2021 Subaru Outback: windshield cracks

Filed Oct 14, 2024 · Visibility · CA

Since owning this vehicle, we have replaced the windshield at least once a year. The first due to a 1/16th inch chip that evolved into a 10 inch crack over the course of a day. The second was a crack from driver side pillar that appeared overnight, no chips prior. Third was a 8" crack from passenger pillar that appeared overnight while garage parked, after a day, it grew to reach the center of the windshield. I think it's unacceptable that windshields can just crack overnight less than a year after install. It's beyond concerning knowing that our windshield could crack at anytime, or that superficial chips must be taken care of IMMEDIATELY or we run the risk of replacing the entire windshield.

Filed Jun 11, 2024 · Visibility · AL

Windshield cracked under heat from parking in sun. The windshield spontaneously cracked when wiper fluid was turned on after parking on hot (85F) day. The whole windshield spidered indicating it is under extreme stress.

Filed May 29, 2024 · Visibility · AL

The windshield developed a crack. It initially started with what appeared to be a small rock impacting the bottom of the windshield where the wipers rest on the glass. The area of impact was the size of a small rock. A crack started forming and going upwards towards the roof of the car. Due to the heat in Alabama, the crack grew from 3 inches to approximately 9 inches. No safety features have been effected. I do commute 160 miles total for work, daily, so a crack that large necessarily creates a dangerous driving situation.

Filed May 9, 2024 · Visibility · CA

The windshield has cracked now, unprovoked for the second time in the exact same way it did 2 years ago. I came out to my car and it was parked, and the same crack it had 2 years ago was visible on the windshield. A crack starting from the passenger side that travels to the middle of the windshield. I have heard about many other Subaru drivers having this issue and their windshield cracking the exact same way. The first time I had it replaced I took it to the dealership and had to pay, and they replaced it with OEM glass.

Filed Apr 8, 2024 · NY

The windshield is very light and delicate. I have had two cracked windshields in less that two years, Also, the glass is so soft that it gets tons of micro-pits from sand. At night they each disperse lights and make it difficult to see.

Filed Mar 15, 2024 · Visibility · CA

Chipped windshield quickly progressed to full crack, which necessitated windshield replacement.

Filed Feb 8, 2024 · Visibility · CO

I'm on my 3rd windshield in under 12 months. I have not changed my driving habits and have been in typical weather for my area. The vehicle is garage kept. First windshield had a center driver's side ding that lasted all winter. We had some unseasonable spring weather changes that caused it to crack and spiderweb replaced 4/10/23, 24K miles. 2nd windshield, cracked 5/15/23, got dinged at the bottom and spiderwebbed immediately, again on driver's side. 3rd windshield, 12 inch line center passenger side from the edge, no ding or chip, no obvious cause for crack, occurred 1/28/24.

Filed Dec 28, 2023 · Visibility · WA

Windshield randomly developed a crack for no apparent reason. No rocks flying in, no extreme conditions, we were in 40-60 degrees temperatures in California on normal freeways and streets, not in any off-road conditions.

Filed Dec 22, 2023 · Visibility · 23,000 miles · CA

The contact owns a 2021 Subaru Outback. The contact stated that upon approaching the vehicle, she became aware that the front windshield had suddenly cracked, extending from the center of the windshield to the passenger’s side bezel. The vehicle was taken to the dealer, who determined that the crack was the result of the impact of a small, unknown object. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 22V712000 (Visibility), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 23,000.

Filed Dec 10, 2023 · Visibility · CA

Windshield developed a 10" crack overnight, parked while it was snowing in Boulder, CO. There was no damage prior to this past night. This problem is widely reported on [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 24, 2023 · Visibility · GA

Just purchased this vehicle certified pre-owned 2 months ago. Car was parked and spontaneous windshield crack started on drivers' side and has now advanced up through drivers visual field. A simple google search shows this to be a chronic, documented issue with MANY Subaru vehicles. Driving is limited and this is a costly fix for a fault not on the consumers end. I have contacted warranty and consumer protection before I call to schedule a replacement. ZERO problems or damage to vehicle before this, car wasn't in motion and as evidenced by photos it had no physical compromise causing this.

Filed Aug 17, 2023 · Visibility · MO

When driving on Interstate Highway 44 at approximately 45mph the windshield suddenly cracked on the lower passenger side of the vehicle. There was minimal traffic at the time of the incident and the roadway ahead was clear.