Toyota 4RUNNER headlights problems

Filed Aug 25, 2026 · Lights · FL

Driver side headlight goes out approximately every 6 months. Sometimes the light only has to be “wiggled” in its connection and the light comes back on. Sometimes the light must be replaced. The light has also exploded when my spouse was attempting to replace the lightbulb. A friend has a 2014 Toyota 4 runner and the drivers lightbulb has been replaced approximately 12 times in 6 years. The passenger side headlight is not affected.

Filed Jul 21, 2026 · Electrical, Fuel system · FL

The contact owns a 2025 Toyota 4Runner. The contact stated that the message “Headlights On” was erroneously displayed. The fuel gauge indicated 71 percent. Additionally, the 12-volt charging system malfunctioned with the message “See the Dealer” displayed. Several unknown orange warning lights were illuminated. The vehicle was restarted, and the warning lights turned off. The window on the passenger’s side was violently shaking. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure, but an undisclosed software was reprogrammed. The vehicle was taken back to the local dealer, where it was diagnosed and determined that the fuel pump was replaced. The vehicle was repaired. The dealer was contacted and informed about a diagnostic test. The manufacturer was contacted, and a claim was filed. The failure mileage was unknown.

Filed Jun 22, 2026 · Lights · OK

The interior of both headlights have the interior coating peeling in the first 20k miles

Filed Feb 6, 2026 · Visibility · NC

Windshield cracked approximately 2” from the bottom all the way across while using the defroster to clear ice from it. I was still parked at the time. I am unsure how long it will stay water tight or become worse. One concern is the crash avoidance and the automatic high beam sensor are both attached to the windshield and don’t want them to fail. I also don’t want the entire piece of glass to shatter and land in my lap while driving. The dealer refused honoring the repair under warranty. They only use one particular repair shop (which I suspect they own) and even quoted me a price for replacing the ruined glass. In addition to paying for that I would need to pay the dealer to recalibrate the crash avoidance and headlight sensor. I have yet to report the damage to my insurance. As of yet there are no warning lights showing.

Filed Nov 4, 2023 · Lights · IL

My brand new 2023 Toyota 4Runner has terrible head lights. I see I am not the first person to post this very same complaint either. These headlights NEED to be recalled and replaced by Toyota. I will do my best to describe this, but when driving in the dark there is large shadow cast on the left side of the throw of the lights. It is far in front of the car, just before the light tapers off into darkness. But it's not just that the headlights are uneven, I have light that surrounds the dark spot. So it's like I'm constantly chasing an animal. The 4Runner has a soft suspension, so every small bump in the road makes the shadow dance and it is incredibly distracting. It's all I look at. When I turn it looks like something is running across the road. This is a dangerous design. I live in Illinois and I drive to and from work in the dark 5 months out of the year. Everybody on the internet says it's for the safety of oncoming drivers. The shadow is nowhere near where somebody would be sitting in an oncoming driver seat. This problem is all over the internet. Why has nothing been done about it? The Toyota dealer told me it's be design, and so did the service manager. Toyota corporate referred me to the customer relations lead back at the dealer, who sent me back to corporate, who sent me to a senior advisor at corporate, who told me they have to respect what the dealer says. Round and round we go. I inquired if my dealer can take apart my headlights and remove the piece that casts the shadow out on the road. I bet you know the answer to that one. Never once have I seen this in any vehicle driven by myself, family or friends. Anybody I have had in the car has mentioned how distracting it is. These lights need an immediate recall and replacement. Thank you.

Filed Nov 2, 2023 · Lights · OR

Similar to NUMEROUS newer ('12+) vehicles, the instrument cluster gauge needles light up even when the headlights are not on. Therefore when driving the vehicle, the driver isn't aware that the headlights are NOT ON at night (and there are no DRL/daytime running lights to warn oncoming drivers), which means that the vehicle is driving at night WITHOUT any lights on. People are going to be killed this way; both the driver and innocent motorists driving near this vehicle. I nearly got in a head-on collision last night because the vehicle headlights weren't on after sundown (but I listed crash, fire, fatalities to get your attention, as I submitted this same issue about 8years ago for a similar incident with a Nissan Leaf that narrowly missed running me over as it was driving without any headlights on/LED gauge cluster was bright enough to see the drivers face, and NOTHING has changed in the auto industry for safety on this widespread issue). How can the automotive industry and the federal safety agency have let this happen? Instrument cluster gauges should not have ANY backlighting unless the headlight switch is physically activated by the driver. This issue is even worse with the new LED/virtual gauge cluster screens.

Filed Sep 27, 2023 · Lights · IL

The headlight pattern of the low beam lights has a large dark area at the 10 to 11 O'clock position that appears in the oncoming traffic lane when driving at night. This dark area is very distracting while driving at night. The area is approximately 1 to 2 meters in diameter when seen on the driving surface. It appears the headlights to not meet the photometric requirements for headlights. This pattern was first noticed when the vehicle was delivered by the dealer. I have contacted multiple dealers with no remedy. The dealer states that "pattern is by design."

Filed Aug 30, 2023 · Lights · IL

When using the low beams, there is a distinctive shadow or blotch that is evident on the driver's side only in the 2023 4 Runner Limited. I understand from others that it is due to the LED anti glare technology mandated to be used by the government. This shadow or blotch is NOT visible when using the high beams. When using the low beams the shadow is ALWAYS in the periphery or in front of the driver....but it is there at ALL times. As a driver, my eyes are drawn to it, taking my eyes off of the traffic or road ahead. On several occasions I have thought that it was an animal or something. I have had passengers in my vehicle who immediately noticed the same thing and thought that it was a terrible design and would pose a safety hazard. This shadow is NOT visible on the passenger side. I have notified Toyota USA and have visited the dealership several times. I have had the headlamp replaced with no resolution, so I went back to have the headlight adjusted up and it is still there. I have been told by Toyota USA and dealership that this is a 'characteristic' of the vehicle and has been designed this way and they will not do anything to resolve this issue. I have done quite a bit of research and understand other Toyota owners are experiencing the same thing. Here are a few other websites where owners are complaining of the same thing: [XXX] and [XXX] and [XXX] ). I feel that this characteristic is a defect or flaw that poses a safety risk since the driver's eyes are drawn to this 'spot' while driving at night using the low beams. I did not experience this issue with my previous 2014 Toyota 4-Runner. I really appreciate someone looking into this as I am contemplating selling my brand new vehicle because of it. I have video as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 6, 2023 · Lights · CA

The vehicle headlights have failed on multiple occasions. The cause of the failures was ingress of water into the sealed headlamp assembly. The problem was reported to Toyota. Toyota took no action regarding the reports. The entire headlight assembly was replaced three (3) times at our expense. The problem persists. Attached is a photograph of the second (replaced) clearly showing water inside the headlight assembly. The current (most recent replacement) has also experienced water ingress and is available for inspection. The subject vehicle was inspected by three different body shops (two if which are authorized Toyota shops). It was confirmed by all three shops that there is no vehicle design feature that could cause water ingress in the headlamp assembly. This is a serious safety issue and has been brought to Toyota's attention with no response.

Filed Jul 28, 2022 · Suspension · WV

Section of frame broke and fell to the pavement. Vehicle bouncing and went off road causing damage to front driver side bumper, turn signal light housing, headlight. Extensive Back frame rusting has made vehicle dangerous. Frame has many soft spots. Both back shocks rusted and broken. Replace shocks but frame will eventually brake. This is my only vehicle. So, I will continue to drive and pray that this vehicle stays together and doesn't result in death. Front frame and suspension are also rusted and rusting. Please help !