The contact owns 2024 Peterbilt 567. The contact stated that while driving 25 MPH, there was a strong fuel odor coming from the vehicle. No warning lights were illuminated. The vehicle was driving to the dealer to be diagnosed and it was determined that the fuel tank was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was attempted to be notified; however, the manufacturer was no longer in business. The approximate failure mileage was 20,000.
The worst 2024 Peterbilt 567 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Fuel system1
- Transmission1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system1
- Transmission1
Recalls 8
Exterior lighting: lighting control module: software
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2024-2026 Kenworth T480, T680, T880, W990, Peterbilt 520, 536, 537, 548, 567, 579, 589, 2025 Kenworth T180, Peterbilt 535, 2025-2026 Kenworth T280, T380 and L770 vehicles. The tail brake light, upper and lower beam headlights, reverse light, and turn signal may not illuminate as intended. In addition, the lift axles, if lowered, may revert to a raised position, or oscillate up and down when the signal warning lights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
- Risk
- Delayed and unsteady headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash. In addition, an unexpected position change of the lift axles may increase the risk of injury.
- Remedy
- Dealers will update the VCU software, free of charge. Owner letters were mailed August 19, 2025. Owners may contact Kenworth's customer service at 1‑425‑828‑5888 and Peterbilt's customer service at 1‑940‑591‑4220. PACCAR's number for this recall is 25PACF.
Recall number 25V436000 · Recall details
Service brakes, air: antilock: modulator
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 2026 Peterbilt 548, 589, and 2024-2026 Peterbilt 567 trucks. The rear brake piping assembly may have insufficient clearance, which can result in a loss of service brakes or anti-lock brake function.
- Risk
- Brake failure can increase the risk of a crash.
- Remedy
- Dealers will install new brake hoses and correct the rear brake piping assembly, free of charge. Owner letters were mailed September 8, 2025. Owners may contact Peterbilt's customer service at 1‑940‑591‑4220. PACCAR's number for this recall is 25PBE.
Recall number 25V353000 · Recall details
Electrical system: software
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop functioning.
- Risk
- Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may not function properly or at all, increasing the risk of a crash.
- Remedy
- Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed February 3, 2025. Owners may contact Kenworth's customer service at 1‑425‑828‑5888 and Peterbilt's customer service at 1‑940‑591‑4220. PACCAR's numbers for this recall are 24KWL and 24PBL.
Recall number 24V915000 · Recall details
Steering: linkages: tie rod assembly
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 389, 548, Kenworth T480, T800, 2024-2025 Peterbilt 520, 567 and Kenworth T880 vehicles with PACCAR 20k steer axles. The steering arm and/or tie rod bracket fasteners may fail, resulting in a loss of steering control.
- Risk
- A loss of steering control increases the risk of a crash.
- Remedy
- Dealers will install new correctly torqued fasteners, free of charge. Owner notification letters were mailed January 21, 2025. Owners may contact Kenworth's customer service at 1‑425‑828‑5888 or Peterbilt's customer service at 1‑940‑591‑4220. PACCAR's numbers for this recall are 24KWK and 24PBK.
Recall number 24V908000 · Recall details
Power train: automatic transmission: lever and linkage: column shift
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Peterbilt 365, 367, 389, 535, 536, 537, 548, 567, 579, and 2021-2025 Kenworth T180, T280, T380, T480, T680, T880 and W990 trucks. The right-hand gear shifter stalk connectors may have been improperly crimped, resulting in a loss of communication.
- Risk
- A loss of communication between the gear shifter and the transmission may result in the vehicle becoming disabled after coming to a stop, increasing the risk of a crash.
- Remedy
- Dealers will inspect and replace the gear shifter assembly as necessary, free of charge. Owner letters were mailed December 15, 2025, then phased after that. Owners may contact Kenworth customer service at 1‑425‑828‑5888 or Peterbilt customer service at 1‑940‑591‑4220. PACCAR's numbers for this recall are 24PBE and 24KWE.
