Hyundai Sonata Hybrid stalling problems

Filed Oct 16, 2026 · Engine · CA

My 2017 Hyundai Sonata Hybrid suffered a sudden and dangerous engine failure matching the exact conditions of the federal safety agency Safety Recall 209 (Hyundai Campaign 209) for premature connecting rod bearing wear. The vehicle entered Limp Mode due to diagnostic trouble code P1326. The mandatory Knock Sensor Detection System (KSDS) software update was successfully completed on this vehicle prior to the failure. The vehicle is currently located at Hyundai of [XXX], where dealership technicians confirmed that the engine is completely failed and requires replacement. However, the dealership and manufacturer are actively refusing to perform the mandatory safety recall remedy, instructing me to pick up the un-repaired, hazardous vehicle. They are citing the vehicle's salvage title as the sole reason for denial. Under federal the federal safety agency regulations, a manufacturer cannot deny a safety recall remedy based on a salvage or branded title status unless the vehicle cannot be physically or safely repaired. This engine defect poses a documented fire and stalling hazard. I am filing this immediate complaint because Hyundai is violating federal recall mandates by attempting to discharge a vehicle with an open, dangerous safety hazard without completing the legally required remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 21, 2026 · Engine · 97,000 miles · PA

The contact owns a 2015 Hyundai Sonata. The contact stated that while driving approximately 65 MPH, the vehicle failed to properly accelerate. Later, while attempting to accelerate from a yield sign, the vehicle suddenly stalled. The vehicle was later towed to the local dealer to be diagnosed, and it was determined that the engine bearings had failed and the engine needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 97,000.

Filed Sep 1, 2026 · Engine · 110,000 miles · CA

The contact owns a 2017 Hyundai Sonata. The contact stated that the vehicle experienced excessive oil consumption with an abnormal burning odor. The vehicle was taken to a dealer, and an oil consumption test was performed. The contact was informed that the vehicle passed the inspection. While driving later, the vehicle stalled and was taken back to the dealer, where it was determined that the vehicle was consuming an excessive amount of engine oil, and several DTC including the Knock Sensor Detection System (KSDS) were found. The contact stated that while driving or reversing at various speeds, the vehicle shuddered, made abnormal rattling sounds, entered HEV Lock Mode, and the vehicle stalled. The vehicle occasionally came to a complete stop in the middle of the road and had to be pushed out of the roadway. On other occasions, the driver was able to pull over to the side of the road. The vehicle failed to restart and was towed after stalling. The contact stated that the check engine warning light was illuminated before the vehicle entered HEV Lock Mode, with several unknown warning lights illuminated. The vehicle was towed to the dealer, where several tests, including bearing clearance tests and unknown repairs, were performed; however, the failure persisted. During the final service visit, the dealer diagnosed the vehicle with engine wear and tear and fractured pistons. The dealer determined that the engine needed to be replaced; however, the service manager informed the contact that there was no guarantee that replacing the engine or catalytic converter would resolve the failure due to severe engine damage. The vehicle was not repaired. The manufacturer was notified of the failure and offered loaner vehicle assistance on several occasions; however, coverage for the engine replacement was denied. The failure mileage was approximately 110,000.

