1993 Nissan Pathfinder problems

Filed Jan 28, 2011 · Body, Brakes · 176,613 miles · IA

This is the second 1993 nissan pathfinder I have owned and both have had the exact same problem with the frame. The rear crossmember completely rusts out and falls off the problem is vary dangerous not only to other drivers but it also severs the rear brake line. I was driving in my ally hit a pot hole doing maybe 10 tops went to stop and could not had to use the emergency brake to stop. I could have killed someone or myself. There needs to be a recall on all the old model frames cus it is a continues problem.

Filed Feb 2, 2009 · Body, Suspension · 100,000 miles · MO

Rear suspension has separated from the frame due to extreme rusting of frame rails. Excess movement of rear axle from separation damaged the brake line and caused loss of rear brakes.

Filed Nov 23, 2007 · Tires · 197,043 miles · NC

*note: the tires in question are size 235/75r15...this size option was not available in the drop down box./// blowout and near accident occurred. After further evaluation it was determined the sidewalls of the front right tire had collapsed upon entering a slow curve. The condition had existed earlier as the sidewalls were worn to the threads being exposed. After further evaluation ;all four tires seem to have a very flimsy and sub-standard sidewall construction. The vehicle will not be driven until all four tires can be replaced.

Filed Oct 1, 2005 · Tires · 171,357 miles · NY

I'm a consumer who just had four new cooper discoverer ast ii tires installed on a '93 nissan pathfinder. All failed within 709 miles, approximately one month of driving. After driving two weeks and 555 miles, the front left tire suddenly blew out in my driveway. It appeared to fail at the bead. My tire dealer turned the tire over to a cooper rep who examined the tire and said the shop installed it improperly, leading to the failure. The shop disagreed with the finding, but they replaced the tire free of charge. Two weeks and 154 miles later, I noticed the three other coopers were failing. The rears had softball-sized bulges on the tire wall extending from the bead toward the tread. The right front had a baseball-sized bulge in the same location. All the bulges were on the inboard, whitewall side of the tire. My shop's owner personally pulled the tires, examined them, and found bare bead wire adjacent to the bulge. The bare wire was 1-2 inches long. He says the location of the bare wire/bulge falls on the bottom side of the tire during mounting--a spot not contacted by the mounting bar during installation. Furthermore, he said he found no scuffing inside the tire indicating contact with the mounting bar and no loose rubber inside the tire, further indicative of damage during mounting. He trusts his installer, a 10-year employee who installs 100 tires a week. He's convinced the tires were defectively manufactured. My dealer has followed up with cooper. The company insists the tires were damaged during installation, but it went ahead and credited the shop the cost of the tires. My dealer had a similar failure on a cooper lifeliner sle tire a month earlier, and cooper denied any problems on their part in that incident as well. The tires are cooper astii, p235-75-15 I pulled one dot#...3d1tcla2305 thanks --- bruce stoff, ithaca ny.

Filed May 8, 2005 · Body · OH

Frame verry rusty and broke in rear of vehicle

Filed Nov 9, 2004 · Engine · 36,705 miles · CA

There is a recurring problem with the exhaust manifold and the manifold studs breaking, resulting in an exhaust leak inside the engine compartment which causes exhaust fumes to enter the passenger compartment.

Filed Nov 13, 2003 · Engine · 56,500 miles · HI

Exhaust manifold leaks due to poor quality exhaust manifold and/or bolts.

Filed Sep 4, 2003 · Engine · 105,000 miles · CA

Exhuast manifold studs keep breaking causing leakage, fumes, and noise. Has happened 3 times in 45k miles at $500 to $1200 per incident. Have filed complaint with nissan consumer affairs (incident 4259794). Nissan declined to assist because they said vechicle was beyond useful service life. Even if that were true, the repairs I'm paying them for over and over should have a useful service life. I've been told by several dealers that this will continue to happen. Common nissan, fix this problem once and for all. I just want to have it fixed once and for all without having to keep on paying for this. Check out this forum http://forums.vmag.com/suvpathfinder0200 where there are literally 100's of complaints.

Filed Mar 6, 2003 · Body · 133,000 miles · NH

Consumer was informed the rear end frame of the vehicle was full of body rot, and if impacted in an accident, it would disintegrate.

Filed Feb 19, 2003 · Body · 165,000 miles · PA

The frame of the vehicle had rusted on 2 occasions.