2013 Kia Optima: engine failure

Filed Aug 19, 2026 · Brakes, Engine · TX · fire

On July 14, 2026, the vehicle's engine was replaced by an authorized dealership under an official Kia recall. On August 16, 2026, while driving on the highway, heavy smoke suddenly began emitting from the engine compartment. When attempting to slow down, the braking system suffered a total loss of power and failed completely. To stop the vehicle, it had to be steered into the highway median to intentionally scrape against it to force a stop. Immediately upon exiting the vehicle, heavy flames were observed under the engine compartment before completely engulfing the front of the car. The fire department extinguished the fire, and the vehicle is a total loss.

Filed May 14, 2026 · Engine · FL

I was driving on the high way and my car completely stopped I towed it to a shop and the engine seized

Filed Apr 30, 2026 · Engine · 125,000 miles · TX

The contact owns a 2013 Kia Optima. The contact stated that while driving at an undisclosed speed, the engine unexpectedly seized without warning. The contact stated that after the vehicle lost motive power, several unknown warning lights illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had seized and needed to be replaced. The vehicle was not repaired. The vehicle was then towed to the dealer but was not diagnosed or repaired. The contact was informed that no diagnostic trouble codes were found. The manufacturer was made aware of the failure. The failure mileage was approximately 125,000.

Filed Apr 29, 2026 · Engine · 297,000 miles · CA

The contact owns a 2013 Kia Optima. The contact stated while driving 75 MPH, the vehicle went into LIMP Mode and failed to exceed 60 MPH. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the knock sensor and the harness had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred on several occasions, and the vehicle was driven or towed to the dealer as needed. The dealer cleared the diagnostic trouble codes and informed the contact that a recall repair would not be completed unless the engine made loud knocking sounds or seized. The contact stated that while driving at an undisclosed speed, the engine made an abnormally loud sound and seized. The vehicle was towed to the residence. The vehicle was then towed to the dealer, where the contact was informed that the engine was not eligible for replacement due to a lack of maintenance records because the contact did not have all the oil change service records available. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 297,000.

Filed Apr 13, 2026 · Engine · GA

The contact owns a 2013 Kia Optima. The contact stated that while attempting to start the vehicle, the vehicle failed to start. There was no warning light illuminated. The vehicle was towed to a local dealer, where it was diagnosed and it was determined that the turbocharger had failed, and the engine and turbocharger needed to be replaced. The vehicle was not repaired. The contact received a letter from the dealer that the vehicle was covered under a manufacturer settlement for engine replacement; however, the dealer advised the contact that there was an out-of-pocket cost to replace the turbocharger. The manufacturer was informed of the failure. The failure mileage was unknown.

Filed Apr 7, 2026 · Engine · 130,000 miles · FL

The contact owns a 2013 Kia Optima. The contact stated that while his son was driving approximately 35 MPH, there was an abnormal metal-on-metal sound coming from the vehicle, and the vehicle stalled. The contact drove out to the location and became aware that the oil and the battery warning lights were illuminated. The contact attempted to restart the vehicle, but the vehicle failed to restart, and the starter motor was smoking. The contact stated that prior to the engine failure, the starter motor had been replaced. The vehicle was towed to the independent mechanic who had recently replaced the starter motor. The mechanic diagnosed the vehicle and informed the contact that the engine had seized and needed to be replaced. The mechanic informed the contact that the VIN was included in the federal safety agency Campaign Number: 17V224000 (Engine and Engine Cooling). The contact called the local dealer and the manufacturer but was informed that the vehicle would not be repaired. The failure mileage was approximately 130,000.

Filed Mar 23, 2026 · Engine · GA

1) Motor failed on interstate and car towed to automotive shop. Currently still at the shop with hope to tow to Kia to address issue. 2)My teenage daughter and her friend were placed in a dangerous and potentially life-threatening situation due to what appears to be a catostrophic vehicle failure. While driving our 2013 Kia Optima whith approximately 160,000 miles, the vehicle suddenly lost power while our daughter was traveling a major highway. The car quit responding to the gas pedal and she was forced to pull over on the side of the highway and was stranded in traffic with no safe way to move the vehicle. When she attempted to restart the car the engine light began flashing (it did not do so before hand), the car was shaking and undriveable. This was not a minor inconvenience, it was a serious safety hazard. A young driver was left sitting on the shoulder of a high-speed roadway with cars and trucks passing at highway speeds up to 80 mph. Had another driver drifted or had she not been able to reach the shoulder in time, this situation could have easily resulted in a major crash or fatality(-ies). The vehicle would not restart properly and had to be towed. Prior to this incident, there were no obvious warning sings of an imminent catastrophic failure. The mechanic's invoice of his diagnostics is attached. Vehicles should not fail in a way that suddenly leaves drivers stranded in active highway traffic with no warning. This type of failure creates an extremely dangerous situation not just for the driver but for everyone on the road. I strongly urge the federal safety agency to review whether this model vehicle has known engine or safety defects that can lead to sudden engine failure or loss of power while driving. No parent should have to get a phone call that their child is stranded on the side of a major highway because their car suddenly died without warning. I am requesting this vehicle incident be documented and investigared as a potential safety defect.

