2016 Tesla Model X steering problems

Filed Jul 19, 2026 · Acceleration, Brakes · WA

I was driving the vehical when something went wrong. The vehicle showed a warning stating "ABS disabled". I was worried by this, when I saw further warnings appear including "Safety restraint system issue" "Power braking assist reduced" and something about steering. The dashboard also showed "Park Brake fault" and a red icon with a seatbelt and another with an airbag. Alarmed, I pulled to the side of the road. I then discovered that I could not use the parking brake or turn on the flashers. There is no manual parking brake, and the car thought it was still driving. I was facing downhill and the only way to keep the car from rolling was to keep my foot on the brake. I had to call 911 and could only safely exit the vehicle, after they had ensured it would not roll. Again, I could not exit the vehicle, or even put on flashers to warn traffic. Tesla attempted to have me reboot the operating system but this also failed -- apparently there is no manual reboot or brake avalible.

Filed Apr 29, 2026 · Steering · CA · crash

The rack-and-pinion system failed, causing steering to become difficult at low speeds and worsening rapidly over weeks. It was inspected by a mechanic at EV Coastal in Santa Ana, who said it was not the U-Joint or bolt corrosion issue addressed by an earlier the federal safety agency recall. There were no notifications either visible to me or to the mechanic in service mode. The accident was at low speeds and a partial cause was my daughter's difficulty making a smooth adjustment with the steering wheel. She was pulling out of a parking spot and collided with a car going a little faster than it should have in a parking lot. Fortunately, the damage was limited to a scratch to the passenger side door of the other car (see photo) and scratches to the right side of the front fender of the Tesla.

Filed Mar 20, 2026 · Steering · AL

I don't think Tesla ever did the steering bolt recall per SB-20-32-002 on my vehicle. I had all the bolts fail, with obvious corrosion, and the motor separated from the rack causing a loss of power steering while moving. You can see where the bolt physically failed and the corrosion both on the remainder of the bolt and the entire mating surface of the motor to the steering rack. Going back through my service records, it is only listed once on 9 June 2021 with notes of "Parts not available" hidden in the comments. Tesla is telling me this was done, with comments about a January 2021 visit, but I never took it to them in January (I did in February) and the February visit has no mention of the recall. Regardless, one of two things happened: either Tesla didn't do the recall and I fell victim to the issue or the recall was done and the new, updated bolts still failed due to corrosion and exposure to a corrosive, winter environment. I still suspect the former for the reason that no visible evidence of the protective wax coating required by the TSB could be seen on the motor or steering rack. Perhaps they swapped the bolts but didn't apply the wax, which allowed for continued corrosion? I won't know for sure until they continue with the repair, but I'm worried they are going to toss the parts and sweep this under the rug and foot me with the full bill. Regardless, I want this documented that I had a failure despite the recall so that any other owner with a similar problem can see this record.

Filed Jan 27, 2026 · Steering · 80,000 miles · CA

The contact owns a 2016 Tesla Model X. The contact stated that while driving during a rainstorm, the power steering assist feature suddenly failed, and the steering wheel became difficult to turn in either direction. The driver was able to forcefully turn the steering wheel and drive the vehicle a short distance to the residence. The vehicle was later towed to the local Tesla Service Center who diagnosed that the steering rack circuit board had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 20V062000 (STEERING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 80,000.

Filed Oct 28, 2025 · Steering · MI

There is a u joint problem that is reported in many model x vehicles especially in the 2016 models. The steering stiffens and make is very difficulty to maneuver .

Filed Oct 11, 2025 · Steering · CA

While driving, the steering suddenly failed — the wheel spun freely with no response from the front wheels. This occurred at a stoplight shortly after exiting the freeway; had it happened minutes earlier at highway speed, it could have caused a serious crash. The vehicle was towed to a Tesla Service Center, which confirmed an under-torqued and stripped bolt on the intermediate steering shaft connecting to the steering rack. The steering column module, shaft, and rack were replaced. This was the second major steering incident in six months. In April, the same part had seized, making the steering extremely stiff. Tesla replaced the intermediate shaft then, but immediately after pickup, the car veered sharply left and triggered a traction control alert. Only after I returned did they perform an alignment and test drive. That means the first repair was released to me without a post-repair safety check. The October failure involved the same component, suggesting negligent workmanship or a recurring defect in the steering connection. Total loss of steering control represents a critical safety hazard that could lead to loss of life. I strongly believe this issue warrants an investigation and possible recall.

