2002 Saturn Vue technical service bulletins
485 technical service bulletins and manufacturer communications cover the 2002 Saturn Vue.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
- This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
- Unknown or other
- Electrical system
- Unknown or other
- Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles
- This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as...
- This service bulletin provides information for dealers/technicians on Service Programming System (SPS)...
- This bulletin provides information for electrical ground repairs using new General Motors replacement...
- This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake...
- This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil...
- This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License...
- This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- Equipment: other: owners/service/other manual
- Back over prevention
- This service bulletin provides information about the Hunter wheel Road Force balancers that should be...
- This service bulletin provides information for dealers on how to submit a product information report (PIR)...
- This service bulletin provides graphics, information and guidelines for engine component wear to assist...
- Engine
- This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter...
- This service bulletin provides service information on new torque specification and installation procedure...
- This warranty administration bulletin provides information regarding the field action courtesy...
- This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water...
- Visibility: defroster/defogger/HVAC system: rear window: electrical heating element
- Unknown or other
- Power train
- Equipment
- Fuel system, gasoline
- Equipment
- Equipment
- This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake...
- This informational bulletin provides information on key code security rules and information on GM keycode...
- Equipment: electrical: anti-theft devices
- This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and...
- This informational bulletin provides information for dealers how to submit a product information report...
- This informational bulletin provides information on key code security and information on GM key code look...
- Equipment
- This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves,...
- Engine and engine cooling: exhaust system: emission control
- Equipment: electrical: radio/tape deck/cd etc.
- Equipment
- Engine
- Equipment
- Equipment
- These 2 SKUs are Front Left/Front Right Stabilizer Links
- Engine
- Equipment
- Engine and engine cooling
- Electrical system: instrument cluster/panel
- Equipment: electrical
- Electrical system: software
- Equipment: other: owners/service/other manual
- This informational bulletin explains how to update the older Onstar module software to new software over GSA.
- This informational bulletin provides information for dealers how to submit a product information report.
- Electrical system: software
- Steering
- Electrical system: software
- Engine
- This informational bulletin provides information on OnStar® VCIM is currently restricted parts
- Electrical system
- Equipment adaptive/mobility
- Electrical system
- This preliminary information communication provides information to the technician about vehicles that have...
- This informational bulletin provides additional information on how to install pistons and suggest what...
- This technical bulletin provides a procedure to reprogram the media disc player with the latest...
- This informational bulletin provides information to gm dealers on the correct cleaning methods when...
- This preliminary information communication advises the technician if unable to place an onstar call in the...
- This preliminary information communication advises the technician on the steps to diagnose and repair the...
- This preliminary information communication advises the technician the steps on repairing the concern
- This preliminary information communication provides information to help the dealership technicians perform...
- This preliminary information communication advises the technician on the steps for diagnosing the concern
- This preliminary information communication advises the technician, if unable to place an onstar call in...
- Equipment: electrical
- This informational bulletin provides information on vehicles may rock or move slightly forward or rearward...
- Engine and engine cooling: exhaust system: emission control: catalytic convertor
- Equipment: electrical
- This informational bulletin provides an out line on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp...
- This informational bulletin provides information on Clarification of Use
- This preliminary information communication provides information to the technician about finding needle...
- This informational bulletin provides information on exterior lamp condinsation and replacement guidelines
- This informational bulletin provides information on Part Restriction and Ordering Process Information for...
- Equipment: electrical: radio/tape deck/cd etc.
- Fuel system, gasoline
- OnStar® Voice Fallback Number Update Some customers may have received a letter from OnStar® stating that...
- Engine and engine cooling: exhaust system: emission control: catalytic convertor
- Equipment: electrical: navigational system(global positioning system)
- Electrical system
- Fuel system, gasoline
- This informational bulletin provides information to advise dealers about seat belt buckles not operating...
- Electrical system
- This informational bulletin provides information on a GM of Canada OnStar® cellular communication upgrade.
- Equipment adaptive/mobility
- Electrical system
- Equipment: other: owners/service/other manual
- This informational bulletin provides dealership personnel with information on flexible fuel vehicles...
- This informational bulletin provides information to assist dealership personnel with the identification of...
- Special coverage (revised model year vehicles). some 2005-2006 model year (MY) chevrolet equinox, 2006 my...
- This informational bulletin provides information to dealership personnel on upgrading certain OnStar...
