2017 Hyundai Santa Fe: excessive oil consumption

Filed Nov 5, 2026 · Engine · TX

I am submitting a complaint regarding engine oil consumption in my 2017 Hyundai Santa Fe Sport 2.4L 4-cylinder with approximately 117,000 miles. The vehicle consumes approximately one quart of engine oil every 5,000 miles during normal operation. There are no visible oil leaks or noticeable exhaust smoke. I am concerned that the engine may be consuming oil internally due to a possible defect involving the piston rings, valve seals, or another internal engine component. The exact cause has not been professionally diagnosed. Excessive oil consumption creates a safety concern because low engine oil levels can lead to inadequate lubrication, sudden engine failure, or loss of engine power while driving, potentially putting the driver and other motorists at risk. The condition has not yet been formally confirmed by a dealership or independent repair facility. The vehicle has not undergone a formal manufacturer or third-party inspection specifically for this issue. The engine is available for inspection upon request. There are currently no check-engine warning lights or diagnostic trouble codes. No visible smoke or external oil leaks have been observed. The primary symptom is the gradual loss of engine oil during normal driving. I am requesting that the federal safety agency document and investigate this condition to determine whether it may be related to an engine defect affecting Hyundai vehicles equipped with the 2.4L engine.

Filed Sep 20, 2026 · Engine, Transmission · OH

Component/System Failed: Engine assembly (Theta II 2.4L GDI) and Exhaust/Catalytic Converter. Description: The vehicle suffered a failure associated with the known Theta II engine defects. Engine oil consumption and internal engine wear directly led to unburned fuel and debris entering the exhaust stream, resulting in severe catalytic converter restriction/failure. Safety Risk: The combined failure caused sudden loss of power while driving, engine stalling, and significant driveability hazards, creating an immediate risk of a rear-end collision on public roads. Confirmation & Inspection: The failure was confirmed and diagnosed by a certified service facility. Replaced components and diagnostic documentation remain available for inspection upon request.

Filed Sep 8, 2026 · Engine · PA

-The primary mechanical failure is a burned exhaust valve in Cylinder 2, which has resulted in 0 PSI compression and a persistent engine misfire. This severe top-end valve degradation occurred as a direct consequential result of a chronic, underlying defect in the engine's internal oil-delivery and consumption systems. The vehicle is currently fully assembled, intact, and available for immediate inspection upon request at Brown-Daub Hyundai. -The vehicle suffered a sudden, severe loss of motive power while operating in traffic due to the cylinder drop, triggering a sudden transition into a dangerous operating state. The extreme oil consumption rate (burning 5 to 6 quarts of motor oil every 3,000 miles) created an ongoing, severe risk of sudden highway stalling, catastrophic moving component seizure, and potential engine bay fire due to extreme internal operating friction and chronic oil starvation. -Failure has been confirmed by two independent automotive facilities: Independent Confirmation: On XXX, [XXX]’s Service Center performed a diagnostic scan and an engine compression test, formally documenting diagnostic trouble code P030200 (Cylinder 2 Misfire) and verifying 0 PSI compression in Cylinder 2.Dealership Confirmation: On XXX, the service manager at Brown-Daub Hyundai executed a formal electronic and mechanical inspection under Repair Order #XXX, duplicating the failure and logging active trouble codes P0301, P0302, and P0128. -Symptoms first appeared progressively through an accelerating, severe oil consumption defect, which was documented during multiple routine maintenance: XXX oil consumption (115,865 mi): XXX (119,601 mi) no external leaks: XXX (125,502 mi) excessive oil consumption:XXX (135,116 mi) excessive oil consumption:XXX (133,022 mi) P0420 Cat Code: XXX (approx. 137,000 mi)engine rough-riding, shaking, & violent misfires began, preceding the mechanical breakdown INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 3, 2026 · Engine · NC

On May 26.2026, Southern States Hyundai performed mandated Service Campaign 9C2 (Theta II Emissions Improvement). The software immediately caused drivability degradation and a catalytic converter failure, mirroring the defects Hyundai acknowledged to the federal safety agency on May 18, 2026. Corporate customer care is using an unrelated oil consumption testing protocol to deflect liability and charge me $1,400 for the testing and/or $4002 for the catalytic converter out of pocket for damage caused by their own recall software. This hesitation is a severe safety risk when accelerating into traffic.

