2017 Hyundai Santa Fe: sudden loss of power

Filed Nov 5, 2026 · Engine · TX

I am submitting a complaint regarding engine oil consumption in my 2017 Hyundai Santa Fe Sport 2.4L 4-cylinder with approximately 117,000 miles. The vehicle consumes approximately one quart of engine oil every 5,000 miles during normal operation. There are no visible oil leaks or noticeable exhaust smoke. I am concerned that the engine may be consuming oil internally due to a possible defect involving the piston rings, valve seals, or another internal engine component. The exact cause has not been professionally diagnosed. Excessive oil consumption creates a safety concern because low engine oil levels can lead to inadequate lubrication, sudden engine failure, or loss of engine power while driving, potentially putting the driver and other motorists at risk. The condition has not yet been formally confirmed by a dealership or independent repair facility. The vehicle has not undergone a formal manufacturer or third-party inspection specifically for this issue. The engine is available for inspection upon request. There are currently no check-engine warning lights or diagnostic trouble codes. No visible smoke or external oil leaks have been observed. The primary symptom is the gradual loss of engine oil during normal driving. I am requesting that the federal safety agency document and investigate this condition to determine whether it may be related to an engine defect affecting Hyundai vehicles equipped with the 2.4L engine.

Filed Oct 15, 2026 · Electrical, Engine · CA

On [XXX], Laguna Niguel Hyundai performed Service Campaign 9C2 (ECU software update for Theta II emissions improvement, Hyundai TSB 26-01-013H) on my 2017 Hyundai Santa Fe Sport. Immediately after the update, the vehicle developed drivability problems that did not exist before: rough/harsh shifting, hesitation, and loss of power during cold-start operation (the first 1-3 minutes after engine start), plus intermittent infotainment and navigation system failures. Hyundai's own dealer notice dated 05/18/2026 acknowledges vehicles may exhibit 'hesitation or rough shifting' after the 9C2 update and states the matter is 'currently under review' — no permanent fix has been released. The dealership that performed the recall has since refused to service my vehicle again. I opened case #[XXX] with Hyundai corporate; my inquiries on 09/03/2026, 09/11/2026, and 09/17/2026 asking for a corrective action have gone unanswered. The hesitation and power loss are a safety hazard when merging into traffic or crossing intersections. I request the federal safety agency investigate this pattern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 13, 2026 · CA

On XXX, [XXX] Hyundai performed Service Campaign 9C2 (ECU software update for Theta II emissions improvement, Hyundai TSB 26-01-013H) on my 2017 Hyundai Santa Fe Sport. Immediately after the update, the vehicle developed drivability problems that did not exist before: rough/harsh shifting, hesitation, and loss of power during cold-start operation (the first 1-3 minutes after engine start), plus intermittent infotainment and navigation system failures. Hyundai's own dealer notice dated XXX acknowledges vehicles may exhibit 'hesitation or rough shifting' after the 9C2 update and states the matter is 'currently under review' — no permanent fix has been released. The dealership that performed the recall has since refused to service my vehicle again. I opened case #XXX with Hyundai corporate; my inquiries on XXX asking for a corrective action have gone unanswered. The hesitation and power loss are a safety hazard when merging into traffic or crossing intersections. I request the federal safety agency investigate this pattern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 27, 2026 · Engine, Transmission · MD

Immediately following the mandatory Hyundai Servie Campaign Update 9C2-ECU THETA 11my vehicle began exhibiting severe hesitation, very rough idling, jerking at slow speeds and when gear changes, difficulty going up inclines and almost feel at times as though it is about to lose power which poses life threatening situations especially when turning into traffic. I have reported it to the dealers who never once test drove the vehicle but said to me that they did and could find no problem, however they did make me pay for repairs which never fixed the problem. I returned three times with the same issue. They recommended a Fuel Induction Service and a Auto Trans Service. Spark plug change. Igniton coils change. Nothing worked!

