2004 Toyota 4RUNNER airbags problems

Filed Dec 29, 2025 · Airbags, Body · MO · crash · 1 injury

What component or system failed or malfunctioned, and is it available for inspection upon request? Response: Frame, Suspension, Airbags / Yes it is available for inspection. How was your safety or the safety of others put at risk? Response: Safety was put at risk due to frame & suspension failure due to severe rust. Also due to failure of deployment of AirBags. Rusted Frame Failure subsequently caused safety of Injured Party and other motorists to be at risk due to the Injured Party’s 4Runner to dart across oncoming lane of traffic with no warning other than a swaying motion felt immediately before losing control. Once the Injured Party lost control of the 4Runner it crossed into oncoming traffic, progressing into the drainage ditch on the oncoming traffic side of highway. Once the 4Runner impacted the drainage ditch at a 90° angle, the 4Runners momentum dispersed by causing the 4Runner to overturn 3 times landing on its wheels in the adjoining field. Has the problem been reproduced or confirmed by a dealer or independent service center? Repaonse: Independent Service Center has confirmed the problem with the Rusted Frame, Rusted Suspension, and Air Bag failure. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Response : Yes Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Repaint: No warning lamps prior to failure. Symptoms indicative of failure were an unknown minor swaying sensation while driving. Injured party was under the impression that there may have been a tire low on air, which was discovered to be incorrect later.

Filed Oct 20, 2021 · Airbags · NM

Side curtain shield airbags.

Filed Sep 10, 2021 · Airbags · 238,000 miles · TN · crash · 1 injury

The contact owned a 2004 Toyota 4 Runner. The contact stated that the driver’s and front passenger air bags failed. The contact stated that when at complete a stop at the red traffic light, the vehicle in the rear failed to stop and crashed into the contact's vehicle rear-end, pushing the vehicle into the roadway. The driver’s and front passenger air bags failed to deploy and caused the front passenger's head to hit the dashboard, suffered injuries to the head, six broken back vertebrae, three broken ribs, head concussion. The contact was the driver and had no injuries to report. The front passenger who was her husband was airlifted to the hospital. The State Trooper mentioned that the other driver might have been on their phone however it was unknown due to them suffering fatal injuries. A police report was filed. The vehicle was towed. The contact advised that the vehicle was destroyed. The manufacturer was not contacted. The failure mileage was 238,000.

Filed Mar 25, 2020 · Airbags, Body · CA

Cracked dashboard risk of airbags deploying

Filed Nov 22, 2019 · Airbags · 180,000 miles · UT

Tl* the contact owns a 2014 toyota 4runner. While driving in reverse over a small bump, both frontal air bags deployed without warning. The vehicle was taken to larry h miller toyota murray (5650 s state st, murray, ut 84107, (801) 590-0640) and numerous failure codes were located. The vehicle was not repaired. The VIN was included in the federal safety agency campaign number: 16v065000 (air bags). The vehicle was unable to be driven. The manufacturer was made aware of the failure and provided case number: 10909230699. The failure mileage was approximately 180,000.

Filed Aug 27, 2018 · Airbags · 45 miles · GA · crash · 1 injury

The airbags failed to deploy upond impact from a tractor trailer. Car completely totaled.

Filed Jun 19, 2018 · Airbags · GA

Tl* the contact owns a 2004 toyota 4runner. The contact received notification of the federal safety agency campaign number: 16v065000 (air bags); however, the parts to do the repair were unavailable. The contact stated that the manufacturer exceed a reasonable amount of time for the recall repair. An unknown toyota dealer located in upatoi, ga was contacted and confirmed that the parts were not available for the recall remedy. The manufacturer was made aware of the issue and was not able to confirm when the parts were to become available. The contact had not experienced a failure. Parts distribution disconnect.

Filed Oct 14, 2017 · Airbags · TX

Tamara recall (airbags)

Filed Aug 10, 2017 · Airbags · CT

I had to schedule appointments to take the car to toyota because of the airbag defect.this happened twice once in 2013 and they said that there was no charge and than they charged me $346 and said it was to replace fluids...the second recall was in 2016 this time there was no charge.

Filed Mar 27, 2017 · Airbags · 136,000 miles · GA · 2 injuries

Tl* takata recall. The contact owns a 2004 toyota 4runner. When the contact started the vehicle, the four side curtain air bags deployed in the vehicle. The contact sustained neck injuries and the passenger sustained burns and cuts on the left side of his arm. The occupants did not require medical attention. There was no fire, crash, or police report filed. The vehicle was towed to the dealer, but was not diagnosed or repaired. The manufacturer was notified. An investigator inspected the vehicle. The contact was awaiting authorization for the repairs. The failure mileage was 136,000.