2016 Tesla Model X brakes problems

Filed Jul 19, 2026 · Acceleration, Brakes · WA

I was driving the vehical when something went wrong. The vehicle showed a warning stating "ABS disabled". I was worried by this, when I saw further warnings appear including "Safety restraint system issue" "Power braking assist reduced" and something about steering. The dashboard also showed "Park Brake fault" and a red icon with a seatbelt and another with an airbag. Alarmed, I pulled to the side of the road. I then discovered that I could not use the parking brake or turn on the flashers. There is no manual parking brake, and the car thought it was still driving. I was facing downhill and the only way to keep the car from rolling was to keep my foot on the brake. I had to call 911 and could only safely exit the vehicle, after they had ensured it would not roll. Again, I could not exit the vehicle, or even put on flashers to warn traffic. Tesla attempted to have me reboot the operating system but this also failed -- apparently there is no manual reboot or brake avalible.

Filed Jan 23, 2026 · Brakes, Driver assistance · FL

2016 Tesla Model X experienced Electronic Parking Brake failure with alerts stating ‘parking brake did not release.’ Tesla is charging for replacement despite known EPB defect and recall affecting 2016 Model X vehicles. This is a safety-related braking issue.

Filed Jan 11, 2026 · Brakes · NY

While driving a notification popped up, parking brake may not be applied while driving. This notification appears in rain or snow making me think it is weather related malfunctioning.

Filed Feb 27, 2025 · Brakes · IL

My 2016 Tesla Model X (VIN [XXX] ) was manufactured in March 2016 according to the sticker on the driver door. My car is experiencing the same issue as the Tesla Service Bulletin #SB-17-33-002 under the federal safety agency's recall # 17V2600 when putting the vehicle into drive or reverse from park. Tesla is stating they can not perform the service work because there is no recall specifically for my VIN# even though the car is showing the same error messages on the diagnostics screen and showing the same symptoms and failure as the recall and service bulletin. The repair requires the replacement of the parking brake calipers which is a safety issue if not replaced which could result in not properly functioning when needed. The vehicle is available for inspection. The vehicle displays warning messages not to drive the vehicle, the parking brake is not released and could cause damage to the brake pads if driven, and to take to the Tesla service center. Tesla is proposing the same repair and solution as the recall / service bulletin and wants to charge me $1,500 for something that should be under the recall, especially since my car was manufactured during the specified timeline of Feb 2016 to Oct 2016 and should fall under the safety issue with the same issue as the recall. This recall needs to include my VIN # and any Model X built during this timeframe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 27, 2024 · Brakes, Electrical · TX

I initially brought my vehicle to the Tesla Service Center in Richmond, Texas, to address issues involving the motor. During this visit, I was informed that mismatched tire sizes and worn parts in the front end were contributing to the problem. The service center proceeded with repairs, charging me for the work. However, the original issue persisted after I picked up the vehicle. Despite multiple follow-up appointments and additional repairs, the problem was never resolved.

Filed Dec 27, 2024 · Brakes, Electrical · TX

To Whom It May Concern, My name is [XXX] , and I am writing regarding unresolved issues with my 2016 Tesla Model X (VIN: [XXX] ). Despite multiple service visits, extensive repairs, and approximately $8,000 in costs, my vehicle remains undrivable and presents significant safety concerns. I initially brought my vehicle to the Tesla Service Center in Richmond, Texas, for motor-related issues. I was informed that mismatched tires and front-end components were contributing to the problem, and repairs were completed. However, the original issue persisted. Subsequent visits for additional repairs also failed to resolve the problem, and new safety concerns emerged. Complicating matters, the Richmond Service Center has since closed, and its staff were terminated. When I contacted the Westchase Service Center, Manager Andrea P. informed me that no resolution or agreement could be reached. I have attached the following invoices for your review: Invoice #[XXX], dated April 26, 2024 Invoice #[XXX], dated November 9, 2023 I am requesting the following: A full review of my service history and unresolved issues. Immediate repairs to address motor and safety concerns at no additional cost. A clear explanation of Tesla’s policies regarding unresolved repairs, especially with closed service centers. This situation has caused financial and personal hardship. I urge Tesla to address these issues promptly to restore my confidence in your brand. Please contact me at [Your Phone Number] or [Your Email Address] to discuss this matter. Sincerely, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 31, 2024 · Brakes · VA · crash

On May 30, on a 55 mph highway, my Tesla Model X was traveling at highway speed in thick traffic. The vehicle was using cruise control, but not auto pilot. In other words, the auto steering function was not engaged. A vehicle that the Tesla Model X was following came to a sudden, unexpected stop. I applied the brake pedal with full force. The anti-lock brakes engaged and the brakes began pulsing (normal anti-lock brake behavior). However, while the brake pedal was depressed with full force, the anti-lock brakes stopped pulsing and the brake pads disengaged from the rotors. The car coasted as if the brake pedal was not depressed. The brake failure resulted in a frontal collision with the stopped vehicle. A police report was filed at the scene of the crash. There were no physical injuries and the Tesla Model X was driveable after the incident. However, the car that was struck had significant damage (but no bodily injuries). Because the Model X was driveable, I attempted to recreate the incident 12 hours later. However, as I tested the brakes, they behaved normally. With the fully depressed brake pedal, the antilock brakes stayed active until a full stop of the vehicle. Is it possible that the frontal collision system malfunctioned? As the frontal sensors detected an impending crash, did the car's computer disengage the brakes mistakenly? The car had no warning lights prior to May 30. However, at the exact time of the crash, two codes were registered. (I used the Tesla service mode to access them). One code states the anti-lock brakes were active. The second code registered exactly 2 seconds later and states "Pedestrian safety system fault". There is a police report, but we have not received it yet. I had to check NO in the form because the form would not allow me to move forward unless I uploaded the report. I can upload the police report when I receive it.

Filed Dec 28, 2023 · Brakes, Driver assistance · IL

Display MCU1 is unsafe or at end of life and unsafe locks up goes dark and unresponsive for long periods of time, unable to drive sometimes my my car is under warranty either they should fix it or upgrade it, I was told I need to upgrade it but my car is still under new car bumper to bumper warranty either fix it or replace it, if MCU1 doesn’t work then replace it with MCU2 and honor the new car bumper to bumper warranty

Filed Dec 17, 2023 · Brakes, Driver assistance · IL

I had an interaction with this vehicle on snow/ice packed I70 in Colorado, almost to the Kansas border. This car passed me, then immediately cut in front of my truck in the right lane and quickly slowed to about 10 mph with no warning. The car then pulled over onto the snow packed shoulder.

Filed Aug 8, 2023 · Brakes, Driver assistance · NC

the autopilot was engaged and the system failed, it james the breaks hard and it started scraping the body above the tire