Filed Sep 20, 2026 · Engine, Transmission · OH

Component/System Failed: Engine assembly (Theta II 2.4L GDI) and Exhaust/Catalytic Converter. Description: The vehicle suffered a failure associated with the known Theta II engine defects. Engine oil consumption and internal engine wear directly led to unburned fuel and debris entering the exhaust stream, resulting in severe catalytic converter restriction/failure. Safety Risk: The combined failure caused sudden loss of power while driving, engine stalling, and significant driveability hazards, creating an immediate risk of a rear-end collision on public roads. Confirmation & Inspection: The failure was confirmed and diagnosed by a certified service facility. Replaced components and diagnostic documentation remain available for inspection upon request.

Filed Aug 24, 2026 · Electrical, Engine · NJ

My 2017 Hyundai Santa Fe, purchased new from Lynnes Hyundai in February 2017, has approximately 93,000 miles. The vehicle previously developed a significant oil-consumption/engine problem that was diagnosed by Hyundai, and Hyundai replaced the engine with a remanufactured engine. Approximately two weeks after the engine replacement, the check-engine light illuminated and DTC P1326 was identified. The dealership replaced the knock sensor. Approximately two weeks later, the check-engine light illuminated again with a recurring P1326 condition. The vehicle is currently at Lynnes Hyundai and has been there approximately three weeks while they attempt to determine the cause. Hyundai Techline is involved. Prior to the current repair visit, while traveling approximately 60 mph, the vehicle experienced a very forceful hesitation that jerked the vehicle. I immediately slowed down and pulled onto the shoulder. The vehicle continued to hesitate intermittently while I drove slowly to safety. I was concerned that the vehicle could lose power or shut down while I was driving at highway speed, creating a risk of a crash. The recurring P1326 condition has been confirmed by the Hyundai dealership. The vehicle and engine have been inspected by Hyundai/Lynnes Hyundai multiple times, including after the engine replacement. The current recurring condition has not been resolved. The check-engine light is the warning lamp associated with the current condition. I do not know the underlying cause of the recurring P1326 condition; Hyundai is currently attempting to diagnose it. The vehicle is currently available for inspection at Lynnes Hyundai.

Filed Aug 23, 2026 · Engine · NC

My 2017 Hyundai Santa Fe 3.3L V6 (148,000 miles) has documented oil consumption and a recurring DTC P0278 (Cylinder 6 Contribution/Balance). Hyundai's formal oil-consumption test confirmed oil consumption, but said it was below the threshold for combustion-chamber cleaning. The check-engine light and P0278, and losing acceleration ability continue to recur. The vehicle is available for inspection. Hyundai has confirmed the oil-consumption issue but has not determined the cause of P0278 or performed the TXX8 engine inspection I am requesting. I am concerned about worsening engine performance, loss of power, or engine failure, particularly given Hyundai's history of engine-bearing issues with certain 2017 Santa Fe 3.3L engines. I am not claiming diagnosed bearing failure; I am requesting a TXX8 inspection to determine whether an eligible engine condition exists. I have contacted both the dealership and Hyundai Corporate, but have been told I must repeat the oil-consumption test. At 148,000 miles, I am requesting prompt inspection before the 150,000-mile TXX8 limit and covered repair/replacement if an eligible condition is found.

Filed Jul 27, 2026 · Engine · MI

On June 10, 2024 at 107,129 miles Hertrich Hyundai dealership of New Castle inspected my vehicle and submitted a request to Hyundai for engine replacement under the recall settlement of the Theta II Engine Settlement. Hyundai denied the request because of the rebuilt title, even though the rebuilt title resulted only from prior Roof damage unrelated to the engine, powertrain, or recall issue. After continuing to seek assistance from Hyundai, my engine ultimately seized and suddenly stopped working on May 10, 2026, while driving on the highway with my two children. The vehicle lost power and stopped in traffic, creating a dangerous situation and causing my children extreme fear and distress. Had Hyundai honored the Theta II Engine Settlement when I first requested assistance, this failure could have been prevented. I request that Hyundai honor the Theta II Engine Settlement and replace my defective engine at no cost to avoid any future problems. My Hyundai Santa Fe is covered under the Theta II Engine Settlement. For over three years, I repeatedly contacted Hyundai after experiencing symptoms consistent with the known Theta II engine defect. Hyundai failed to provide meaningful assistance, did not properly process my requests, and denied coverage solely because of the vehicle’s rebuilt title.

