Gear shift will not change all the time. Have to sit and wait for possible change. Until it stops all together
The worst 2006 Suzuki Aerio problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Brakes7
- Airbags5
- Engine4
- Acceleration2
- Body2
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Brakes7
- Airbags5
- Engine4
- Acceleration2
- Body2
- Seat belts2
- Tires2
- Electrical1
- Fuel system1
- Steering1
- Suspension1
- Transmission1
- Visibility1
Recalls 1
Power train: manual transmission
- What is wrong
- On certain vehicles equipped with 5-speed manual transmissions, due to improper shape of the clip, the retaining clip that keeps the gear shift cable attached to the gear shift lever can contact the gear shift lever housing if excessive lateral force is applied when shifting to first gear.
- Risk
- Repeated shifting in this manner can eventually cause the retaining clip to break. If the retaining clip breaks, the shift cable can become disconnected from the shift lever, resulting in loss of the ability to change transmission gears.
- Remedy
- Dealers will replace the gear shift cable retaining clip with a clip that has a different shape. The recall began on august 13, 2007. Owners may contact american suzuki at 1‑800‑934‑0934.
Recall number 07V307000 · Recall details
Technical service bulletins for the 2006 Suzuki Aerio 6
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Reminder of the importance to conduct safety inspections for rust damage to suspension and related parts...
- This Service Bulletin was sent by Suzuki Motor Corporation to its authorized Suzuki automobile...
- Suzuki: parts list for repairing manual transaxle 5TH gear concerns such as popping out of gear while driving
- Malfunction indicator lamp on; diagnostic trouble code P0456 (evaporative emission system leak detected). tt
- ECM software may incorrectly set DTC P0441 (evaporative emissions system incorrect purge flow) on vehicles...
- Abnormal rear tire wear
2006 Suzuki Aerio fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 2.3L 4‑cyl | FWD | 22 | 28 | 24 |
| 2.3L 4‑cyl | 4WD | 21 | 26 | 23 |
What 2006 Suzuki Aerio owners say
Most recent owner complaints, unedited.
Tl* the contact owns a 2006 suzuki aerio. The contact stated that while driving approximately 65 MPH, the front passenger side seat belt became abnormally tight and caused welts to the passenger's neck. The contact also noticed that the air bag warning light was illuminated continuously and a message that indicated that the passenger side air bag was deactivated. The problem recurred multiple times. The vehicle was taken to an independent mechanic and they were unable to reset the air bag light and informed the contact that the seat belts needed to be replaced. The manufacturer was not notified of the failure and the approximate failure mileage was 47,000.
Airbag warning light stays on. Purchase this vehicle new in 2006. Dealer refuses to repair, no warranty to cover defects. Thought that this problem were isolated, but is very wide spread.
Tl* the contact owns a 2006 suzuki aerio. The contact stated that while driving approximately 25 MPH, the vehicle exhibited unintended acceleration which caused the engine rpms and the speed to increase. The contact indicated that the defect recurred on multiple occasions. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the defect. The failure mileage was 29,403.
The airbag light stays on and the 'passenger airbag off' light will not turn on. I see there are similar problems in other models from suzuki.
Tl* the contact owns a 2006 suzuki aerio. The contact stated that while driving approximately 35 MPH, the vehicle increased acceleration. The vehicle failed to slow down after applying the brake pedal numerous times. The accelerator pedal remained in a stuck position. The contact shifted the gear into neutral in order to stop. The vehicle was coasted to the side of the road. The vehicle was towed to an authorized dealer who stated the accelerator pedal was entrapped by the driver's side floor mat. The engine was completely damaged due to the opened throttle defect. The vehicle was not repaired. The manufacturer was not notified of the problem. The approximate failure mileage was 50,000. The VIN was unavailable. Updated 01/09/13
Air bag light on dashboard stays on;when reported to dealership,I was advised that this indicates"air bags would not deploy in case of an accident";dealership(suzuki courtesy in pittsburgh pa)rejects any responsibility for defect and would not take care of this issue free of charge); never had any accidents with car,but if "air bags will not deploy"statement is correct,I am concerned for the safety of anyone driving this car in my household. I have found many similar complaints on the internet database and feel that the federal safety agency should look into this problem; current mileage;37000;car was purchased new in 2006. Thank you!
Tl*the contact owns a 2006 suzuki aerio. The contact took the vehicle in for an oil change; after the check engine light illuminated which the contact noticed while driving 50 MPH. He took the vehicle to a mechanic who recommended that the engine area be cleaned. The vehicle was not repaired. The failure and current mileages were approximately 30,000.
Suzuki aerio 2006. Steering wheel has become loose and can cause loss of control of vehicle. Dealer what me to pay for repair. I was told that some vitara's had the same problem.
Tl* the contact owns a 2006 suzuki aerio. He front brakes have been changed every 2,000 miles since purchase. The brakes wear down to the metal. This condition causes the calipers to fail. He speculated that the calipers were designed too large for the brake system. A technician from the dealer has not stated that since the vehicle was out of warranty they can not provide any assistance. The current mileage was 32,867. The failure mileage was 5,000.
Compare the 2006 Suzuki Aerio
Other model years
Questions about the 2006 Suzuki Aerio
Is the 2006 Suzuki Aerio reliable?
Owners have filed 27 complaints about the 2006 Suzuki Aerio, 1.2 times a typical Aerio model year.
What is the 2006 Suzuki Aerio year score?
The 2006 Suzuki Aerio scores 68 out of 100 (average). The score compares it with the other model years of the Suzuki Aerio: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2006 Suzuki Aerio?
Brakes, with 7 complaints. Next is airbags (5).
How many recalls does the 2006 Suzuki Aerio have?
1 recall, covering power train.
What gas mileage does the 2006 Suzuki Aerio get?
Official estimates for the 2006 Suzuki Aerio range from 23 to 24 mpg combined. The most efficient version (2.3L 4-cyl, FWD) gets 22 city and 28 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Suzuki Aerio?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history