2017 Hyundai Santa Fe Sport: engine knocking or ticking

Filed May 12, 2026 · Engine · NY

I was driving on a main road at 55-60 mph with my daughter and grandchildren in the car and had a sudden loss of power. I was almost hit from behind. The check engine light started blinking. And the car went into limp mode. I had to limp it to the nearest place to safely get off the road so as not to put my family in any other danger.There is not enough shoulder on the road to pull over safely. It was very stressful. Was able to get it in someone's driveway and then eventually towed to Auburn,NY Hyundai/Chevrolet where it is currently. It would not turn over to start again. It does have battery power. I am waiting to hear from the service techs as to what they think is wrong. They advised me that there is a $199 per hour diagnostic fee. I also told them that we noticed metal flakes in the oil when we checked it. I feel I should mention that the vehicle went into limp mode a few weeks ago also and the dealership told me the knock sensor was bad. I had that replaced at that time.

Filed May 5, 2026 · Engine, Transmission · NY

COMPONENT FAILED: Theta II 2.4L GDI engine connecting rod bearings. Vehicle has 95,000 miles. Engine available for inspection in [XXX] . SAFETY RISK: Engine knock + limp mode at 1500 RPM caused sudden loss of power on highway. Oil consumption 1L/700km risks catastrophic engine seizure while driving. CONFIRMED BY DEALER: Independent service center confirmed DTC P0010 from metal debris. Hyundai Motor America Case #42623761 confirmed recall coverage but refuses remedy. INSPECTION: Manufacturer aware via Case #42623761. Local Hyundai dealers non-responsive. No police/insurance inspection. WARNING SYMPTOMS: Engine knock started at ~94,000 miles. Check Engine Light with DTC P0010. Progressive oil consumption. Limp mode activated at 95,000 miles. HYUNDAI VIOLATION: Hyundai confirmed via email they refuse to honor Safety Recall 162 / Service Campaign 966 Lifetime Warranty for VIN [XXX] despite all symptoms matching recall description. Request the federal safety agency compel Hyundai to authorize Bearing Clearance Test and engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 21, 2026 · Brakes, Engine · SC

My ABS Lights the triangle with the ! In the middle goes in and off the down hill control light and the sweet control light all go on when the ABS light goes on my oil was completely dry had to add two quarts while the engine was ticking when started and when accelerating it was making a clicking noise I still had 3000 miles before needed an oil change but like I said it was bone dry and then the drivers seat was going back and not wanting to come back up I’ve only had the car 42 days and it’s having all kinds of problems

Filed Jan 20, 2026 · Engine · GA

We have a 2017 Hyundai Santa Fe with 130k miles on it. It has the 2.4 engine with known manufacturing defects. We are the 2nd owner and timely & proper maintenance was completed on it since it was new. My [XXX] driver was operating the vehicle on Interstate 75 in Middle Georgia when the vehicle started running very rough, slowed down dramatically and the check engine light started blinking. She was blessed that a large truck didn’t run her over as she tried to move to the side of the roadway. We called a tow truck to take it to the nearest Hyundai dealership- ALM Hyundai of Warner Robins, GA. They inspected the vehicle and stated that the engine had messed up and they wouldn’t replace it since the vehicle had 130k miles and outside their window for 120k mile replacement. We purchased the vehicle from the original owner in 2022. We verified that it had timely and proper maintenance on it. We were also aware of a potential engine issue but verified with a Hyundai service advisor at Five Star Hyundai in Macon, Ga that the vehicle would be eligible for engine replacement if it messed up due to a manufacturing defect as long as proper maintenance was completed. We noticed that the vehicle was significantly burning oil at around 110k miles and regularly had to put oil in it to make sure it would not run dry. We did have the safety recall performed on it for the engine knock issue that Hyundai mandated. These vehicles are a major safety hazard on the roadway and these effected engines should be replaced by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 5, 2026 · Engine, Fuel system · NC

Component: Engine (Theta II 2.4L GDI) / connecting rod bearing-related failure risk with abnormal internal oil loss. The vehicle is available for inspection upon request (engine, oil level condition, diagnostic history, and dealer records). Safety risk: While driving on the highway (approx. 70 mph), the vehicle displayed a low oil warning, and I experienced concern for potential engine seizure/stalling and sudden loss of power, which could cause a crash. I reduced speed and sought service. This condition presents an ongoing safety risk because sudden engine failure can occur without adequate warning. Dealer confirmation: The problem was confirmed by a Hyundai dealer. After a routine oil change, the low oil warning appeared within ~1,700 miles. A Hyundai service center inspected the vehicle and documented the engine was approximately 3 quarts low with no external leaks, indicating internal loss/engine deterioration rather than a leak. Hyundai then required additional steps (combustion chamber cleaning and monitored mileage), and the abnormal internal oil loss condition persisted. Manufacturer inspection: The vehicle has been inspected by Hyundai dealerships, and Hyundai performed campaign-related actions, including KSDS/ECM update (T3G) and later knock sensor replacement. No police or insurance inspection. No crash or injury occurred. Warning lamps/symptoms prior to failure: Prior symptoms included a Check Engine Lamp with DTC P1326 (KSDS-related) documented by Hyundai service in 2025, followed by continued abnormal internal engine condition. The low oil warning occurred while the vehicle was in motion (highway speed). The issue remains unresolved, and I do not feel the vehicle is safe to operate due to seizure/stall risk. Additional: I reported this as a safety defect because similar Theta II engine issues are widely reported and can result in stalling, seizure, or engine fire. Hyundai denied engine replacement assistance despite the documented condition.