Filed Aug 31, 2026 · Engine, Suspension · WI

My truck began emitting a strong oil odor on XXX. I took it to Amato in [XXX], where I was told the oil pan was leaking. They replaced the oil pan, and I paid for the inspection as well. About an hour after picking up my truck, the check‑engine light came on. I returned to the dealership, and they then said additional repairs were needed, even though I had already paid $2,211.57 for the work they claimed was necessary. At that time, my truck had 145,776 miles on it. Because the manager at [XXX] refused to address my concerns, I was told to go to another Amato location, and I was effectively blacklisted from the first dealership. I went to Amato Glendale, where I experienced the same issues. They fixed only one of the problems, and that was only after I contacted Hyundai corporate. My truck continued to have oil‑consumption issues. Amato required me to complete a three‑month, 1,000‑mile oil consumption test before they would consider providing assistance. I completed the test as instructed. Now, however, they are saying that due to the age and mileage of my truck, they will not cover the engine replacement — even though the problems began at 145,000 miles, not 156,000. Other drivers have reported that Hyundai delays necessary repairs until major engine damage occurs, and I believe that is exactly what has happened in my case. There was also a suspension recall that applied to the 2018 model but not the 2017. Amato Hyundai covered part of that repair only because I contacted corporate again. My current complaint is about the failing engine and Amato Hyundai’s lack of responsibility in properly diagnosing and repairing my truck. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 23, 2026 · Engine · NC

My 2017 Hyundai Santa Fe 3.3L V6 (148,000 miles) has documented oil consumption and a recurring DTC P0278 (Cylinder 6 Contribution/Balance). Hyundai's formal oil-consumption test confirmed oil consumption, but said it was below the threshold for combustion-chamber cleaning. The check-engine light and P0278, and losing acceleration ability continue to recur. The vehicle is available for inspection. Hyundai has confirmed the oil-consumption issue but has not determined the cause of P0278 or performed the TXX8 engine inspection I am requesting. I am concerned about worsening engine performance, loss of power, or engine failure, particularly given Hyundai's history of engine-bearing issues with certain 2017 Santa Fe 3.3L engines. I am not claiming diagnosed bearing failure; I am requesting a TXX8 inspection to determine whether an eligible engine condition exists. I have contacted both the dealership and Hyundai Corporate, but have been told I must repeat the oil-consumption test. At 148,000 miles, I am requesting prompt inspection before the 150,000-mile TXX8 limit and covered repair/replacement if an eligible condition is found.

Filed Aug 21, 2026 · Engine · OK

There is a class action lawsuit for the Theta Engine in some Kia and Hyundai vehicles and my type of vehicle falls into this lawsuit category. I drive a 2017 Hyundai Santa Fe Sport and what the lawsuit described what happened to my vehicle, it seized up and you’re supposed to have a lifetime warranty for this problem. I submitted all the paperwork and Norman Hyundai sent videos it was seized up but denied my claim so I have a car that no longer drives with a car loan still so can’t buy a new vehicle. I was told they didn’t see oil additive anytime but their own business this in March ‘26 and May ‘26. It states on the lawsuit if anyone’s in the class action lawsuit they are covered if this happens to your vehicle. Also, part of the lawsuit is the oil consumption and how much it’s eating gas and then it seizes possibly or catch fire and my car was barely getting a 1,000 miles and it would be empty so couldn’t keep up always checking it and the car seized up due to what’s supposed to be covered.

Filed Aug 13, 2026 · Engine · KS

We have been involved with an Oil Consumption problem since 2025 maybe earlier. No leaks just an over use of oil. I have had to fill it myself or take it to the dealer. They did testing and di some kind of cleaning that took 8 hours. We still have the problem and while driving the whole car shut down. No power in the middle of a highway. This has now happened twice and the first time we had to call AAA for help. It showed an engine sign and we checked the code. First it was an small air leak but they didn't find anything. It came up again, same message so we replaced the gas cap, but the oil was still disappearing and the car had shut down again. I spoke with the Hyundai corporation and they said to do the combustion cleaning again. So we set it up but found out that we had to pay for it so we declined. They refused to do anything about the car. We later found there were other cars made by the same company with the same problem. I did some research and they have had an Oil Consumption problem for quite a while. Now the Catalytic Converter is showing up as having problems. Well that's where the oil goes and can shut down the car due to airflow. They never disclosed it to us face to face, we had to find out about it after the the warranty was up. That was very dangerous to have stopped on a highway.

