Our rv refrigerator ignited causing a fire in the back of the unit. If we had not been home, our rv would have been completely destroyed. Two days following this incident we received a recall letter from dometic warning of a possible fire danger. However, the unit that we have was not listed in the recall, but the fire occurred exactly as described in the recall letter. Our attempts to contact dometic have gone unanswered for two weeks. ( ie email and telephone.) this incident required that we turn off the propane used to heat our rv. Therefore not only do we not have a refrigerator, we are unable to use the gas heater. Information should be forthcoming from the company and it is not.
The worst 2004 Tiffin Phaeton problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
Recalls 5
Equipment: recreational vehicle/trailer
- What is wrong
- Tiffin motorhomes is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
- Risk
- The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
- Remedy
- Tiffin motorhomes is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The safety recall began on february 17, 2011. Owners may contact norcold at 1‑800‑767‑9101.
Recall number 11V082000 · Recall details
Equipment: recreational vehicle/trailer
- What is wrong
- Tiffin is recalling 3,507 my 2004-2007 allegro, allegro bay and allero bus, my 2004-2005 phaeton and my 2005-2007 zephyr motor homes equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- Risk
- Release of coolant under certain conditions could ignite and result in a fire.
- Remedy
- Tiffin will be working with dometic in order to repair these refrigerators (please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or tiffin at 256‑356‑8661.
Recall number 08V509000 · Recall details
Equipment: recreational vehicle/trailer
- What is wrong
- On certain motor homes equipped with a two-door refrigerator manufactured by the dometic corporation, these refrigerators may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- Risk
- Release of coolant under certain conditions could ignite and result in a fire.
- Remedy
- Tiffin motorhomes will be working with dometic in order to repair these refrigerators (please see 06e076). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or tiffin at 1‑256‑356‑8661.
Recall number 07V517000 · Recall details
Equipment: recreational vehicle/trailer: lpg systems: water heater
- What is wrong
- On certain class a motor homes equipped with vehicle systems' aqua-hot and hydro-hot water heaters, which use webasto burner tubes, the burner tubes do not meet specifications and could fail prematurely.
- Risk
- The surface temperature of the exhaust tube exiting from the heater can increase and could potentially ignite combustible materials in or around the vehicle.
- Remedy
- Tiffin is working with vehicle systems to notify owners and have the repair performed on their vehicles. Owners may contact vehicle systems at 1‑800‑685‑4298 or tiffin at 256‑356‑8661.
Recall number 05V268000 · Recall details
Seat belts: front: buckle assembly
- What is wrong
- The seat belt assemblies on certain motor homes fail to comply with the loop load requirements of federal motor vehicle safety standard no. 209. "seat belt assemblies."
- Risk
- The seat belt buckle may unlatch in the event of a vehicle crash, possibly resulting in personal injury to the seat occupant.
- Remedy
- Amsafe will replace the buckles. Owners should contact amsafe at 574‑266‑8330 or tiffin at 1‑256‑356‑8661.
Recall number 04V383000 · Recall details
Technical service bulletins for the 2004 Tiffin Phaeton 12
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- CSA-043 fccc
- This was a letter to our dealers we sent out when we first heard of the Kidde fire extinguisher recall,...
- Tiffin motorhomes: TSB contains notification of owner letter. select document search button below. two...
- Rv: instructions on how to install the charge solenoid wiring in a rv or vehicle. ta
- Tiffin motorhomes: TSB contains notification of owner letter. select document search button below. all...
- Tiffin motorhomes: exhaust tip and pipes to the muffler on phaeton models needs to be installed. ta
- Tiffin motorhomes: TSB contains notification of owner letter. select document search button below. some...
- Tiffin motorhomes service campaign: a wire is not hooked up and needs to be. the navigational system will...
- Tiffin motorhomes: there is a potential problem with the water heater by pass in your unit. there is a...
- Tiffin motorhomes service campaign: switch box grounding lug. the tap screw is not tight enough. this...
What 2004 Tiffin Phaeton owners say
Most recent owner complaints, unedited.
Compare the 2004 Tiffin Phaeton
Other model years
20012003200420052007200820092010201120122014201520162017201820192020202120222025
Questions about the 2004 Tiffin Phaeton
Is the 2004 Tiffin Phaeton reliable?
Owners have filed 1 complaint about the 2004 Tiffin Phaeton, fewer than a typical Phaeton model year.
What is the most common problem with the 2004 Tiffin Phaeton?
There are not enough complaints to tell.
How many recalls does the 2004 Tiffin Phaeton have?
5 recalls, covering equipment and seat belts.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Tiffin Phaeton?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history