Filed Mar 12, 2026 · Brakes, Electrical · 111,862 miles · TX

The contact owns a 2013 Kia Optima. The contact stated that while driving 75 MPH, the vehicle lost motive power. The accelerator pedal was depressed; however, the vehicle eventually stalled on the side of the road. The key, battery, oil, and engine warning lights were illuminated. There was an abnormal ticking sound coming from the vehicle. The contact stated the failure was related to the federal safety agency Campaign Number: 23V652000 (Service Brakes, Hydraulic). The vehicle was towed to an independent mechanic, where it was determined that the engine had seized. The engine failed to turn over. The mechanic had previously performed a routine oil change. The vehicle was towed to the local dealer, where it was diagnosed with low voltage. The spark plugs were checked, there were no oil leaks, and the vehicle was diagnosed with catastrophic engine failure. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 111,862.

Filed Jan 13, 2026 · Engine · 136,000 miles · TX

The contact owns a 2013 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal and stalled. The contact was able to coast to the side of the road. Several unknown warning lights were illuminated. The vehicle was towed to an independent mechanic. The contact was informed that the engine had seized and to tow the vehicle to the dealer for assistance. The vehicle was not repaired. The vehicle was then towed to the dealer, where it was confirmed that the engine had failed. The contact was informed that since the vehicle had a branded title, it could not be repaired. The vehicle remained at the dealer unrepaired. The contact stated that back in October 2024, the vehicle had been in a hit-and-run accident. The insurance company had declared the vehicle a total loss. The contact kept the vehicle and registered it with the rebuilt title. The contact stated that the engine on the vehicle was the original engine. The manufacturer was notified of the failure. The contact stated that Kia Customer Care called and advised the contact that the manufacturer declined the request for the repairs. The failure mileage was approximately 136,000.

Filed Jan 8, 2026 · Engine · AR

The engine on my 2013 Kia Optima (VIN [XXX] ) failed catastrophically less than one mile after purchase. This vehicle is subject to Kia Safety Recall SC147, which addresses a manufacturing defect involving engine bearing wear caused by factory machining debris and identifies engine replacement as the remedy when failure occurs. A Kia dealership inspected the vehicle and confirmed the failure was denied under warranty. I then requested that the dealership pursue recall compliance under Safety Recall SC147. After consultation with Kia Techline and a Kia service representative, the dealership declined to submit or pursue recall compliance for this engine failure. I am submitting this complaint for recall non-compliance and request that this matter be reviewed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 5, 2025 · Engine · 250,000 miles · WI

The contact owns a 2013 Kia Optima. The contact stated that while driving approximately 65 MPH, the vehicle started losing motive power. The contact stated that several unknown warning lights were illuminated. The contact stated that while attempting to pull over, the steering wheel was difficult to turn, and the brake pedal required additional effort to depress. The contact pulled over and turned off the vehicle; however, while attempting to restart the vehicle, the vehicle failed to start. The vehicle was towed to a local dealer. The vehicle was diagnosed, and it was determined that the engine had seized and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to the federal safety agency Campaign Number: 17V224000 (Engine and Engine Cooling); however, the contact was informed that the VIN was not included in the recall. The failure mileage was approximately 250,000.

Filed Oct 19, 2025 · Engine · CO · fire

Engine Seized After Kia Recall Repairs – Safety Defect Recurrence I own a Kia vehicle (VIN: [XXX] ) with a rebuilt title. Kia performed engine recall work on my vehicle at Fowler Kia in Longmont, Colorado. The service advisor stated the recall was to “protect the engine from seizing.” After driving around 18,000 miles since the recall service, the engine seized suddenly while operating. Kia Customer Affairs has denied warranty coverage because of the salvage title, but this does not change the fact that the defect is safety-related and persisted after recall work. This creates a serious safety concern because: The engine failure happened without warning, Kia performed the recall on this exact safety defect, And now they are denying any further responsibility. I request that the federal safety agency investigate Kia’s handling of safety recalls on vehicles with rebuilt titles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)