Filed Jul 21, 2026 · Engine · TN

On July 4, 2026, I was driving 2.5 hours from home. My car stopped after about an hour of travel. The car shook and the check engine light came on as the car shut down. There were no warning lights on in my vehicle. I have oil change records. My car had burned through all the oil in an hour. This is not a new problem with this model Hyundai. Every group I went to discuss the problem online all had customers who reported their vehicles suddenly started burning oil quickly which resulted in damaged motor with no warning lights in the dashboard. I had to have my car towed from out of town to the dealership. The dealership that said I had extended warranty on parts of the motor. However upon checking the motor, they said it wasn't covered. I filled out a claims report with Hyundai motors who looked into the problem and also said it's not covered under warranty. This is a known issue of Hyundai with a failure to warn of low oil in the car's warning center. This is a fault of Hyundai. I've taken good care of my car and just paid $1000 for new tires on July 2, 2026 before my trip. The dealership quoted me a price of $3500 to replace the motor with a used one. It would also require 16 hours of labor which I Believe is $200 an hour. I believe they should replace the motor due to faulty systems. My car has 107,000 miles on it, but whenever I've gone to have it checked out, everything checked out fine even at the dealership. Also, this is a known issue that Hyundai is refusing to address with their customers.

Filed Jun 10, 2026 · Engine · OH

My wife was driving our 2017 Hyundai Santa Fe around March 8, 2023 with our 3 children in the vehicle. She began merging onto interstate 70 when the vehicle made a noise and became undriveable. She could still steer but pushing the pedal down did not do anything. She had to carefully pull over off of the highway so that she did not get in an accident. This vehicle had to be towed to a mechanic who said the engine had seized up and that the oil is gone from the engine and that I would need to have it sent to a Hyundai dealer. This vehicle had 108,334 miles on it so it was just past Hyundai's 100,000 mile warranty. This vehicle was towed to a Hyundai dealer who confirmed that the engine was locked up and that an oil sample found metal in the oil. The dealership recommended to replace the engine with a used one for over $11,000 which I declined then charged me $160 for evaluating. No warning lights or indicators were ever showing any issues. We did notice sometimes after an oil change that they would state on the invoice that the oil was a half quart low. This vehicle was parked in a garage and never had a drop of oil leak. Hyundai recently extended the warranty for this vehicle to 150,000 miles and then declined my repair claim due to the repair not being done at a dealership. The sudden loss of power while driving was a scary incident for my family but thankfully no one was hurt.

Filed Jun 9, 2026 · Engine · FL

The engine burns oil fast. You have to replace oil on a regular bases. The car also looses fluids fast as well. This causing the engine to over heat. This causes the cylinder to head blow.

Filed Jun 4, 2026 · Engine, Fuel system · VA

Hi, my name is [XXX], i bought used Hyndai Santafe sport 2017 from dealership in 2020. It had around 47,000 Miles on it, intitially it was running fine but after driving 2 years i discovered that engine is burning oil and after the oil change right after 1000 miles i had to add a quart of oil and it was like every two weeks. I had many srevices from dealership and other auto mechanic stores but it didn't improved. I had no choice but to keep driving the card on XXX th the engine crashed with out any sign on dashboard. There was slight noise and it increase by the way car was parked on the side road from Highway. The car was towed to my local mechanic and confirmed that engine is crashed. After i had to towed to dealership and i am still waiting for their response. Now we have put 43,000 miles in 6 years (91,000) total mileage. I had bought the waranty from dealership by $ 2500 which expired in 2025 Currently no warranty. My question here is that the car is still under 100,000 and engine failed. What if the dealership refuse to replace the engine. What are my leagal rights. Thanks [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)