2016 Kia Optima: engine failure

Filed Nov 5, 2026 · Engine · AZ

My Kia experienced catastrophic engine failure while I was driving on the freeway, creating an extremely frightening and dangerous situation. The sudden loss of engine power put my safety and the safety of surrounding motorists at risk, as I was traveling at freeway speeds when the engine gave out. Leading up to the failure, my vehicle experienced excessive oil consumption despite regular maintenance. I was repeatedly adding oil between scheduled oil changes. Previous repairs, including replacement of spark plugs and a thermostat, did not resolve the underlying issue. Following the engine failure, a Kia dealership reported a cracked engine valve and multiple severely damaged or melted spark plugs, including spark plugs that had recently been replaced. These findings raise serious concerns about progressive internal engine damage and a potentially defective engine. Despite my concerns regarding known Kia engine defects and possible connecting rod bearing issues, the dealership stated it could not perform the bearing clearance test due to the condition of the valves. My case was never submitted to Kia Techline for further investigation. I was initially instructed to provide oil change and maintenance records for consideration of engine replacement assistance, only to later be told that excessive oil consumption was not relevant to my claim. I am extremely concerned that a potentially defective engine experienced progressive damage before suddenly failing on the freeway, placing my life and others at risk. I am requesting that the federal safety agency investigate this failure and determine whether it is related to known Kia engine defects or an unresolved safety issue affecting other vehicles.

Filed Sep 24, 2026 · Engine, Fuel system · CA

The contact owns a 2016 Kia Optima. The contact stated that while driving 25 MPH, the vehicle shut off without warning. Soon after the failure, the engine caught fire; however, the fire dissipated independently. The insurance agent was contacted and arrived at the scene to inspect the vehicle. The contact was initially informed that the vehicle was safe to drive; however, the engine failed to start after several attempts. Due to the failure, the vehicle was towed to a dealer where a mechanic discovered that the knock sensor was inoperable and had caused the fire. The contact was informed that the vehicle was included in the federal safety agency Campaign Number: 18V907000 (Fuel System, Gasoline, Engine) and the vehicle was repaired under the recall. Nearly a month after the repair, the vehicle started consuming oil with the master warning light displayed. The vehicle was taken back to the dealer for an inspection; however, no fault was found with the vehicle. The manufacturer was notified of the failure, and the contact was referred to the dealer. After another inspection, the dealer agreed to replace the engine; however, the failure recurred after the repair.

Filed Aug 25, 2026 · Electrical, Lights · FL · crash

Vehicle was purchased in 2023. AC blower failure occurred for the first time in June 2024 and was repaired by PepBoys. On 4/2/2025 the ve3hicle had an active recall event when the engine seized on the highway because of a faulty oil pump/filter, Engine was replaced 4/17/2025 under that recall. Kia advised at the time that the wiring harness should be replaced due to electrical issues at the time but said that there was no recall for that work. At the time, there were no electrical failures of steering, brakes, all power etc. Nor did we know that those were a possibility. The wiring harness quote was $7,000, over the cost of the vehicle. It was decided to continue repairing the electrical issues as they came up, it was assumed that the fuses would blow before there because a safety or total vehicle failure, as automobiles are designed that way. 8/4/2026 the vehicle experienced a complete and total loss of power resulting in a traffic crash into another vehicle as the brakes felt like you were trying to push a wall rather than a pedal. There was minimal physical damage to the other car and the kia, the other driver got my husband's insurance information and then drove off. The car did startup after ~30 minutes or so and was driven home, but taken to the Kia dealership the next day. It was said that the blower motor overheated and melted a portion of the electrical junction box under the hood and that it was unsafe and dangerous to drive. Kia said that there were no active recalls for this work. the federal safety agency SC351 seems very similar to this issue that has plagued this car since the beginning. We would ask that Kia incorporate this vehicle and others outside of the year/model ranges in SC351 that have similar failure mechanisms as this seems common.

Filed Aug 21, 2026 · Brakes, Electrical · CA

While driving at highway speeds on the freeway in San Diego, the engine of my 2016 Kia Optima catastrophically seized without warning. I instantly lost all power steering, brake assist, and electrical power, creating an immediate life-threatening emergency. The vehicle was towed to a Kia dealer. Corporate Techline and the dealership are refusing to perform the mandated settlement rod bearing test and are falsifying paperwork to deny the safety remedy.

Filed Aug 5, 2026 · Engine, Transmission · FL

The engine assembly completely seized and the vehicle is currently stored at an independent repair shop . While traveling at high speed on Interstate 4 on July 24, 2026, the vehicle suffered a sudden, catastrophic loss of power and stalled in live traffic, creating an immediate threat of a high speed rear end collision. An independent service center officially confirmed the engine seizure after a dealership failed to perform an inspection during an eight hour wait, and no law enforcement or insurance inspections have occurred. Prior symptoms included severe, recurring oil loss requiring constant manual additions of oil between regular service intervals (most recently serviced in June 2026 at a kia dealership), and eventually the car completely shutoff on July24.