- This informational bulletin provides information on communication with OnStar® module after Canadian...
- Equipment: electrical
- This informational bulletin updates information on electrical ground repairs using new replacement...
- Engine and engine cooling
- Equipment: electrical
- This informational bulletin provide information for the technicians to repair the rear window defroster...
- This warranty bulletin clarifies the use of dealer empowerment to satisfy the customer.
- Canadian Customers Unable To Place Calls And Turn By Turn Inoperative In The United States.
- XM Audio Traffic And Travel Link Availability And Operation.
- Equipment: electrical: radio/tape deck/cd etc.
- This information bulletin provides the dealers on how to submit a product information report.
- Summary to be provided on a future date.
- Ignition Key Removal
- Equipment: electrical: radio/tape deck/cd etc.
- This information bulletin provides the technician the information on how to properly clean a metal surface...
- This informational bulletin provides information on what products GM has to aid in the eliminating...
- Vehicle Recalls
- Equipment: electrical: radio/tape deck/cd etc.
- Equipment: electrical: radio/tape deck/cd etc.
- Programming And Activation Of Replacement OnStar Modules.
- This informational bulletin advises the technician to update the Onstar from an analog system to a digital...
- This informational bulletin provides the technician with information on what E85 fuel may due to a non E85...
- This informational bulletin is to assist with the identification of issues that are not considered...
- This informational bulletin explains condensation in exterior lights and replacment guidelines for...
- Equipment: electrical: radio/tape deck/cd etc.
- Electrical system: software
- Canadian Customers Unable To Place Calls In The United States
- Information On Requests To Add OnStar Bluetooth Option.
- Electrical system: software
- Refinishing Aluminum Wheels
- Equipment
- Underbody Component Corrosion The following information may be helpful when addressing underbody component...
- This informational bulletin provides directions on submitting different PIRs
- This informational bulletin provides information on how to save fuel and proper maintenance without using...
- Equipment
- Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
- Electrical system
- This informational bulletin provides information on key codes security rules and information on GM key...
- This informational bulletin provides information for Engine Squealing Type Noise on Start-up or Vibration...
- This informational bulletin provides a revision for 11-00-89-005D to add additional Mandatory Minimum...
- This informational bulletin provides a revision for 05-08-48-001B to add 2010-2014 model years and update...
- Electrical system: instrument cluster/panel
- This technical bulletin provides Warranty Administration
- This technical bulletin provides a revision of 99-04-20-002G to add 2013-2014 model years.
- This warranty administration bulletin provide policy information on clarification of use-dealer...
- This informational bulletin provides information on the appearance of chromed aluminum wheels due to...
- Electrical system
- This warranty administration bulletin provides information on the Clarification of Use for Dealer...
- Electrical system
- Engine and engine cooling
- This informational bulletin provides information regarding the aftermarket device interference with onstar...
- This informational bulletin provides a step by step procedure on how to properly use the GM chemicals to...
- Power train: axle assembly
- This informational bulletin provides a description of the proper wheel installation and proper wheel...
- This warranty administration bulletin provides information regarding customer concerns not duplicated and...
- This informational bulletin provides information and rules for GM keycode look up applicationa dn the key...
- This informational bulletin provides a single point reference and strategy document to aid in reducing...
- Service brakes
- This warranty administration bulletin provides information on what should be considerd warranty damage or...
- Electrical system
- Equipment adaptive/mobility
- This warranty administrational bulletin provides information on Clarification of Use
- Gm: there are seat belt problems: difficulty latching and unlatching buckle
- General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger...
- Gm: there may be noise coming from the cylinder head, because of low oil pressure which is caused by debris
- Normal operating characteristics of electric power steering (EPS) system during extended lock-to-lock...
- Saturn service campaign: new special reimbursement policy for vehicles equipped with variable transmission...
- General motors corp: special coverage adjustment; analog onstar deactivation.
- Buick cadillac chevrolet gmc hummer oldsmobile pontiac saab saturn service campaign: special coverage...
- Daytime running lamps (DRL) inoperative (inspect/replace drl resistor)
- Saturn service campaign: ignition control module - replace on vehicles equipped with 2.2L 4 cylinder (rpo...
- Trailer, recreational and disabled vehicle towing information
- Parts update - timing chain tensioner design change
- Information on servicing vehicles using new ignition start switch housing (ignition lock module) without...
