2016 Kia Sorento body problems

Filed Sep 29, 2026 · Body · CA

I am the original, single owner of a 2016 Kia Sorento in Snow White Pearl. My vehicle currently has approximately 96,000 miles on it. Roughly one year ago, the factory paint began catastrophically peeling, flaking, and deteriorating in large sheets on the roof and near the passenger-side door. This damage is not the result of environmental wear, stone chips, or poor maintenance. It is a documented, widespread manufacturing defect—specifically, a factory primer-adhesion failure (delamination)—that uniquely impacts Kia and Hyundai vehicles painted in this specific Snow White Pearl finish. I contacted Kia Consumer Care to resolve this issue and was assigned Case Number 26409995. Despite my status as a loyal, original owner of a vehicle under 100,000 miles, Kia issued a blanket denial of assistance. Kia is well aware of this systemic manufacturing defect, as their sister company Hyundai has previously extended paint warranties to 10+ years for identical white paint delamination issues. Kia’s refusal to remedy this known defect constitutes unfair and deceptive consumer business practices under California law. My vehicle specifically features Kia’s "Snow White Pearl", which is widely documented to have a latent factory defect. The core issue stems from an original chemical failure where the white base paint layer did not properly bond or fuse to the factory primer layer. Over time, exposure to atmospheric heat, rain, or vibration causes the top layers to completely delaminate and flake off in massive chunks, often exposing the bare gray primer underneath. When multiple panels peel, it presents a safety hazard if paint flakes off into the vision of drivers behind me.

Filed Aug 20, 2026 · Body, Lights · 215,640 miles · TN

See attached document for complaint.

Filed Aug 20, 2026 · Body · SC

The paint iscoming off and don't stick to the vehicle. I need kia to paint this car asap

Filed Aug 14, 2026 · Body · CA

Vehicle: 2016 Kia Sorento EX VIN: [XXX] Current Mileage: Approximately 67,000 Component: Paint/Body (Exterior Finish) My 2016 Kia Sorento (Snow White Pearl / Pearl White) has developed premature, multi-panel paint failure. Flaking began appearing on the roof rail area above the front doors in late summer 2025, followed by flaking on the hood, and later bubbling on the rear driver-side door. Flakes recovered from the ground beneath the vehicle have consistently been approximately the size of a 50-cent piece. At the manufacturer's request, three independent, licensed California collision repair facilities inspected the vehicle. All three independently identified a paint adhesion or chemical bonding failure, not ordinary wear. One shop's written estimate states verbatim that "the sealer did not chemically bond when basecoat was applied." Another states it cannot warranty a repair unless affected panels are stripped to bare metal and fully refinished. Repair estimates to properly address the condition range from approximately $9,000 to $17,000. Kia has already acknowledged this as a defect meriting manufacturer assistance, having extended a goodwill offer covering partial repainting costs. I am filing this report to document a paint system manufacturing defect, consistent with a pattern reported by other Kia Sorento owners and referenced in at least one prior Kia service bulletin (SA166) addressing paint peeling on Sorento door panels. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 26, 2026 · Airbags, Body · AZ

The exterior paint on my 2016 Kia Sorento (Snow White Pearl, paint code SWP) is peeling off in large chunks across multiple panels. The clear coat is delaminating and lifting in sheets from the surface, exposing bare metal underneath which is now actively rusting. This is consistent with a known defect documented in hundreds of complaints about 2013-2016 Kia Sorentos in Snow White Pearl (SWP). I have photographic documentation showing significant progression of this damage over the past few months. The vehicle has not been inspected by a dealer or manufacturer regarding this issue. No warning was given prior to the paint failure — it began suddenly and has spread rapidly. The vehicle is available for inspection upon request. Additionally, the gear shift randomly locks in Park without warning, leaving me unable to operate the vehicle. This has occurred on multiple occasions and presents a direct safety risk as it strands me without notice. No warning lights or messages appeared prior to the shift lock engaging. The dashboard is also cracking in multiple locations, including near the airbag housing, which may present an additional safety concern.

Filed Feb 2, 2026 · Body · GA

Pearl white paint has begun flaking, and peeling.

Filed Jan 16, 2026 · Body · AZ

I have a white pearl 2016 Sorento and Paint started peeling around windshield. Now paint is peeling all over. Recently had windy day and sheets of paint are laying on ground. I take care of my car and this is embarrassing. Kia should be embarrassed as well. Not good for sales I’m sure.

Filed Oct 22, 2025 · Body · 86,711 miles · FL

The contact owns a 2016 Kia Sorento. The contact stated that the dashboard was cracked in the shape of an air bag on both the left and right sides, causing concerns about a potential inadvertent air bag deployment. There were no warning lights illuminated. The vehicle was taken to a local dealer, who confirmed that the crack was cosmetic and advised the contact to reach out again if the air bag started to protrude through the crack. The vehicle was not repaired. The contact reached out to the manufacturer and provided photos, but received no assistance. The approximate failure mileage was 86,711.

Filed Oct 2, 2025 · Body · NY

We have a 2016 Kia Sorento that has the Snow White Pearl paint. Our vehicle has a tad over 100k miles and the paint is peeling. We take care of our car and always have it clean and do not understand why this is happening. Paint is flaking / peeling off in large amounts exposing the primer underneath. I had a body shop look at it and they say it looks like something went wrong with the painting process when vehicle was made. I have a 1997 ford ranger that has 280k miles on it without this issue so I do not believe that this is a mileage / age issue. I did reach out to kia but had no luck with this problem. Thank you so much for your time and any help is greatly appreciated.

Filed Aug 25, 2025 · Body, Engine · NC

I now believe I've had a lemon. Since I purchased my car in 2016 they have been trying to diagnose a smell from the exhaust and started replacing parts, this was in Miami. Then for a few years in Vegas the car spent months at the dealership trying to fix a burning oil issue which I've been told there is a known problem with the turbo still isn't fixed. From the first year I had paint peeling on my snow white pearl color which has numerous forums about KIA/Hyundai paint issues especially with my color. I had them repaint the hood which took twice after the bad job the first time. I saw little bumps in the paint which I thought was over-spray from that incident and now I have peeling from one of those spots which is how they form from what i read. My car is 2016 but only has 65k miles. The spot now is getting bigger by the week, the rain isn't helping. there are other spots around the edges and a big spot on the roof and others I've already filled in with a paint pen which looks ugly. If you see my car, inside and out it looks pretty close to new from the way I've taken care of the car. The paint started in August of 2016 but most recently 2025. The engine issues were day one but most recently 2024 they fixed a cylinder that got a hole in it after consuming all the oil and it seems to be headed down that path with the remedy they are offering at KIA. The engine and paint should be convered under a class action lawsuit or recall to hold them accountable and fix the issues.