2023 Tesla Model Y: ball joint or control arm failure

Filed Oct 25, 2026 · Steering, Suspension · GA

Noticed a clunking noise from the front of car. Put in a service request via the Tesla app. It said it was fin to drive and made an appointment for 2 weeks later. 1 week later, there was a very loud noise and settling of the car. 2 bolts were on the ground and the left front wheel lost steering control. The bolts secure the lower control arm. This would have been catastrophic if it had occurred while driving.

Filed Oct 20, 2026 · Suspension · 29,000 miles · MD

The contact owns a 2023 Tesla Model Y. The contact stated that upon pulling out of the driveway, there was an abnormal screeching sound coming from the vehicle. The contact stated that extra effort was need to steer the vehicle to the left. After turning the steering wheel to the right, the vehicle dipped several inches. Upon exiting the vehicle, the contact became aware that the front upper control arm was hanging down due to a loosened bolt. Due to the failure, the vehicle towed to a Tesla Service Center. Upon speaking to a technician at the Service Center, the contact was informed that the dealer had never heard of the failure. Upon investigation, the contact discovered and associated the failure with the federal safety agency Action Number: PE26006 (Suspension). The vehicle remained with the dealer. The failure mileage was approximately 29,000.

Filed Oct 8, 2026 · Suspension · MN

Repeated creaking from the front suspension over bumps, speed bumps, and railroad tracks on nearly every drive. The noise was present by about 66,800 miles; exact onset unknown. No warning lights or messages appeared; the noise was the only symptom. On 09/14/2026, at 68,092 miles, a Tesla service center inspected the steering and suspension and found worn ball joints on both front lower lateral links, torn bushings on both front lower compliance links, and worn ball joints on both rear knuckles. Tesla recommended replacing these parts plus a 4-wheel alignment. The parts are still on the vehicle and available for inspection. The front lower lateral link is the component under the federal safety agency investigation PE26-006 (lateral link detachment on 2021-2023 Model Y). Worn ball joints on that link at under 70,000 miles raise the risk of it separating while driving, which could cause a loss of directional control. No detachment, crash, or injury has occurred. I asked Tesla to cover the front lateral link repair because of the open investigation. Tesla declined, calling these wear-related items outside warranty or campaign coverage, so the repair will be at my own expense. I believe this premature wear may be an early stage of the detachment the federal safety agency is investigating.

Filed Oct 3, 2026 · Steering, Suspension · CA

I began hearing a squeaking noise coming from the front of my 2023 Tesla Model Y. While pulling out of a parking lot at a low speed, the front left control arm failed and the bolts came out. When the failure occurred, the vehicle suddenly steered to the left. Fortunately, I was traveling at a very low speed when this happened. I am concerned that if the same failure had occurred while traveling at freeway speeds, I could have lost control of the vehicle and potentially been involved in a serious accident. Tesla has since repaired the vehicle. After this incident, I researched similar failures and found multiple reports from other Tesla Model Y owners describing control arm/suspension components or associated fasteners coming loose or separating. I am reporting this because I am concerned this may represent a broader safety issue with the Model Y suspension system.

Filed Sep 2, 2026 · Suspension · CA

Front lateral control arm bolt spontaneously loose and about to fall out causing front tire noise and unstable drive/steering. May have caused severe damage/accident if happened at high speed but fortunately we discovered this while driving at low speeds. Car only has 33K miles. No warning lights. Upon inspection other front control arm bolts loose and not tight. Dealer inspection scheduled and pending.

Filed Sep 1, 2026 · Suspension · FL

Driver-side front suspension is creaking and popping when turning the steering wheel, particularly at low speeds. Noise appears to be coming from the left-front suspension. Vehicle needs inspection of the driver-side front upper control arm/ball joint, lateral and compliance links, bushings and associated suspension components for wear or excessive play.”