- Low oil pressure - inspect oil filter for damage
- Reduced vehicle power, no transaxle down shift, ses light on, buzz noise from door speakers/speakers...
- Hesitation on acceleration after internal engine repairs - check injector harness orientation
- Remanufactured VT25E transmission quality issues
- Rattle noise from front of vehicle at slow speeds on rough surfaces when brake pedal is not applied
- Transmission fluid leak from right hand axle seal area
- No movement in drive or reverse with or without diagnostic trouble codes (DTCS) P1758, P1758, P1882,...
- Transaxle slips, no third gear, engine flare during shift after transaxle service
- Service engine soon (SES) light and severe engine misfire on cylinders 1 and 4 or cylinders 2 and 3
- Anti-lock braking system (ABS) light on diagnostic trouble code (DTC) C0551 after replacing the ebcm
- Trailer, recreational and disabled vehicle towing information
- Information on identifying proper design level and torque spec change for front lower control arm
- Fuel nozzle shuts off intermittently or prematurely during fuel fill and/or ses lamp on with DTC P0446...
- Driveline characteristics for all-wheel drive (AWD) and four-wheel drive (4WD) systems
- Rear suspension torque specifications
- Vibration from 30 mph or faster felt in the drivers seat or floorboard area
- Service information regarding saturn rear drum wheel cylinder inspections
- Intermittent no movement in drive or reverse with or without diagnostic trouble codes
- Service engine soon telltale illuminated with diagnostic trouble code P0742
- Intermittent hesitation during vehicle launch
- Service manual update - lower control arm ball stud nut torque specification changes
- Fuel filter replacement
- Recreational and disabled vehicle towing information
- Vehicle does not shift or move after running for a period of time and/or check engine light is on and DTC...
- Service manual update-wiper/washer systems schematics
- Replacement of rear lateral link assemblies
- Rear toe cam adjustment nut for service applications
- Service engine soon (SES) lamp illuminated with DTC P0135 HO2S heater circuit performance bank 1 sensor 1...
- Crank no start, hard start, stalling, or front lamps intermittently inoperative setting any of the...
- Service engine soon (SES) and/or reduced power lamp illuminated, limited throttle response following cold...
- Engine flare during 2-3 shift, most noticeable during light to moderate acceleration
- Service information regarding engine support during removal of right front engine mount assembly
- Check engine light on with P0440 or P0442 stored
- Revised VT25E (VTI) spacer plate available
- Vibration felt in seatback or armrest at vehicle speeds between 48 to 89 km/h (30 to 55 mph)
- Service information regarding a pop/clunk noise from the rear of the vehicle on initial cold start and/or...
- Return form for compact discs (CDS) or digital versatile discs (DVDS) that are stuck in cd player when...
- Oil life system reset procedures-trucks
- Squeak noise from front inner door armrest/pull handle
- Information on proper mode switch setting (between defrost and heater/defrost) to prevent window moisture...
- Service manual update for engine block clearance, cylinder head clearance and fastener torque specifications
- Heater-ventilation-air conditioning (HVAC) hiss-type noise
- Anaerobic sealant application requirements for VT25E transaxle
- Rattle noise from steering column
- Saturn field product reminder- vehicle fix it right the first time issues, parts restriction information...
- Service manual update for rtv sealant usage on the rear drive module
- Oil leak from front cover seal during extremely cold weather
- Blue smoke at engine start-up
- Low volume ticking noise, radio volume resolution or cd will not load/eject
- Wind and/or whistle noise coming from the outside rearview mirror
- Service manual update - hood opening procedure for inoperative hood latch
- Special policy adjustment - extended transmission warranty coverage for the variable transmission with...
- Service support and technical assistance for onstar and/or XM radio
- Squeak noise from front of vehicle
- Drone noise between 50-75 mph (80-120 km/h)
- Speedometer fluctuation
- Oil leaks from engine after sub-freezing temperatures
- App sensor 2 and/or tp sensor 2 signal circuit voltages drop
- No reverse after case cover assembly replaced
- No forward or reverse gears or line pressure after a valve body replacement on a VT25E transaxle
- Delay into reverse or no reverse after valvebody replacement
- Ses illuminated engine miss/misfire feel or rough idle
- No selection fir saturn when programming a saturn vehilcle
- Pop noise from engine area during heavy throttle input
- On-board diagnostic (OBD) system software upgrade
- Inoperative HVAC rear defrost, recirc, or air condition (AC) mode switches and/or reduced or no airflow...