Filed Sep 8, 2025 · Steering · LA

The steering is stiff and hard to turn this is the second time this has happened. It happened last year around this same time. I took to Tesla service in New Orleans for repair and they said they cleaned the bolts and reconnected the line. And now the car is experiencing the same issue

Filed Jun 17, 2025 · Steering, Suspension · CO

In March of 2025, my steering of the model X became really stiff. As time went on, the problem became worse and no longer able to turn left or right without major force. I made an appointment with Tesla and took it in for servicing. At this time they changed the steering bolts and steering shaft April 23, 2025. This cost $489.70 (I will attach invoice). As soon as I picked up the vehicle my steering wheel was about 30% stuck to the right. I immediately sent a picture to tesla for them to conduct an alignment and fix the issue. They fixed the issue but around May 15th, I had a nail in my tire so I took my car in to fix it. At that time I find out that the tires on my car were exposed to the wire (I will add the picture of the tires). I replaced these tires on March 1st 2025 which is only 2 1/2 months since I replaced it. It was an indication that something is wrong so I make another appointment with Tesla to check it and get another alignment I dropped off car on June 3rd. Tesla tried to perform another alignment to find that they are not able to because the steering gear assembly needs to be replaced. I asked for clarification because I just fixed the steering components in April and they are now wanting $4900 for the steering gear assembly. As I was researching, I find that my model x was produced on May 2016 and there is a recall for Model x produced before Oct 2016 for the steering bolt and steering components if they are damaged. When I tell tesla that there is a recall they say that my vin is not associated with the recall. I am filing a complaint because my car is with in the period of vehicles produces in the recall. There is a huge safety issue if the steering bolt and steering gear assembly is malfunctioning. There were no warning lamps or messages to indicate this. This has put my family and other vehicles at risk and Tesla is aware of this problem but won't honor the recall or admit that the steering issue are all related.

Filed Mar 19, 2025 · Steering · OH

I had cruise set at 60mph on 2 lane highway. Their were rumble strips in center as well as edges of the road. I approached 2 slow moving vehicles (adaptive cruise was on) and then used turn signal, took over control myself disabling adaptive cruise. I pulled back in across the center mark after passing vehicles. When i crossed the 12" wide center rumble strip my car immediately threw up a message on the screen and i could barely turn the wheel to prevent the car from driving into the ditch on my projected path back into my lane. The car got straight finally but the wheel was nearly impossible to turn. A few miles later, I approached my ramp to take and slowed down to 15mph under the ramp limit and it took nearly everything to get the wheel to turn 15 degrees to make my turn. i pulled off very slowly into a graveyard right off the road and parked the car. i took pictures of the messages on the screen "EPAS_w002 Steering may require increased effort" on the center screen and the similar message on the center screen "Steering assist reduced steering may require increased effort". I did a computer reboot (hold 2 buttons on steering wheel), left the car with my key and locked it ad walked away for a minute. I reapproached the car, it unlocked, and i turned the car back ON. Everything worked when i got on the highway with the exception of Autosteer (beta). It would not set, so i disabled it on the center screen. I turned it back on this morning (next day) and it is fully functioning again. I do not know how i didn't end up in the ditch at highway speeds, but i feel this needs reported and a solution found before I or someone else loses steering. I'm not sure the center rumble strip had anything to do with it or if it was coincidental, but the car always does a shimmy when you cross rumble strips in the center of the road (switching lanes) regardless of speed.

Filed Mar 13, 2025 · Driver assistance, Electrical · MA

Hi, My steering wheel turning very hard even though the federal safety agency issued the the recall last month but your website says your vehicle is not on recall. Also my rear camara is working still Tesla said needs to be replace again even though Tesla replace in 2023 which is I paid. My autonomy is not working even though I paid $8000 plus $500 tax when I purchase my model X in 2016 for full self driving/ Tesla doesn't want to honor this to us. Hopefully the federal safety agency put my vehicle in recall list. Thanks for you help. Best regards