1996 Plymouth Voyager brakes problems

Filed Apr 15, 2008 · Brakes, Engine · 68,000 miles · OH

Tl*the contact owns a 1996 chrysler voyager. After purchasing the vehicle, the defogger failed to operate normally. The driver had to stop the vehicle in order to clean the windows. There have been several failures with the vehicle since it was purchased. The engine was rebuilt and the serpentine belt was replaced on five occasions. The steering was replaced incorrectly by a dealer and was authorized by the manufacturer to be replaced. The brakes and the heating system were replaced under the extended warranty; however, the brakes were replaced four times. The contact was charged $100 per visit. Invoices are available if needed. A complaint was also filed with the state attorney general. The contact is disabled and aware of the safety risk involved in the numerous vehicle failures. On march 27, 2008, the dealer replaced the manifold and cylinder. On april 14, 2008, while making a right turn at approximately 30 MPH, the steering wheel locked. The vehicle was towed back to the dealer. The dealer stated that they really care about their customers and would be willing to do a buyout. The powertrain was unknown. The failure mileage was 68,000 and current mileage was 80,995.

Filed Nov 2, 2005 · Brakes, Steering · 63,320 miles · OH

Dt: the contact stated there were several safety defects within vehicle. The service dealer attempted to repair the vehicle numerous times. There was a problem with the defrosting system, the air conditioning belt, heater core, and heater blower, they were all replaced. The replacement of these parts did not solve the defrosting problem. The steering column shook while driving at normal speeds. The dealer has not been able to diagnose the source of the steering vibration. There was a squeaking noise in the brakes. The dealer said this was normal because the vehicle was not in use for a long period of time. The dealer indicated the noise would end with normal use, but the noise continued. *ak updated 12/7/2005 -

Filed Aug 27, 2004 · Brakes · KY

While applying the brakes pedal went to the floor. Consumer was able to drive the vehicle to the dealer for inspection, and mechanic could not duplicate the problem.

Filed May 25, 2004 · Brakes · 144,000 miles · MD

Catastrophic failure of the master hydraulic control module (ABS) leaving only 5% braking capability. No brake warning light, no defect code in computer. Occured while in driveway.

Filed Mar 18, 2002 · Brakes · NY

While driving, could feel brakes holding. Dealer had to replace brake pads, shoes and rotors due to wearing out. *ak brakes on vehicle fail often.

Filed Jan 16, 2002 · Brakes · CA

While driving would step on brakes pedal, brakes would make loud noise, and there was extended stopping distance. Dealer had been contacted. Please provide more information.

Filed Jan 15, 2002 · Brakes · AZ

While driving about any MPH could step on brakes, but vehicle will not stop on time. Brakes had to be replaced,. But, time in time the problem reappeared. Please provide more information.

Filed Oct 10, 2001 · Acceleration, Brakes · VA

Electronic contol unit is bad. This controlls the wipers as well as many other things. Only the windshield wipers do not at this time. I thought we would crash into some when we were on the highway and a big rainstorm hit. We could'nt see anything, it was very scarry. Dealer estimates $579.00 for repair/replacement. Chrysler said "too bad" "not our problem". Also, the parking brake does not hold. I had that checked @ the dealer, who said it could not be adjusted any further w/o risk of the brakes locking up. They also mentioned, the cable was fine, it was not stretched and did not need to be replaced. When we use the AC system, it gives off a bad smell. I think there is some filter in the system somewhere, but they state at the dealership, it does not affect the interior smell of the vehicle when replaced. In otherwords, it will not make the smell go away. The lugage rack does not stay locked in place when adjusted. The locks will not work to hold the adjustable bars in place. The cruise control accelerates far too quickly from the steering column buttons. It also does not dissengage when I try to use the buttons. Thank you for your time and patience! :o)

Filed Aug 28, 2001 · Brakes · MD · crash

I am convinced the ABS failed and contributed to the collision that occurred. I know how to use the ABS and have practiced with it, so know how it feels when the system engages. This is the second time the ABS has not functioned - the first time nothing was found wrong! This time it is being checked again. There were no injuries but much car damage. No estimates yet.

Filed May 29, 2001 · Brakes · UT

Brakes lock up when brakes are applied and have difficulty releasing. There will be a burning smell emitted when this problem occurs. Dealership and also private mechanics have examined vehicle, and replaced numerous components in braking system. It has been suggested that computer could be faulty because windshield wipers will engage on their own. Please provide any additional information/attachments.