Filed Jul 15, 2026 · Engine, Fuel system · WA

The primary failure is in the Engine/Powertrain system and Knock Sensor Detection System (KSDS), causing 6 identical sudden engine stalls (OBD-II code P1326) from 09/2000 to 06/2026. Additionally, severe excessive oil consumption was documented during 2 of these diagnostic visits, showing deep-seated engine issues. The vehicle and all records are available for inspection at the Hyundai dealer. Safety was severely threatened on 6 occasions. The vehicle abruptly stalled at 60+ mph in active highway traffic, forcing an immediate engine shutdown. This left me with highly impaired steering and braking control in fast-moving traffic, creating an imminent risk of high-speed rear-end collisions and jeopardizing my life and others. The primary stalling defect and P1326 code were confirmed 6 separate times by the authorized Hyundai dealership. The secondary excessive oil consumption issue was also formally confirmed by the dealer during 2 of those visits. Despite multiple dealership-confirmed diagnoses, no permanent repair has been achieved. The vehicle has been inspected during all 6 visits by dealership technicians. For the current (6th) visit, the dealer could not resolve the recurring defect and formally contacted Hyundai Corporate Technical Support for expert analysis, which is currently ongoing. Except for the first visit, the pattern is identical: the car stalls, the dealer clears codes/replaces KSDS, and it stalls again within 3 weeks. Notably, during the 4th visit, they replaced the Intake Manifold. Now, on this 6th visit, they demand I pay to replace that same part again. This proves they cannot diagnose the root engine failure and are only applying useless, temporary fixes. Prior to all 6 stalls, the flashing Check Engine / Hybrid Warning light triggered on the dashboard. This critical KSDS alert was followed within seconds by a total loss of motive power. Also, a history of rapid engine oil depletion and low-oil alerts was documented in 2 of the diagnostics.

Filed Jun 10, 2026 · Engine · GA

The Hybrid Electric Vehicle (HEV) system in my 2017 Hyundai Sonata Hybrid Limited malfunctioned. On three separate occasions, the HEV warning light illuminated while I was driving on the highway, followed by a sudden loss of power. The vehicle stalled and stopped running, leaving it inoperable. The incidents occurred in approximately August 2022, November 2023, and February 2026. The vehicle is available for inspection upon request. Each incident occurred while driving on a highway. The vehicle suddenly lost power and stalled in moving traffic, creating a significant safety hazard. I was forced to attempt to move the vehicle out of active traffic lanes while other vehicles were traveling at highway speeds. The unexpected loss of propulsion increased the risk of a crash, serious injury, or death to myself, my passengers, and other motorists. The vehicle was taken to a Hyundai dealership after each incident. However, the dealership did not provide an explanation for the HEV warning light, loss of power, or stalling condition. To my knowledge, no permanent repair was identified, and the problem recurred on multiple occasions. The vehicle was inspected by a Hyundai dealership following each towing event. The vehicle was towed after each incident because it was not safe to drive. To my knowledge, Hyundai did not provide a definitive cause for the failures. The vehicle has not been inspected by police or insurance representatives in connection with

Filed Sep 5, 2025 · Fuel system · SC

Fuel injector failed. The vehicle stall and accelerate poorly due to misfires. It is leaching gasoline into the oil which can result in total engine failure. Dealership verified the injector was bad. There was a warning light at one time after refueling, presumed it was my fuel cap, tightened it, and the light went away.

Filed Feb 24, 2025 · Engine · 180,000 miles · CA

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated while driving approximately 65 MPH, the check engine warning light was illuminated, and the vehicle stalled. The contact was able to exit the highway; however, the contact was unable to restart the vehicle. The contact had the vehicle towed to a dealer to be diagnosed. The vehicle was diagnosed, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The contact stated that prior to the engine failure, the engine had been replaced two years prior. The manufacturer was not informed of the failure. The failure mileage was approximately 180,000.

Filed Jan 18, 2025 · Engine · MA

I bought this car brand new in november 2023, by february, the car started stalling on the streets/hyway. All dash lights would come on, the vehicle would stall and is no longer able to restart. This happened 4 time in 2024. When I tow it to the dealer, they always come back with the same answer. ''the AC motor power cable has been disconnecting leading to lose of power''. They have replaced it 4x but the same problem persist. It's very scary especially whn am driving in a busy road or when am driving at night in the middle of winter. Am not sure how to move from here. Thanks.

Filed Aug 12, 2024 · MS

The car randomly loses power and stalls on the expressway and it states that something is wrong with the hybrid system

Filed Jul 9, 2024 · Brakes, Engine · 145,000 miles · MN

The contact owns a 2013 Hyundai Sonata Hybrid. The contact received notification of the federal safety agency Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving approximately 45 MPH, there was smoke coming from the engine compartment before the vehicle stalled. The vehicle was towed to the local dealer. The vehicle was not yet repaired. The failure mileage was 145,000. Parts distribution disconnect.