2004 Toyota 4RUNNER suspension problems

Filed Dec 29, 2025 · Airbags, Body · MO · crash · 1 injury

What component or system failed or malfunctioned, and is it available for inspection upon request? Response: Frame, Suspension, Airbags / Yes it is available for inspection. How was your safety or the safety of others put at risk? Response: Safety was put at risk due to frame & suspension failure due to severe rust. Also due to failure of deployment of AirBags. Rusted Frame Failure subsequently caused safety of Injured Party and other motorists to be at risk due to the Injured Party’s 4Runner to dart across oncoming lane of traffic with no warning other than a swaying motion felt immediately before losing control. Once the Injured Party lost control of the 4Runner it crossed into oncoming traffic, progressing into the drainage ditch on the oncoming traffic side of highway. Once the 4Runner impacted the drainage ditch at a 90° angle, the 4Runners momentum dispersed by causing the 4Runner to overturn 3 times landing on its wheels in the adjoining field. Has the problem been reproduced or confirmed by a dealer or independent service center? Repaonse: Independent Service Center has confirmed the problem with the Rusted Frame, Rusted Suspension, and Air Bag failure. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Response : Yes Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Repaint: No warning lamps prior to failure. Symptoms indicative of failure were an unknown minor swaying sensation while driving. Injured party was under the impression that there may have been a tire low on air, which was discovered to be incorrect later.

Filed Oct 20, 2024 · Body, Electrical · IL

Rusty frame undercarriage. It’s not going to get any better due to the fact I have to drive on hwy 80 with all the construction, that’s a hazard itself, potholes everywhere that puts stress on your frame and the salt every winter.

Filed Sep 22, 2024 · Body, Brakes · IL

UNKNOWN: Excessive frame rust. frame is excessively rusting to the point where the brakes and suspensions is connected to the frame has been compromised. brake lines rusted to the point of failure, thus almost causing a wreck. Vehicle is now parked due to safety concerns involving the excessive rusting that is happening to the frame and any components that is attached to the frame.

Filed Aug 22, 2024 · Suspension · HI

I recently bought a 2004 Toyota 4 Runner and the frame of the vehicle has significant corrosion to the extent of holes, weld failures and more. I've never seen frame rust so bad on a vehicle like this. I'm a little uneasy about the safety of this situation. I think Toyota should replace the frame or give a good discount on the part and labor. I hope someone can help me out with this concern.

Filed Jul 18, 2024 · Body, Suspension · IL

Cars frame is rotting out to the point it is not safe to drive. I was told being in a collision could cause catastrophic failure and the car is just turning 20 years old with 125,000 miles. Can’t get my money back and the car is otherwise is excellent condition.

Filed Jun 12, 2024 · Suspension · WI

Frame is severely rusted and has holes started at 40k miles

Filed Mar 22, 2024 · Body, Steering · MO

Took 2004 Toyota 4Runner SR5 to Toyota dealership to be serviced. Dealership called me to explain unable to do alignment, due to rear back frame excessive rusted through. Dealership advised waste of money to align new tires just purchased, unable to even do alignment and it was dangerous. Now what is to be done? This is my daily driver for work. How did this happen that its unsafe and dangerous to drive.

Filed Dec 28, 2023 · Suspension · MI

Excessive frame rusting. There are holes in the frame from rusting. At this point in time there isn’t anything I can do about the issues. Frame is unrepairable.

Filed Nov 9, 2023 · Suspension · OH

Entire frame of the vehicle is rotten with rust and holes. This vehicle has been inspected by McDaniel Toyota, Marion, OH 43302 and the damage was confirmed. I have been and must continue to drive this vehicle even though the dealership did not recommend it. No evidence of the extent of the rust and damage was not noticed until October 2023 when a strap on the gas tank came loose. Upon further inspection, he noticed the holes and rust all over the frame. Reported to Toyota because other 2004 Models were recalled for this issue. They were of no assistance.

Filed Oct 27, 2023 · Suspension · OH

Frame of this vehicle completely rusted through. Holes on passenger side right where the front door ends. Hole is approx 12" long. Frame also has a hole in the left front core support. Advised that the vehicle is no longer safe to drive by my Toyota Dealer and personal mechanic. . There were no indications of this until a few weeks ago when the gas tank strap had come off and the gas tank was leaning. When inspected, it was found the frame was in disrepair.