Filed Sep 1, 2026 · Suspension · 32,000 miles · FL

The contact owns a 2023 Tesla Model Y. The contact stated that while the babysitter was attempting to park the vehicle, the front driver’s side control arm detached from the vehicle with a loud pop. No warning light was illuminated. A dealer was contacted. The vehicle was towed to the dealer but was not yet diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and sent the tow service. The approximate failure mileage was 32,000.

Filed Aug 27, 2026 · Suspension · CA

What component or system failed or malfunctioned, and is it available for inspection upon request? The front driver-side control arm came loose after two bolts fell out. The vehicle had no prior accidents, and the failed area can be inspected if needed. How was your safety or the safety of others put at risk? The front driver side of the car suddenly dropped onto the wheel while I was backing into a parking spot. If this had happened at highway speed, it could have caused a very serious accident, loss of control or potential death. Has the problem been reproduced or confirmed by a dealer or independent service center? The problem was confirmed after the vehicle was inspected and the two missing control-arm bolts were identified. The car was not safe to drive after the failure. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle was inspected after the incident by a service center or mechanic. It has not been inspected by the manufacturer, police, or insurance unless otherwise noted. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lights, messages, or noticeable symptoms before the failure. It happened suddenly while I was backing into a parking spot.

Filed Aug 27, 2026 · Steering · CA

The bolts on the control arm came loose on its own while driving causing the steering to become unstable and loud.

Filed Aug 17, 2026 · Suspension · TX

Both the right (April 2024) and now left (Aug 2026) upper control arm bolt became loose. The left created damage. Now I routinely check the bolts and now on a check on the right it loosen naturally freely spinning by hand. Caught the right bolt early before damage and serious safety issue. Note this is a wide issue and the federal safety agency should issue a wider recall as Tesla argues about repairs and doesn’t take this seriously. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 16, 2026 · Acceleration, Electrical · CA · crash

COMPONENT/SYSTEM THAT FAILED: The service brakes failed to stop the vehicle. While reverse-parking at low (parking) speed, I applied the brake pedal and the vehicle did not stop as expected, resulting in contact with an object and vehicle damage. The vehicle is available for inspection upon request; it has been preserved and driven only minimally since the event. HOW SAFETY WAS PUT AT RISK: The brakes failed with no warning. Had a person been behind the vehicle, the failure to stop could have caused injury. This is the only vehicle for a family with three children who are regularly transported in it, and I no longer feel safe driving them. REPRODUCED/CONFIRMED BY A DEALER OR SERVICE CENTER: Not yet. INSPECTED BY MANUFACTURER/POLICE/INSURANCE/OTHERS: The insurer opened and then denied the claim and stated that no vehicle telemetry/data was available to preserve. No independent forensic inspection has occurred yet. Police did not attend. WARNING LAMPS/MESSAGES/SYMPTOMS PRIOR TO FAILURE: NONE. There was no warning light, no alert message, and no audible signal before or during the event. The parking sensors did not beep as they normally do. No ABS or brake warning light appeared at any time before or after. ADDITIONAL RELEVANT DETAIL: Approximately one week earlier, the front lower control arms were replaced. It is UNKNOWN whether the ABS wheel-speed sensor or related wiring was affected; the vehicle displayed no related warning at any time. No injuries occurred.

Filed Aug 12, 2026 · Suspension · NY

I am experiencing a loud, persistent creaking and groaning noise coming from the front suspension of my 2023 Tesla Model Y whenever the vehicle travels over bumps, uneven road surfaces, or during low-speed steering maneuvers.This structural front-end noise raises immediate safety concerns regarding a potential premature failure of critical suspension components, specifically the front lower lateral links or upper control arm ball joints. I am deeply concerned that this component wear could lead to a sudden detachment of the suspension link while driving, resulting in a sudden loss of steering control and an immediate crash hazard.Tesla is aware of widespread suspension issues in these model years, but there is currently no active safety recall to protect owners from catastrophic part failure. I am filing this to urge a mandatory safety recall before a serious failure occurs. I have just over 63,000 miles