Tesla Model 3 no deployment problems

Filed Sep 3, 2026 · Airbags, Brakes · 119,730 miles · NJ · crash · 2 injuries

The contact owned a 2020 Tesla Model 3. The contact stated that while driving 50 MPH in traffic on a sunny day, the vehicle drove over a pothole, and the traction control and ABS warning lights illuminated. The brake pedal was checked; however, fifteen minutes later the vehicle crashed into a 26-foot box truck. The contact stated that the box truck left the scene of the crash. The tire skid marks were 100 feet long. The air bags failed to deploy. The contact stated there was an electrical failure which caused the brakes to become inoperable. Additionally, the alerts were late. The contact stated that the battery might need to be replaced. The driver and his daughter, who was seated inside the vehicle, sustained back pain, whiplash, and knee injuries. The driver was transported by ambulance. Medical attention was provided. The contact stated that surgery might be needed in the future. The daughter was taken to the hospital, and medical attention was provided. A Police report was filed. The vehicle was towed to an auto body shop. The EDR was requested on the manufacturer website. The failure mileage was approximately 119,730.

Filed Apr 27, 2026 · Brakes · AZ · crash · 3 injuries

The Tesla was hit on the passenger side by a Honda civic that ran a red light traveling more than 25 mph The Tesla spun 180 degrees after impact. No airbags deployed. Immediately after impact the Tesla turned on hazard lights. However the vehicle would not come to a stop after pressing on the brakes. After impact the vehicle was coasting backwards at probably less than 5-6 mph. It would not respond to brake presses. Oddly the vehicle had regen braking enabled which should have brought it to a stop, but it didn’t. The vehicle kept coasting backwards as if it was in neutral for about 20 meters until it hit a curb and stopped. BRAKES WOULD NOT WORK!!!

Filed Apr 21, 2026 · Airbags, Seat belts · MA · crash · 2 injuries

I was involved in a rear-end collision while stopped at an intersection. The impact was significant. During the crash, the front airbags did not deploy. More importantly, the seat belts in both front seats (driver and front passenger) failed to function as expected. Instead of tightening during impact, the seat belts appeared to loosen, allowing excessive forward movement of the occupants. As a result, I was thrown forward and struck the steering wheel. The lack of seat belt pretensioning raises serious concerns about a potential failure of the vehicle’s restraint system. This incident suggests that the seat belt pretensioners and/or related crash detection systems may not have activated properly under a significant collision event. I am concerned that this represents a safety defect that could increase the risk of injury in a crash. I request that this incident be investigated as a possible failure of the restraint system, including seat belt pretensioners and crash sensing mechanisms.

Filed Mar 31, 2026 · Airbags, Driver assistance · NC · crash

The components involved are the automatic emergency braking (AEB) system and the airbag system. During the collision, the AEB system did not activate, and the airbags did not deploy. The vehicle is available for inspection upon request. I was driving on a main roadway with no stop signs or traffic controls in my direction when another driver entered from a side street with a stop sign and pulled directly in front of me. I was unable to avoid the collision, and my vehicle was struck the other vehicle. The failure of the AEB system to engage and the airbags not deploying increased the risk of injury to myself and could have posed a risk to others involved. The issue has not been reproduced, and it has not yet been confirmed by a dealer or independent service center. The vehicle has been inspected by police and insurance representatives. The other driver was determined to be at fault. I am in the process of addressing the incident with the manufacturer. There were no warning lights, messages, or prior symptoms indicating any issue with the braking or airbag systems before the collision.

Filed Dec 16, 2025 · Airbags · CA · crash · 1 injury

Air bags did not deploy during crash. It is available for inspection upon request My face smashed into the steering wheel resulting in black eyes, swollen nose, cuts on my face and a concussion. Yes, the airbags clearly did not deploy during crash No No

Filed Nov 18, 2025 · Airbags · 88,894 miles · CA · crash · 1 injury

The contact owns a 2018 Tesla Model 3. The contact stated that while driving at approximately 30 MPH through an intersection, another vehicle t-boned the driver's side from the driver's side front bumper to the rear passenger door. The contact stated that the air bags did not deploy as intended. Medical attention was needed after the contact sustained lower back, left shoulder, neck, tailbone, and internal bleeding injuries were sustained. A police report was filed. The vehicle was taken to a collision center, where it was currently pending an inspection. The manufacturer was not notified of the failure. The failure mileage was approximately 88,894.

Filed Oct 29, 2025 · Electrical · 12,300 miles · WA · crash

The contact owns a 2025 Tesla Model 3. The contact stated that while coming to a stop at a traffic light, the vehicle’s autopilot system became inoperable, and the vehicle unexpectedly accelerated up to approximately 13 MPH without any warning lights illuminated. The contact attempted to regain control of the steering; however, due to the failure, the vehicle collided with another vehicle, resulting in severe damage to the driver’s side rear quarter panel, wheel, and tire. The contact stated that the air bags did not deploy during the incident. No injuries were sustained, and no medical attention was required. A police report was not filed. The contact expressed concern that the vehicle may present a potential safety hazard, as the failure had recurred on multiple occasions when attempting to drive the vehicle. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 12,300.

Filed Oct 16, 2025 · Brakes · 49,000 miles · NJ · crash · 1 injury

The complaint was filed on behalf of the contact's daughter. The contact's daughter owned a 2020 Tesla Model 3. The contact stated that while the contact's daughter was driving at 35 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the contact's daughter stated that the brake pedal felt spongy and unusual. The contact's daughter stated that the brake pedal was depressed to the floor; however, the vehicle still did not stop. The contact's daughter enabled the emergency braking system; however, the vehicle still did not stop. The contact's daughter beeped the horn to alert the nearby driver, and the dash cam independently activated. The contact stated that because of the failure, the contact's daughter's vehicle rear-ended the vehicle in front of the contact's daughter's vehicle. The air bags did not deploy. The contact stated that after the crash, the emergency braking system failure warning light was illuminated. The vehicle was towed to a local tow yard. The vehicle was condemned as a total loss by the insurance company. A Police report was filed. The contact's daughter was treated at the local hospital on the following day. The contact's daughter sustained headaches, whiplash, and a concussion. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,000.

Filed Oct 9, 2025 · Electrical · 111,725 miles · NJ · crash

The contact owns a 2019 Tesla Model 3. The contact stated that his wife was driving approximately 30-40 MPH at night with Full Self-Driving(FSD) mode engaged. The contact stated that the driver was exiting the highway to merge onto another highway that would close intermittently. The contact stated that the driver briefly looked at the navigation screen, and the vehicle suddenly crashed into the first highway closure gate, and the windshield shattered. The vehicle then crashed into a second highway closure gate. The contact stated that the Full Self-Driving(FSD) mode failed to operate as needed to prevent the collisions. The driver was able to stop the vehicle by depressing the brake pedal. The vehicle stopped in the middle of the highway, and there was no oncoming traffic. The contact's daughter was occupying the front passenger's side seat during the incident. The driver called 911, and the police officers arrived at the scene. A police report was filed, but the police report number was not available. The air bags did not deploy. There was no injury sustained. The vehicle was towed to a tow yard, where it was under evaluation. The contact related the failure to the federal safety agency Action Numbers: PE25012(Electrical System) and PE24031(Electrical System). The contact attempted to contact the manufacturer via phone, but the manufacturer was unreachable. The vehicle was not repaired. The failure mileage was 111,725.

Filed Oct 9, 2025 · Driver assistance, Electrical · CA · crash

Vehicle self drove took quick into an off ramp and took flight on cattle guard into a pole. The vehicle never attempted to make a emergency stop and no air bags deployed