2009 Mazda MAZDA6 technical service bulletins
255 technical service bulletins and manufacturer communications cover the 2009 Mazda MAZDA6.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This bulletin supersedes the previously issued bulletin(s) listed below
- Description
- Product Quality Information (PQI) DESCRIPTION Service Information MT-041/12 is no longer valid
- This bulletin supersedes the previously issued bulletin(s) listed below
- This SA supersedes the previously issued SA(s) listed below
- This Service Alert supersedes the previously issued SA listed below: The changes are noted in Red....
- If you encounter any type of electrical concern (e.g, dead battery, engine no start, DTC(s) stored...),...
- A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating
- Exterior trim heat damage such (melted, separating, etc.) when parked near a glass building or Low-E windows
- When replacing the SiriusXM satellite radio unit, a call must be made to inform SiriusXM of the existing...
- Some customers may complain about a noisy HVAC blower motor or odor after a cabin air filter replacement
- Airbag system warning light flashing with DTC B1126:1B or B1127:1B. DTC B1126:1B
- Exterior trim heat damage such (melted, separating, etc.) when parked near a glass building or Low-E windows
- In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems
- Exterior trim heat damage when parked near a glass building or Low-E windows
- Speedometer replacement procedure
- Some customers may complain of signs of oil on the struts or shock absorbers
- In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer.
- This service bulletin provides testing and charging procedures in order to promote proper battery...
- Accessory instructions can be found on OneMazda under Dealer Resources
- The Mazda DCA-8000 is required for all warranty battery testing
- Battery Maintenance: This service bulletin provides testing and charging procedures in order to promote...
- Automatic Transmission/Transaxle Cooler and Lines Flushing Procedure: Automatic Transaxle/Transmission...
- Ethanol is becoming a common additive in gasoline
- Some customers may complain about high engine oil consumption
- Ethanol is becoming a common additive in gasoline
- This service bulletin provides information regarding the proper use of the driverâs floor mat to avoid...
- Accessory instructions can be found on OneMazda under Dealer Resources
- Exterior trim heat damage when parked near a glass building
- When programming a key or installing a Genuine Mazda Accessory Remote Engine Start system, you may...
- If you encounter any type of electrical concern (e.g, dead battery, engine no start, DTC(s) stored...),...
- Subject: UPDATE
- The Mazda DCA-8000PM is required for all warranty battery testing
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems
- In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
- Connectivity Master Unit (CMU), a BLUETOOTH® hands-free unit or text messaging related concerns
- Some customers may complain about high engine oil consumption
- New CARB regulation regarding mandatory checking and documenting of tire pressure whenever a vehicle is in...
- When encountering a vehicle with paint damage, refer to the "Mazda Paint Warranty Guide" to determine
- When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine
- In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
- Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging
- If an engine assembly is replaced after a catastrophic internal mechanical failure, clean the intake...
- There is a concern that some water pumps are being replaced that are not faulty, due to signs of a very...
- The database error discovered with IDS 114.00-114.02 release has been fixed with IDS 114.04 release and is...
- Due to a database error discovered with IDS 114.00-114.02 release (which affects Recall 3719F), it will be...
- Mazda ids inoperative with vcm-ii license expiration message
- In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak...
- Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear...
- Connectivity Master Unit (CMU), a BLUETOOTH® hands-free unit or text messaging related concerns
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight...
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems
- Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO...
- In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
- Some automotive cleaning products contain strong acid or alkali
- This information is provided to help address Passenger Airbag Deactivation (PAD) Indicator illumination...
- Mazda infotainment systems require contacting the proper source for diagnostic support, parts...
- On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system
- When replacing the SiriusXM satellite radio unit (or a MAZDA CONNECT tuner and amp unit (TAU)) with...
- This service bulletin provides information regarding the proper use of the driver's floor mat to avoid...