Filed Jul 29, 2026 · Engine · MD

engine failure, i was driving home from work and i went to accelerate from 0 to 20 miles and the car hesitated and didn't want to move. I took the car to the dealer three days later and it was confirmed that i needed a new engine. I was told by the dealership i was outside of my warranty but i just found out that i was covered up to 120k miles. No lights came on at the time and there wasn't any prior warnings to this happening. I had just put oil into the car two days earlier as i know in between oil changes that i have to put oil into the car and or check the oil to see if it is low.

Filed Jun 16, 2026 · Engine · CO

the engine. I was at a stop sign when the car stop responding to me pressing the accelerator and would not go. Upon further inspection it was noted that my car had no oil in it. I am diligent in getting my oil changed every 3 months or 3,000 miles. My engine had "seized" and i am being advised to purchase a new engine or purchase a new car. While trying to get my car to acclerate i was almost hit 4 times in a matter of 10 mins.

Filed Jun 16, 2026 · Engine, Fuel system · CA

My 2016 Kia Optima equipped with the 2.4L DOHC I4 GDI engine began to experience progressive and severe oil consumption during the latter part of my ownership. The oil warning light began activating repeatedly, even after shortly getting the oil changed. Several certified mechanics and oil change service stations told me this was an ongoing issue with this car and engine and that there was nothing I could do but monitor it and keep it filled. At their instruction, I monitored and had it changed more frequently, often topping it off at the oil change station and at home when needed. Approximately 2 weeks after an oil change upon putting the car in reverse it started to shake uncontrollably. The car was towed to a mechanic who stated I needed an engine. I then towed it to an authorized Kia franchise dealership where the technician documented the oil consumption complaint, confirmed a Cylinder 2 misfire code, performed a borescope inspection, and found the Cylinder 2 exhaust valve burnt with a chunk missing. Engine replacement was recommended by the Kia dealership technician. Prior to my purchase, the engine had already been replaced at approximately 80,000 miles under recall-related circumstances. The replacement engine installed by a Kia dealership subsequently failed, exhibiting symptoms consistent with the documented widespread defect affecting the 2.4L DOHC I4 GDI engine in 2016 Kia Optima vehicles, including severe oil consumption, cylinder misfire, and catastrophic internal engine damage confirmed via borescope at a Kia franchise dealership. Kia America denied the claim based solely on mileage despite the damage being confirmed by their franchise technician. My vehicle became unsafe to drive due to this engine instability shortly after starting before becoming fully inoperable. My vehicle has been non-operational for approximately 5 months. Kia has not provided a substantive written determination despite a formal written demand submitted in March 2026.

Filed May 28, 2026 · Engine · AZ

This vehicle is eligible for Theta II class action settlement, and I cannot seem to get the Kia dealerships, or the Kia Corporate to honor the engine failure issue that I was told by the AAA mechanic should have been replaced. I have also been told by others, including another mechanic at a nationally recognized mechanic that it needs to be taken care of, and that they had the same vehicle and had there's taken care of without any issues.

Filed May 8, 2026 · Engine · TN

I purchased a Kia Optima 2016, in December of 2025. At the time the car wouldn't go over 60 mph. I hauled the car to Kia to have it inspected. The Kia dealership informed me that there is a recall on that particular car for an engine replacement. They tested the car and later informed me that they believed I purchased the car knowing it had a recall and wanted the engine replaced for free so I could sell the car. The car is not for sale, and I had/have no intentions on selling the car. I went ahead and paid $6100 for the engine to be replaced. I later did research and learned that if a car has a recall, it doesn't matter my intentions with the car. I felt that Kia denied a replacement engine because of their opinion of me and not for the recall. The car is registered and insured in my name and is being driven daily. At this time, I feel that I deserve a refund of the $6100. Can you guide me on which steps to take on this matter?

Filed Feb 17, 2026 · Engine, Fuel system · 105,000 miles · CA

The contact owns a 2016 Kia Optima. The contact stated that while driving at 60 MPH, the vehicle stalled with the check engine light illuminated. The brake pedal was depressed, and the steering wheel seized. The contact was able to pull over to the side of the highway and contacted the Highway Patrol for assistance. The contact associated the federal safety agency Campaign Number: 18V907000 (FUEL SYSTEM, GASOLINE, ENGINE); with the failure; however, the VIN was not included in the recall. The vehicle was towed to the residence. The dealer was not notified. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 105,000.

Filed Feb 17, 2026 · Engine · 143,000 miles · TX

The contact owns a 2016 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle shuddered. No warning lights were illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and stated that the knock sensor needed to be installed prior to the failure for the engine replacement to be covered under warranty. The failure mileage was approximately 143,000.