine, oil level condition, diagnostic history, and dealer records). Safety risk: While driving on the highway (approx. 70 mph), the vehicle displayed a low oil warning, and I experienced concern for potential engine seizure/stalling and sudden loss of power, which could cause a crash. I reduced speed and sought service. This condition presents an ongoing safety risk because sudden engine failure can occur without adequate warning. Dealer confirmation: The problem was confirmed by a Hyundai dealer. After a routine oil change, the low oil warning appeared within ~1,700 miles. A Hyundai service center inspected the vehicle and documented the engine was approximately 3 quarts low with no external leaks, indicating internal loss/engine deterioration rather than a leak. Hyundai then required additional steps (combustion chamber cleaning and monitored mileage), and the abnormal internal oil loss condition persisted. Manufacturer inspection: The vehicle has been inspected by Hyundai dealerships, and Hyundai performed campaign-related actions, including KSDS/ECM update (T3G) and later knock sensor replacement. No police or insurance inspection. No crash or injury occurred. Warning lamps/symptoms prior to failure: Prior symptoms included a Check Engine Lamp with DTC P1326 (KSDS-related) documented by Hyundai service in 2025, followed by continued abnormal internal engine condition. The low oil warning occurred while the vehicle was in motion (highway speed). The issue remains unresolved, and I do not feel the vehicle is safe to operate due to seizure/stall risk. Additional: I reported this as a safety defect because similar Theta II engine issues are widely reported and can result in stalling, seizure, or engine fire. Hyundai denied engine replacement assistance despite the documented condition.

Filed Nov 25, 2025 · Engine · CO

The engine of our 2017 Hyundai Santa Fe Sport has been significantly problematic since we first purchased the vehicle in 2017. These issues have been well documented by other Hyundai owners and have resulted in class action lawsuits. After purchasing our vehicle new from dealer, it began experiencing difficulties, consuming large amounts of oil, spewing smoke from the tailpipe, leaving metal shavings in the engine oil, failing to start, and at times going into a protection mode to keep the engine from further damage and restrict speed above 15 miles per hour. The vehicle had to be towed multiple times at our own expense. Hyundai delayed replacement of the engine for months resulting in thousands of additional miles being put on the vehicle under unsafe operating conditions. Hyundai reluctantly replaced the engine in February of 2024. What appears to not be well-documented in the federal safety agency complaints are the impacts of these engine issues to other Hyundai components and parts. Hyundai replaced our original engine but did not replace the engine’s catalytic converter. 20 months later, the check engine light has illuminated again as a direct result of oil sludge and buildup from accelerated oil consumption. In November 2025, the dealership identified the fault code P0420 for catalyst efficiency system below threshold. We have experienced a loss of acceleration, increased fumes, and decreased fuel efficiency as a result of the catalytic converter failure, and believe the vehicle is no longer safe to drive at high speeds on freeways. The dealership has confirmed damage to the catalytic converter and has quoted a replacement fee that is $5000, almost $1000 higher than other dealerships in our area. We asked for the dealership to submit a request to HMA for goodwill assistance and were denied on November 24th. We strongly believe that Hyundai is responsible for both the damage to the catalytic converter as well as the safety concerns caused by this issue.

Filed Oct 3, 2025 · Engine · TN

On [XXX, I was driving on the interstate when my engine seized and the car lost all power, leaving me stranded on the side of the road on a busy exit at night. This was very dangerous to myself and others. I purchased this car in July of 2023 with 69,000 miles in good condition. I immediately made an appointment to take care of the recalls and updates to this car, which were performed February 2024 due to this being the first available appointment. Also, at my first oil change (3,000 miles after the previous oil change) I was told by the mechanic that there was absolutely no oil in my car. Since then I have had to put SEVERAL quarts of oil in between each oil change, costing me hundreds of dollars. Then June of 2024, the P1326 code flashed on my car and it went into limp mode also while I was driving on a busy street, putting myself and others in danger. I took it to the dealership and was advised to continue driving it and there was nothing they can do until my engine fails. I also brought up the oil consumption issue and was told that even if I did an oil consumption test (at my cost), there was nothing they could do. I was advised by my service advisor not to do a consumption test. I took his advice and continued to drive my car, adding countless quarts of oil weekly to my car. Fast forward to September 2024, when my engine light came on due to misfires in cylinder 3&4 and I took it to a local mechanic due to the incredibly long wait for an appointment at Hyundai. I was told all 4 spark plugs were oil fouled due to excessive oil consumption. This happened again July of 2025. My mechanic advised me that there was nothing to do about it, but that this would continue to happen due to the oil consumption issue. Now Hyundai is refusing to take responsibility for this engine that has had documented issues resulting in class action lawsuits and safety issues for myself and others and refusing any financial assistance. No warning lamps were on before incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATIO

Filed Sep 28, 2025 · Engine · CT

On [XXX], around [XXX] I was driving my car on [XXX] and I suddenly experienced "Check Engine Flashing" and engine misfiring. I was driving ~70-75 mph in the left lane. I immediately turned ON the Hazard lights and somehow manage to get to the right lane and safely stopped the car in open space on the side. This could have resulted in a very serious accident as I had my whole family in the car with me. Hyundai Motor Company must be held accountable for this type of engine quality issue. My car has 119580 miles. I had always car maintenance done at Hyundai Dealerships to make sure that it is maintained as per the company recommended. The Catalytic converter in my car was changed by the Hyundai Dealership (Key Hyundai Manchester, CT) at approximately 96000 miles as it had gone bad in April of 2024. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 22, 2025 · Engine · GA

At first I noticed that there’s a strong smell of oil when I am driving it. The engine was consuming a large amount of oil so much so that I have to keep an extra bottle of oil in my car. I will be driving and oil light shows up and I have had an oil change not just a week prior. I had an independent mechanic to come check it and he said a lot of oil is leaking out into the engine because, I never see any oil on the ground. Then finally the check engine light is on, the steering is shaking heavily and I have stopped driving it for my safety and that of others on the road.