- The Mazda GR8-1291 is required for all warranty battery testing
- Some customers may complain of signs of oil on the struts or shock absorbers
- If a vehicle has body vibration or steering wheel shimmy while driving and the root
- Electrical concern and/or multiple dtc's due to aftermarket device
- Connectivity Master Unit (CMU), a BLUETOOTH® hands-free unit or text messaging related concerns
- Mazda North American Operations has approved an additional on-car brake lathe as an option for...
- A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating
- BLUETOOTH® hands-free and/or text messaging related concerns
- Always be sure to use the correct automatic transmission fluid when replacing ATF. Using the wrong ATF may
- If you encounter any type of electrical concern (e.g, dead battery), interview the customer before...
- This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any...
- The Mazda GR8-1291 is required for all warranty battery testing
- When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine
- The Workshop Manual has two-different airbag procedures, one for Standard Deployment and one for Two-Step...
- MIL illumination with DTC's P0441, P0442, P0455, or P0456 stored in memory
- Stopper plates for air bag module connectors have been established as new service parts.
- When dealing with customer complaints of excessive condensation and/or water within the headlamp unit,...
- In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
- In an effort to achieve a higher level of Customer Experience and retain the value of Mazda's vehicles,...
- Blind Spot Monitoring (BSM) system frequently asked questions (FAQ)
- Intermittent non-operation of the windshield wipers
- Some customers may complain that the ambient temperature display is not accurate, or it takes too long for...
- Display shows inaccurate ambient temperature
- Take caution when cleaning plastic headlight lenses
- Mazda Motor Corporation is extending the warranty coverage for a specific repair of sophisticated air bag...
- There is a concern that some water pumps are being replaced that are not faulty, due to signs of a very...
- Raising a vehicle with a jack CAN be dangerous if not done properly. the vehicle CAN slip off the jack and...
- Takata recalls general information purpose: this page was created to assist with handling takata air bag...
- When removing parts from a vehicle, take caution of this symbol "r"
- Ids update 101.00 and 101.02 is now available on MS3 under the "ids/infotainment" tab.
- When dealing with customer complaints of excessive condensation and/or water within the headlamp unit,...
- If an engine assembly is replaced after a catastrophic internal mechanical failure, clean the intake...
- Workshop manual evap system leak inspection using the m-mds has been discontinued for some models
- There are two engine timing chain types for the 2009-2013 MAZDA6 3.7L. 1. roller type timing chain is used...
- Some customers may complain about improper operation of the auto-dimming mirror
- When reprogramming a control module, always use the GR-8 battery management system power supply mode
- Over the past two weeks, an increasing number of iphone se early adopters have reported audio issues with...
- When installing a navigation sd card, confirm that the card is unlocked. also, mazda does not recommend...
- This article provides HVAC heater/defroster operating tips using mode selector dial
- This article provides HVAC heater/defroster operating tips using Mode selector dial
- When installing a navigation SD card, confirm that the card is unlocked
- Some customers may complain about a blurry rear view monitor display
- Some customers may complain about a rattle type noise coming from the rear of the vehicle when driving on...
- Some customers may complain about a blurry rear view monitor display
- Some customers may complain about a blurry rear view monitor display
- Some customers may complain about a rattle type noise coming from the rear of the vehicle when driving on...
- Please be aware that the workshop manual procedure for the 2009 through 2012 MAZDA6 (with 3.7L engine)...
- Please be aware that the Workshop Manual procedure for the 2009 through 2012 Mazda6 (with 3.7L engine)...
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight...
- Some customers may complain that the steering wheel is off center more than 3" even when driving straight...
- Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging
- Mazda guidelines for factory scheduled maintenance
- Brake noise, judder and dragging diagnosis and servicing
- Paint damage Mazda pocket paint guide
- Excessive condensation or water within the headlamp assembly caustion
- Hands-free bluetooth module and/or text messaging troubleshooting procedure
- HandsFree bluetooth module and/or text messaging troubleshooting procedure
- Sulfur smell from exhaust system.
- Battery Maintenance
- Battery test procedure requirements using the GR81291
- Shock absorber replacement guidelines
- Engine Start /Stop Procedure with room fuse removed
- PreMixed long life "FL22" Engine Coolant
- Passenger fAirbag deactivation (PAD) indicator light illumination
- Proper usage of driver's floor mat.
