Hyundai Santa Fe sunroof shattered problems

Filed Nov 6, 2026 · Visibility · 650 miles · GA · 2 injuries

The contact owns a 2026 Hyundai Santa Fe. The contact stated that while driving 65 MPH, there was a loud bang, and the sunroof glass shattered without impact. The contact stated that fractured glass fell into the cabin, onto exposed skin, and into clothing. The dealer was contacted. The vehicle was taken to the dealer, who inquired about potential causes of the shattered glass and referred the contact to the insurance provider for repair. The contact was informed that the sunroof glass would be replaced. The vehicle was repaired. The manufacturer was notified of the failure and offered assistance with the repair. The failure mileage was approximately 650.

Filed Nov 3, 2026 · Visibility · FL

While driving on the freeway at approximately 73 mph, I heard a very loud bang that sounded like something had struck my car. I initially thought a rock had hit my windshield, but I couldn't see any damage. Later, I remembered the incident and went to the garage to inspect my car. After checking the windshield and walking around the front and sides without finding any damage, I climbed up to inspect the roof. I noticed something unusual about the smaller fixed glass panel in front of the sunroof, directly behind the windshield. When I ran my finger across it, I heard a slight cracking sound and felt a rough texture. That's when I realized the entire panel had shattered. The shattered glass poses a potential safety risk due to the possibility of glass falling into the vehicle or further breaking while driving at highway speeds, going over bumps, closing the car doors etc. The panel is available for inspection. The vehicle has not yet been inspected by a dealership or manufacturer, and the cause of the failure has not been determined. There were no warning lights or messages before the incident. After researching the issue, I found multiple reports from Hyundai Santa Fe owners describing similar incidents. Relevant the federal safety agency complaints include: Complaint #11502029 (2020 Santa Fe): Front sunroof glass suddenly shattered with no apparent external impact. Complaint #11548273 (2020 Santa Fe): Stationary glass panel in front of the sunroof shattered while parked. Complaint #11253008 (2019 Santa Fe): Panoramic sunroof shattered while driving with no evidence of an external impact. Complaint #11480753 (2019 Santa Fe): Rear panoramic sunroof panel reportedly exploded while driving approximately 70 mph. I believe these reports warrant further investigation into a possible recurring issue with Hyundai Santa Fe sunroof glass or its assembly, particularly given the potential safety risks of unexpected glass failure while driving.

Filed Jul 23, 2026 · CO

sunroof shattered completely without any force of impact. The glass appears to have imploded.

Filed Jun 17, 2026 · Visibility · TX

2020 Hyundai Santa Fe Limited. The panoramic sunroof glass suddenly shattered/exploded without a collision and without any known impact. Glass shattered completely and created a safety hazard to occupants and traffic. Vehicle was purchased as Hyundai Certified Pre-Owned in 2021. Hyundai corporate case has been opened and advised dealer inspection. Dealer inspection is pending. Photos are available. Request that this be logged as a potential safety issue involving panoramic sunroof glass failure.

Filed Jun 12, 2026 · Visibility · IA

Driving down the road and the sunroof just exploded. No rock, no nearby cars that could have kicked something up. Just crumbled in.

Filed Jun 8, 2026 · CO

On 6/6/2026, my husband and I were driving on I70 west bound near the Golden CO exit. Out of nowhere, we heard a very loud pop sound and then heard wind over our head. The front sunroof spontaneously shattered. What component or system failed or malfunctioned, and is it available for inspection upon request? FRONT SUNROOF How was your safety or the safety of others put at risk? YES! Has the problem been reproduced or confirmed by a dealer or independent service center? YES Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO! NOT A SINGLE WARNING, NOTHING!

Filed May 22, 2026 · NC

On March 17, 2026, the sunroof of our Hyundai Sante Fe 2021 exploded. The driver and two passengers were not hurt because the sunroof was closed and the liner in place when the explosion took place. The incident occurred on an open country highway on a sunny afternoon with no other vehicles or flying objects sighted.

Filed May 21, 2026 · TX

While driving, the sunroof glass of the vehicle exploded/shattered with no known trigger, force or debris striking the glass. At the time no risk to myself as the sunroof shade was closed. I am in the process of getting this inspected and repaired.

Filed May 5, 2026 · MS

Driving down the interstate to work at around 70 MPH at approximately 6:40 AM and the front sunroof exploded upwards. Nothing of impact, just a loud explosion and glass blew upwards. The broken glass is positioned upward. The cover of the sunroof was closed and it was not currently in use. Otherwise, glass could have shattered all over me, causing a wreck. I am an [XXX] veteran, the explosion itself set off my anxiety, but thankfully, I was able to pull the car over without incident. I took pictures of the sunroof and I was able to drive slowly down a smaller highway to the dealership, Mac Grubbs Hyundai in Hattiesburg, MS, where I dropped the car off for repairs. I contacted my insurance company and they picked me up in a rental care from the dealership. There was no warning light, not leaks, or cracks in the sunroof prior to the incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 29, 2026 · Visibility · 43,000 miles · IL

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving 50-55 MPH, the sunroof made an abnormal, exploding sound and shattered. The shade cover was closed during the failure. There was no injury sustained. The vehicle was driven to the workplace of the contact's brother-in-law, and the sunroof was taped to prevent the shattered glass from flying off. The vehicle was then taken to the dealer, where it was inspected. The contact was informed that it was a common failure caused by the intermittent expansion of the body of the vehicle under certain temperatures. The vehicle was not yet repaired. The manufacturer was not contacted. The failure mileage was approximately 43,000.