2010 Mercury Milan fuel system problems

Filed Aug 5, 2025 · Airbags, Fuel system · CA · crash · 1 injury

I collided with three parked vehicles and my airbags did not deploy causing me to hit my head

Filed Apr 17, 2025 · Fuel system, Steering · IL

Check engine light is on mechanic says it's a fuel tank issue

Filed Mar 24, 2023 · Fuel system · 95,000 miles · MD

The contact's father-in-law owns a 2010 Mercury Milan. The contact stated that upon refueling the vehicle, her father-in-law noticed that fuel was leaking on the rear passenger side tire. The contact's husband then verified that fuel was leaking from the fuel tank. The vehicle was taken to the dealer, where it was diagnosed that the fuel tank was fractured and needed to be replaced. The dealer diagnosed and determined that the failure was related to the federal safety agency Campaign Number: 15V793000 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was taken for State Inspection, where it was diagnosed with evaporated emission system leak related to the canister purge valve. The contact's husband replaced the canister purge valve; however, the failure persisted. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall. The manufacturer referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 95,000

Filed Mar 22, 2021 · Airbags, Fuel system · 126,000 miles · GA

Started my car up and it said power steering failed..I cut the car off and waited then it went off...as I was headed to work the airbag light came on for the passenger side..I pulled into the store turned the car off a while and started it back up the light went off before leaving work the power steering message popped back up I once again turned off the car for a while...I manage to make it home but a mile from my house the airbag light once again came on.. Please check into this..I love my life and the life of my loved ones driving like this is very dangerous and this is my only means of transportation.

Filed Oct 25, 2019 · Fuel system · GA

Tl* the contact owns a 2010 mercury milan. The contact stated that the fuel tank fractured and leaked fuel. The contact stated that the vehicle had been at an independent mechanic for four weeks now. The vehicle was taken to legacy ford (413 industrial blvd, mcdonough, ga 30253, (770) 914-2800) one year ago to be repaired per an unknown recall. The dealer stated that there was no failure with the vehicle and diagnostic testing did not reveal a code regarding a vapor lock failure that may have damaged the fuel tank. The contact began to smell a fuel odor on september 25, 2019 and she noticed a huge puddle of fuel on the driveway. She took the vehicle back to the dealer and was shown the stress crack on the fuel tank. The dealer acknowledged that the failure was from the recall repair a year earlier; however, they would have to charge the contact for the repairs. The manufacturer was contacted, but the dealer and contact had not heard back. The failure mileage was unknown.

Filed Oct 20, 2019 · Fuel system · NY

My check engine light came on and was checked and the fuel vapor canister purge valve is not operating properly

Filed May 21, 2019 · Brakes, Fuel system · 70,000 miles · KY

Tl* the contact owns a 2010 mercury milan. The contact stated that the vehicle leaked fuel and there was an abnormal fuel odor inside the vehicle. The vehicle was taken to oxmoor ford lincoln (100 oxmoor ln, louisville, ky 40222, (502) 426-2500) where it was diagnosed that a new fuel tank was needed. The vehicle was not repaired. The dealer also found that the rear brakes needed to be replaced. New brakes were installed; however, front brakes were installed instead of rear brakes. The manufacturer was not made aware of the failures. The failure mileage was 70,000.

Filed Apr 29, 2019 · Fuel system · NJ

Tl* the contact owns a 2010 mercury milan. The contact received a recall notice for the federal safety agency campaign number: 15v793000 (fuel system gasoline) and stated that the manufacturer exceeded a reasonable amount of time to repair the vehicle. The dealer (stevens jersey city ford, 740 nj-440, jersey city, nj 07304) confirmed that parts were not available to perform the recall repair. The manufacturer was not notified. The contact had not experienced a failure. Parts distribution disconnect.

Filed Sep 11, 2018 · Engine, Fuel system · 71,000 miles · NJ

Tl* the contact owns a 2010 mercury milan. The contact stated that the fuel inlet and check engine warning indicators illuminated intermittently. The contact stated that the vehicle exhibited the same symptoms as listed in the federal safety agency campaign number: 15v793000 (fuel system, gasoline), which she received. The vehicle was serviced by holman ford (3641 nj-42, turnersville, nj 08012, 888‑449‑0296), but the failures recurred. The manufacturer was notified of the failures and stated that nothing could be done since the vehicle had already been serviced. The failure mileage was approximately 71,000.

Filed Jun 3, 2018 · Fuel system, Steering · 166,000 miles · ND · crash

Well for starters its throwing a code saying that I have a small fuel leak some where and the 2 is one day I had a flat and after I changed the tire the power steering went out and not only that but the car has a heavy vibration in it and while driving it want to take off either left or right which ended up with me running off the road twice already