Recall number 24V190000 · Recall details
Steering: linkages: knuckle: spindle: arm
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 389, 520, 567, and Kenworth T800, T880, W900, and W990 trucks. The bearing journals may not be fully seated in the steering knuckle assemblies, preventing the proper installation of the wheel end hub assemblies.
- Risk
- An improperly installed wheel end hub assembly can leak oil, causing the axle spindles to loosen or fracture and increasing the risk of a crash.
- Remedy
- Dealers will inspect and replace the steering knuckle assemblies as necessary, free of charge. Owner letters were mailed February 23, 2024. Owners may contact Peterbilt customer service at 1‑940‑591‑4220 and/or Kenworth customer service at 1‑425‑828‑5888. PACCAR's numbers for this recall are 24PBB and 24KWB.
Recall number 24V043000 · Recall details
Steering
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2024-2025 Kenworth T280, T380, T480, T680, T880, L770, W990, and 2024-2025 Peterbilt 389, 520, 535, 536, 537, 548, 567, 579, 589 trucks. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.
- Risk
- A loss of steering control increases the risk of a crash.
- Remedy
- Dealers will inspect and replace the steering gears as necessary, free of charge. Owner notification letters were mailed March 20, 2024. Owners may contact Peterbilt customer service at 1‑940‑591‑4220 and/or Kenworth customer service at 1‑425‑828‑5888. PACCAR's numbers for this recall are 24PBC and 24KWC.
Recall number 24V044000 · Recall details
Fuel system, diesel: storage: tank assembly
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Peterbilt 579 and 567 trucks. The U-bolts that attach the air tank to the chassis may contact the fuel tank and over time, wear a hole in the tank.
- Risk
- A punctured fuel tank can leak fuel, increasing the risk of a fire.
- Remedy
- Dealers will inspect and trim the U-bolts, and replace the fuel tank as necessary, free of charge. Owner notification letters were mailed November 3, 2023. Owners may contact Peterbilt's customer service at 1‑940‑591‑4220. PACCAR's number for this recall is 23PBH.
Recall number 23V653000 · Recall details
Technical service bulletins for the 2024 Peterbilt 567 77
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Fuel Injection Pump part number 2344776PEX for MX-13 engines has been added to this warranty policy.
- 32 fuel injector part numbers (16 for MX-11 and 16 for MX-13) have been added to this warranty policy.
- The new 2.1m day cab lift tools, a Level 3 mandatory tool, are now available to order.
- There is an update to the CARB Base Emissions Warranty Limits table and Manufacturer’s Warranty Coverage...
- Due to supplier constraints, an authorized aftermarket surge tank has been made available.
- "Kenworth: Dealers should check the chassis list and SIR weekly for VIN changes
- An exhaust manifold slip joint seal kit is now available for EPA 2017-2024 PACCAR MX-13 engines.
- [SmartAir / KIMS] A/C systems may shut down prematurely when voltage levels drop below a certain threshold.
- "KW: A link to the PACCAR Powertrain Prognostics Webcast has been added in the Links section
- This optional software update is expected to be available after 08/28/2026.
What 2024 Peterbilt 567 owners say
Most recent owner complaints, unedited.
Right side transmission stalk failed. Truck shut down and was only able to get partially out of 4 lane highway. Truck had to be towed as it would not reset/clear. Dealer replaced transmission stalk. Despite there being a safety recall for these devices (24v-190), and this truck meeting all requirements to be included in the recall, Peterbilt says it is not included and is currently offering no cost covered repair. We also had another truck have the same issue a few months ago.
Compare the 2024 Peterbilt 567
Other model years
Questions about the 2024 Peterbilt 567
Is the 2024 Peterbilt 567 reliable?
Owners have filed 2 complaints about the 2024 Peterbilt 567, close to a typical 567 model year.
What is the most common problem with the 2024 Peterbilt 567?
Fuel and propulsion system, with 1 complaint. Next is transmission (1).
How many recalls does the 2024 Peterbilt 567 have?
8 recalls, covering exterior lighting, service brakes, air and electrical system.
Was there a recall on the 2024 Peterbilt 567 fuel system?
Yes, 1 recall: 23V653000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2024 Peterbilt 567?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history