Filed Jun 12, 2026 · IL

Overview Over approximately six months, I reported persistent drivability concerns to Hyundai on Perryville — specifically hesitation, engine trembling, power loss on acceleration, and eventually a flashing check engine light, particularly when the engine was cold. Despite multiple dealership visits and over $1,500 in out-of-pocket expenses, the root cause was not identified until my fifth visit: a clogged catalytic converter. Hyundai Motor America determined the repair was not covered and declined to explain the diagnostic basis for that decision. When I sought a second opinion at an independent shop (recommended by the dealership), that shop ignored my explicit instructions not to drive the vehicle, drove it, and the car broke down in their care. Their own invoice now states the vehicle needs a new motor. I am filing this complaint to document the full pattern of negligence, misdiagnosis, and failure of care by both parties.

Filed Jun 10, 2026 · Engine · OH

My wife was driving our 2017 Hyundai Santa Fe around March 8, 2023 with our 3 children in the vehicle. She began merging onto interstate 70 when the vehicle made a noise and became undriveable. She could still steer but pushing the pedal down did not do anything. She had to carefully pull over off of the highway so that she did not get in an accident. This vehicle had to be towed to a mechanic who said the engine had seized up and that the oil is gone from the engine and that I would need to have it sent to a Hyundai dealer. This vehicle had 108,334 miles on it so it was just past Hyundai's 100,000 mile warranty. This vehicle was towed to a Hyundai dealer who confirmed that the engine was locked up and that an oil sample found metal in the oil. The dealership recommended to replace the engine with a used one for over $11,000 which I declined then charged me $160 for evaluating. No warning lights or indicators were ever showing any issues. We did notice sometimes after an oil change that they would state on the invoice that the oil was a half quart low. This vehicle was parked in a garage and never had a drop of oil leak. Hyundai recently extended the warranty for this vehicle to 150,000 miles and then declined my repair claim due to the repair not being done at a dealership. The sudden loss of power while driving was a scary incident for my family but thankfully no one was hurt.

Filed May 27, 2026 · Driver assistance, Engine · FL

reporting a serious safety concern involving my 2017 Hyundai Santa Fe Sport with the Theta II engine. While driving on the highway, my vehicle suddenly lost power without warning. The vehicle became unsafe to drive and I had to pull over and have it towed. There was no warning light before the failure. The vehicle has been regularly maintained. Hyundai later stated there was internal engine damage. My vehicle also shows an open engine-related recall/campaign since November 2025. I have found many similar complaints from other Hyundai owners describing sudden loss of power, excessive oil consumption, and engine problems involving the Theta II engine. I contacted Hyundai Motor America and provided documentation and videos, but I have not received a meaningful response. I am concerned this issue may represent a serious safety defect because the sudden loss of power occurred while driving on a highway.

Filed May 19, 2026 · Engine, Fuel system · WA

I am submitting a complaint regarding a turbocharger failure on my 2017 Hyundai Santa Fe VIN [XXX] . The vehicle experienced turbocharger-related failure symptoms including loss of power and drivability concerns. This created a potentially dangerous situation because the vehicle was unable to accelerate normally and could have caused difficulty merging into traffic or maintaining safe roadway speeds. I contacted Hyundai Motor America requesting assistance with repair coverage. Hyundai denied assistance solely because the vehicle was outside the warranty period by time and mileage, despite the seriousness of the failure. I am concerned this issue may be related to broader engine or oil-related defects reported in Hyundai vehicles, including possible oil starvation, excessive oil consumption, or internal engine contamination that could contribute to turbocharger damage or failure. I believe this condition may represent a safety-related defect because sudden power loss during operation increases the risk of a crash. I request that the federal safety agency review this issue and investigate whether similar turbocharger or related engine failures are occurring in 2017 Hyundai Santa Fe vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)