- Siriusxm satellite radio registration transfer after unit replacement
- Mazda Service Support MX Connect MTips
- Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear...
- Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may
- Condensation/Fog in front and rear combination lights
- Some automotive cleaning products contain strong acid or alkali
- Stains appear on wheels
- Mazda Motor Corporation is extending the warranty coverage for dashboard crash pads on certain 2009-2013...
- LDWS or ALH warning light on with DTC C1001:92
- Mazda infotainment systems require contacting the proper source for diagnostic support, parts...
- Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe...
- When dealing with customer complaints of excessive condensation and/or water within the headlamp unit,...
- Summary to be provided on a future date.
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight...
- Bluetooth® hands-free and/or text messaging related concerns. to improve the handling of bluetooth®...
- In accordance with federal regulations, follow the procedure listed below when replacing a...
- Mazda north american operations received many requests from our dealers asking us to approve additional...
- This service bulletin provides information regarding the proper use of the drivers floor mat to avoid any...
- Some customers may complain that the ambient temperature display is not accurate, or it takes too long for...
- MIL illumination with a DTC P1450:00 stored in memory.dtc P1450:00
- Unusual squeak noise when the engine is idling, or just at the moment when the engine is shut off. the...
- When replacing the siriusxm satellite radio unit (or a mazda connect tuner and amp unit (tau)) with...
- Some customers may complain of condensation/fog inside the front or rear combination lights
- Mazda: information provided regarding the indicator light illumination of the passenger airbag...
- This information is provided to help address Passenger Airbag Deactivation (PAD) Indicator illumination...
- A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it...
- To improve handling of customer concerns with hands-free (bluetooth) vehicle systems, mazda launched a new...
- Some customers may complain that the ambient temperature display is not accurate, or it takes too long for...
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle...
- Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided...
- This service bulletin provides information regarding the proper use of the drivers floor mat to avoid any...
- Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may
- Mazda: on various model years and model vehicles, the headlamp assembly would have excessive condensation...
- Some vehicles may exhibit a rattle noise and/or exhaust leaking noise from the rear of the vehicle
- Some customers may complain of signs of oil on the struts or shock absorbers
- Some customers may complain of condensation/fog inside the front or rear combination lights
- Some vehicles may exhibit an exhaust leaking noise from the rear of the vehicle
- The multi information display (MID) and navigation system support for diagnostics, parts authorization,...
- Mazda: small cracks may occur at rubber button of front door handle request switch, allowing moisture to...
- Mazda service program (MSP27) - readiness code for evaporative monitoring system
- Mazda: TPMS warning light illumindated
- Mazda: there is possible excessive condensation or water inside the headlamp unit on many mazda models
- Mazda: there is condensation and fog in the front and rear combination lights
- Mazda: the malfunction light is on and an internal trouble code
- Mazda: some vehicles expererience poor a/c or high engine coolant temps during low spees or idle
- Mazda: rear combination light heat deformation
- Mazda: rear door locks inoperative due to freezing. when ambient temperature rapidly drop below 0% f,...
- Mazda: air bag system warning light flashing
- Mazda: purge valve contact/hard rattle noise. some vehicles may experience a rattle or a loud tick noise...
- Mazda: poor a/c performance/high engine coolant temperature due to inoperative cooling fan
- Mazda: vehicles may exhibit a concern of unstable idling or, in some rare cases, stalling, just after the...
- Mazda: some vehicles equipped with auto wipers and headlamps and port installed accessory homelink/compass...
- Mazda vehicles: mazda service program (MSP20)-GLOVE box stopper over travel may experience a glove box...
- Mazda vehicles: mazda service program (MSP19)-WIND noise from driver side door sash/b pillar area
- Mazda: HVAC blower motor relay terminal inspection
- Mazda: vehicles may have improperly installed HVAC blower motor relay terminals on the engine fuse box
VIN decoder
See the problems and recalls for an exact car
Buying a used 2009 Mazda MAZDA6?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history