- Compact discs (CDS) skip in single cd player
- Squeak or squeal noise while turning vehicle
- Service information regarding 2002 and 2003 model year VT25E transaxle replacement with 2004 model year...
- Headlamp assembly lens with hazy or cloudy cosmetic appearance
- Fluid dripping on driver's floormat
- Remote keyless entry (RKE) transmitter range poor
- Service information regarding transaxle poor performance after case cover replacement, diagnostic trouble...
- Service information regarding design change to the manual transmission shift control housing and the...
- Changes to the AM/FM stereo and audio disc player radio on-board diagnostic modes and cd load operation
- Malfunction indicator lamp (MIL) service engine soon telltale lamp on, reduced power lamp may illuminate...
- Oil filter cap assembly and oil filter element design change
- Service manual update - revised air conditioning compressor does not operate (chart 6 ) diagnostic flow chart
- Service manual update for air conditioning evaporator temperature sensor performance - chart 11
- Service manual update for VT25E (VTI) transmission front differential carrier thrust washer
- Clarification of labor codes used for reprogramming vehicle controllers
- Idle vibration at idle and/or clunk at start-up
- Service information regarding front suspension struts and front stabilizer bar links service parts update
- Revised 2.2L engine control module J1 & J2 connector face diagram
- Revision to second coast clutch disassemble/assemble procedure
- Six-disc radio will not load, eject and/or play compact discs (CDS)
- Crank no start after backfire or rough run/high idle after engine start
- Timing chain design change and revised service procedures
- Service manual update on transaxle oil cooler flushing procedure for vti transaxles
- Insufficient air conditioner cooling during periods of high humidity
- Windshield washer nozzles do not spray washer fluid
- Defrost mode not clearing condensation in lower right and left corners of windshield
- Service manual update - revised torque specification for VT23E (VTI) transaxle variable driven pulley...
- Left front door power window will not go up or works intermittently
- Service manual update for VT25E (VTI) transmission fluid pump pressure relief valve
- Noise from upper steering column behind steering wheel
- Service manual update regarding the use of saturn special tool J-42065 crank hub holding tool
- Service manual update for removal of the sealer used on oil pump gasket during oil pump installation
- Enhanced automatic transaxle fluid fill procedure and plug location/ identification
- Inside rear view mirror compass will not display all 8 compass directions
- Condensation forming on the instrument panel (i/p) top cover and i/p accessory bezel
- VT25E (VTI) transaxle off-vehicle repair authorization
- Vibration with the transmission in park when parked on an incline
- Armrest angled down on front driver or passenger seat when seat is in upright position
- Buzzing, grinding, or growling noise or vibration from rear of vehicle when fuel pump is running
- Front seat cushion cover lower edge loose due to broken cushion drawstring
- Insufficient heat, service engine soon (malfunction indicator lamp) telltale on, diagnostic trouble code...
- Due to a design change in the door and liftgate latching system, a second design latch kit is used to...
- Service information regarding the engine control module (ECM) connector and terminal locations on saturn...
- Shudder/vibration in reverse
- Intermittent whistle/chirp noise from engine compartment
- (MIL) service engine soon telltale illuminated with diagnostic trouble codes (DTC) P0171 and/or P0174
- The fuel gauge is displaying a false low reading or stuck on empty
- Transaxle shifter cable whine noise
- Service manual update for 2002/2003 vue chassis service manuals regarding front and rear alignment...
- 2002 model year VT25E transaxle replacement with 2003 model year VT25E transaxle
- Information on removal of luggage carrier rail assembly bolts strip out and / or heads break off when...
- Foam gasket material protruding out and around outside door handle base
- Hiss / chirp noise in park or neutral
- Excessive noise from (one speed) engine cooling fan at idle
- Fluid dripping on driver's floormat
- Harsh garage shift, shift delay and / or double bump
- Front carpet edge exposed near front door hinge pillar garnish molding
- Service information about first and second design brake pipe flares, updated service procedures and new...
- Grinding / rattle type noise coming from transaxle
- Liftgate outside handle gasket is protruding out between the handle and base
- Clunk pop or click noise when transitioning between acceleration and deceleration
- Subject regarding powertrain vibration at idle with the air conditioner on and transmission in reverse or...