Filed Nov 19, 2025 · Engine · MO

We had the oil changed like always and shortly after I was checking the oil and it was not even on the dipstick so I added some and checked for leaks anywhere did not see any than we had problems with it barely accelerating so took it to dealership the performed the anti knock sensor upgrade for free and when I asked about the oil consumption they said that I needed to do a engine clean and all kinds of stuff came to like $400 so I had them do it because I can not have my wife stranded somewhere after all that they changed the oil again that was another $80 they said to bring it back at 1000 miles for them to check brought it back at 700 miles already used 1.5 qts they said engine is junk but cannot get anything done about because it had at the time 120000 miles

Filed Nov 11, 2025 · Engine · NC

The vehicle’s engine is experiencing excessive internal oil consumption that poses a serious safety risk while driving. After a routine oil change performed by an authorized Hyundai dealer, the engine oil warning light illuminated within about 1,700 miles. Upon inspection by another Hyundai service center, technicians confirmed that the engine was burning oil abnormally and was three quarts low, with no external leaks. This issue was documented in the dealer’s repair order, which states “vehicle is burning excessive oil.” The problem has been reproduced and confirmed by a Hyundai dealer. The vehicle is equipped with the Theta II 2.4L GDI engine, which is already covered under Hyundai’s KSDS (Knock Sensor Detection System) extended engine warranty due to known internal mechanical defects such as bearing wear and oil consumption. Despite this, the manufacturer has declined to replace the engine. The excessive oil burning occurs rapidly and triggers the low-oil warning light while the vehicle is in motion, creating a risk of engine seizure and sudden loss of power that could lead to a crash. The defect remains unresolved. Warning lights for low oil level appeared multiple times beginning in 2025, shortly after the KSDS update and knock-sensor replacement.

Filed Oct 22, 2025 · Engine · IA

Engine is experiencing excessive oil consumption. Engine in question is a Theta II 2.4 GDI. Losing a qt every 400-500 miles. The car has less than 75,000 miles on it. The vehicle has been religiously maintained, oil changes every 5,000 miles or less. However because we are the second owners, even though it was purchased in 2020 when it had less than 30,000 miles, the warranty does not apply. The engine type has several manufacturer defects. Hyundai is using the technicality of a non-transferable warranty to get out of the fact that they knowingly put a defective engine in vehicles. By the time the oil consumption issue is apparent, it is too late, and you need a full unit replacement. I was quoted $9,000 - $10,500 by two Hyundai dealerships to replace the engine. I've spoken to non-Hyundai shops and the only way to truly correct the issue is to replace the engine with a remanned engine since the actual engines are manufactured poorly from go, so even a new one could be defective. There are million of these engines across several KIA and Hyundai vehicles. They cause undue burden to consumers. Hyundai and Kia do not stand by their product and consumers are being hurt. Instead of having an asset I thought was worth $10,000 an I could drive for several years and tens of thousands, if not one hundred thousand plus, more miles, I have a vehicle that is a ticking time bomb that would cost as much to fully fix the problem as it is worth. A simple google for Kia Optima, Kia Sorento, Kia Sportage, Hyundai Sante Fe, Hyundai Sante Fe Sport, Hyundai Sonata or Hyundai Tucson + Theta II 2.4 GDI will yield more than enough results to show how prevalent the engine failure + oil consumption issue is. If left unfixed the engine will consume too much oil and seize, or lead to other problems with vehicle rendering unsafe to drive.

Filed Sep 8, 2025 · Engine · CO

The engine starting consuming a quart of oil in less than 500 miles of recent oil change. Car has 114,000 miles and due to oil consumption lifters are now ticking louder. I was not notified of the class action lawsuit that happened due to this same issue. Oil pressure light came on

Filed Aug 6, 2025 · Engine · 67,000 miles · SC

The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power after the engine made an abnormal sound. The check engine warning light was illuminated. The vehicle was taken to a local independent mechanic to be diagnosed, but the cause of the failure could not be determined. The vehicle was not repaired, and the failure reoccurred. The vehicle was towed to a local dealer, where DTC: P1326 was retrieved, and the vehicle was diagnosed with knock sensor signal range error, metal shavings into the engine, and other unknown failures. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 67,000.

Filed Jul 22, 2025 · Engine · MN

Car stopped running 4 months ago and had it towed to the shop and they did a Knock sensor update and sent us back with it. 4 months later check engine light comes on and take it in and they recommend a new engine and this car has a class action and they’re saying we don’t qualify. They’re saying it’s the piston rings. The car burns oil like crazy. Over 5 quarts in 2,500 miles consistently and the oil light never comes on. I have 2 kids that ride in this car for it to just die or for the engine to start fire is a risk I am not willing to take.

Filed Jul 15, 2025 · Engine · 80,000 miles · FL

The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated while driving 40 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light was illuminated. The contact used a personal handheld scanner to scan the vehicle and retrieved DTC: P1326 which indicated a failure with the Knock Sensor Detection System (KSDS). The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The vehicle was not repaired. The contact related the failure to the federal safety agency Campaign Number: 17V578000 (ENGINE AND ENGINE COOLING); however, the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 80,000.