- Service information regarding elimination of auxiliary water pump and instructions to install 2ND design...
- Powertrain vibration at idle with the air conditioner on and transmission in reverse or drive
- Subject regarding service information on transaxle assembly replacement program
- Subject regarding starter remaining engaged after engine start up and/or electrical accessories being...
- Subject regarding clunk noise while driving vehicle in reverse
- Subject regarding noise from front of vehicle while turning (modify the rosebud fastener and install...
- Subject regarding clunk pop or click noise when transitioning between acceleration and decelration (torque...
- Subject regarding clutch master cylinder assembly part number change
- Subject regarding service information regarding installation of 12V accesory outlet to left rear interior...
- Some consumers may complain of a squeak noise coming from the driver or passenger seat back when pressure...
- Subject regarding recreational and disabled vehicle towing information
- Fuel gauge is displaying a false low reading or stuck on empty
- Subject regarding HVAC module condensation leak into driver and passenger side footwell area- seal heater...
- Subject regarding idle vibration at idle and/or clunk at start up
- Subject regarding service manual update for chassis service manuals regarding front and rear alignment...
- Subject regarding rear seat shoulder belt comfort guide kit
- Malfunction indicator service engine soon telltale is illuminated
- Information pertaining to on-board diagnostic software upgrade
- Information on engine flare during 2-3 upshift
- Subject pertaining to sunshade not lowering or rotating to foward most position
- Some customers may comment the rear seat cushion cover is baggy or loose along the bottom edge
- Service manual update for 2002 body removal and installation service manuals regarding revised headlamp...
- Service manual update for 2002 body removal and installation service manuals regarding removal and...
- Service information on VT25-E transaxle assembly replacement program
- Subject regarding on-board diagnostic (OBD) software upgrade - unable to communicate with ECM using...
- Subject regarding creaking noise from rear of vehicle while driving (replace and secure all four...
- Subject regarding on board diagnostic (OBD) system improvements-scan tool inspection/maintenance (i/m)...
- Subject regarding service manual update for body removal and installation service manuals regarding...
- Malfunction indicator lamp service engine soon tell tale is illuminated with diagnostic trouble codes...
- Subject regarding rear seat cushion cover loose with drawstring cut
- Subject regarding on board diagnostic (OBD) software upgrade - unable to communicate with electronic...
- Subject regarding engine flare during 2-3 upshift during pre- delivery inspection (PDI) road test (install...
- Subject regarding sunshade not lowering or rotating to forward most position
- Subject regarding service manual update for body removal and installation service manuals regarding...
- Subject regarding front suspension struts and front stabilizer bar links service parts update
- Subject regarding service information on new oil cooler cover sealant
- Subject regarding onstar system unable to send or receive cellular phone calls
- Subject regarding squeak/itch noise from front seats
- Service information regarding onstar communication and interface module (CIM) programming
- Service manual update for 2002 body electrical diagnostic service manuals regarding AM/FM stereo with...
- Subject reagarding service manual update for body electrical diagnostics service manuals regarding AM/FM...
- Some consumers may complain of a squeak/itch noise coming from the front seat(s) when moving right or left...
- Service manual update for 2002 engine service manuals regarding fuel level sender and float
- Some customers may comment about a rattle or tapping noise coming from the steering column shroud area
- Some customers may complain about a creaking noise coming from the right or left rear of the vehicle while...
- Some customers may comment about a ratle or tapping noise coming from the steering column shroud area
- Some customers may comment about a creaking noise coming from the right or left rear of the vehicle while...
- Subject regarding service manual update for transaxel service manuals
- Subject regarding service manual update for chassis service manuals regarding differential housing support...
- Subject regarding service manual update for chassis service manuals
- Information on service manual update for powertrain and engine service manuals regarding evaporative...
- Subject regarding verification of proper installation and torque of rear seat belt shoulder guide anchor bolts
- Information regarding service manual update for restraints and chassis service manuals regarding...
- Service information regarding engine exchange program (us only)
- Information regarding essential tool package
- 2002 model year essential service tool update #1 and storage rack system information for vue essential tools
- Service information on california vehicle code requirements regarding 2002 modelyear tire chain disclosure...
VIN decoder
See the problems and recalls for an exact car
Buying a used 2002 Saturn Vue?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history