hello good afternoon my name is [XXX] I have a Toyota Tacoma 2005 could you help me with some information it has a chassis with holes and rotten. Toyota was changing all chassis that had this defect in 2018 to 2020 at no cost, the first owner didn't know about it and I wasn't even warned. I would like to know if I am entitled to a free chassis exchange? INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
2005 Toyota Tacoma body complaints
Page 2 of 10: complaints 11 to 40 of 260, newest first, as owners wrote them.
Hi, I have a 2005 Toyota Tacoma, the chassis is rusty and has holes in it. I went to complain at Toyota, they said the car didn't have a Recall but neither the first owner nor I had news that I would have to change the car's frame. I would like help to resolve this. all parts under the car are very rusty
My 2005 Toyota Tacoma had a recall due to potential frame rusting. I brought my Truck to my local Toyota Dealership for the frame inspection as stated in the recall notice I received. The frame did not need to be replaced and at a later date the frame was sealed per Toyota's remedy. In March of 2022 I had an issue with my truck that required the gas tank to be removed. As it turned out there was major rust to the frame that was located behind the gas tank that was never sealed during the original remedy to the frame rusting issue. I contacted Toyota about the issue and was told that the extended warranty for the Issue had expired. I was told to contact the local dealership. In conversation with the dealership I was told there was nothing they can do. I feel that if this issue has happened to my truck, there must be other trucks on the road with the same issue that the owners have no Idea what is happening to their frames that may cause a safety issue should the frame completely fail. My truck is available for inspection. Neither the dealer or Toyota inspected the Issue. I feel Toyota should have had the hindsight to have the dealers remove the gas tank and seal the frame behind the tank.
The contact owns a 2005 Toyota Tacoma. The contact stated that while his vehicle was parked, he noticed that the subframe was extremely rusted. The contact noticed a 10-inch crack on the inside driver’s side rear of the vehicle. The vehicle was taken to the dealer dealer and the contact was informed that the subframe needed to be repaired. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 170,000. Consumer stated rust is the worst near the catalytic converters. It is also bad just in front of the rear tires. It’s a manufacturer flaw where they designed the double wall to where water could get in but not get out and the frame rots from the inside out. This truck was garage kept.
The frame of my truck failed at the motor mount. The motor mount has sunk into the frame shifting the motor and effecting performance and other parts. This can be confirmed by anyone. I never received recall information, I can’t find evidence of one issued for this year or my state.
The contact owns a 2005 Toyota Tacoma. The contact stated while inspecting the vehicle, he noticed punctures and corrosion on the main subframe. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The contact stated that an unknown recall repair was performed to the subframe in August 2014. The failure mileage was approximately 255,000.
The vehicle was in the shop for service,the tec informed me it would not pass nys iinspection due to rust holes in the frame.
Frame has rust holes in it and will not pass next nys inspection.
Truck was taken in for coolant leak. Technician found the frame to be rusted through and was advised truck was no longer safe to operate. Truck was stationary in dealers repair bay.
Frame rusted severely. Have been advised it is unsafe to drive.
There was a recall on the frame and in 2015 my father-in-law owned the vehicle and had it inspected and all I know is it passed. He is deceased now and I own the vehicle and recurved notification about a recall on the rear springs so made an appointment and they told me that they couldn't fix the problem because the frame was to rusted to safely take springs off to replace. The frame recall has expired but the spring recall is still in effect. So I feel that to fix the safety issue they should fix the frame so that they can fix the springs to solve the safety issue. Any advice or help would be greatly appreciated.
I am the sole owner/purchaser of a 2005 tacoma. Last week a louisville, ky toyota dealer, oxmoor toyota, was replacing the rear u-joints and noticed rust and corrosion throughout the frame. It was so bad, the toyota technician considered it unsafe to drive. I have called toyota USA but they offered no assistance. What else can I do... There seems to be negligence and liability here. Thank you, [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Truck frame was inspected for rust damage by toyota in 2016 as part of a recall. Toyota found the frame to be sound and treated it with anti-corrosive material. Just four years later, the truck frame has rusted through in several spots making it unsafe to drive.
The frame of this tacoma is rusted and has significant holes, very unsafe. I have been told mixed messages by different toyota dealerships. The toyota dealership needs to take care if this recalled frame and stop telling me they do not cover mine. I will not accept the excuse of the recall has expired. It's their responsibility to fix this dangerous problem.
The frame is rusted through on the driver's side next to the catalytic converter. It has two rust holes that are connected with a crack that the rust is starting to widen. The holes are approximately 1-2 inches in size. I first bought the vehicle in 2013 at my home of record (minnesota) in-between duty stations. I'm active military and I'm stationed in north carolina. I deployed in 2017 and didn't get back until late 2018. In early 2019 stevenson hendrick toyota contacted me to have recalls performed on my truck. I took it in and they did the seat belt, throttle pedal, and load rating sticker. However, I was never informed that my framed was rusted through. I found out after I had to troubleshoot my o2 sensors. At which point I contacted toyota headquarters in regards to united states district court for the central district of california case no. 2:15-cv-02171-fmo-ffm to see if they would replace my frame or at least repair it; as I understood the timeframe had past that toyota would replace the frame. I explained to them that I never received any notification about this and that I was deployed as well during this time. Toyota still refuse to fix the frame. When I take the truck in to get serviced sometimes they turn me away; as they don't want to held liable because of the frame. For the price to replace the frame I can purchase a used vehicle. I should not have to dispose of my vehicle when it runs fine and is paid for. Since then I have tried to find someone with the expertise to repair my frame, but no one wants to do the repairs and possibly be held liable afterwards.
Tl* the contact owns a 2005 toyota tacoma. The contact stated that while driving, the vehicle pulled to the right. The vehicle was taken to an independent mechanic and was informed the chassis was bent and was to take the vehicle to a toyota dealer. The vehicle was not taken to a dealer and was not repaired. The contact stated that the chassis was previously replaced at toyota of bristol dealer, (3045 w state st, bristol. Tn 37620, (423) 212-4266), however the failure recurred and was not taken to a dealer and was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 264,488.
Tl* the contact owns a 2005 toyota tacoma. The contact took the vehicle to halterman's toyota (1741 paradise trail, east stroudsburg, pa 18301, (570) 273-9454) to have the brakes serviced. The mechanic pointed out that there were multiple holes found within the frame of the vehicle. The contact was informed that there was an unknown manufacturer recall on the vehicle and that it needed to be serviced. The contact was provided a rental vehicle and, after six weeks, the contact was informed that they did not have the part to repair the vehicle. The manufacturer was notified and referred the contact to the federal safety agency. The vehicle had not been repaired. The failure mileage was 167,000.
I bought a used 2005 tacoma in july of 2019. No frame issues were apparent at the time that I purchased it. The week after I bought it, I took it to the dealership to have recall work done on the leaf springs and seat belts. I asked the dealership service department to check out the frame because I had become aware of the frame service campaign. They told me that the deadline had passed in january of 2019 and that they couldn't do anything about it. I have since discovered much more troublesome frame corrosion and am concerned that the truck is not safe to drive.
2005 toyota tacoma frame is corroded and toyota refused to replace the frame.
Tl* the contact owns a 2005 toyota tacoma. While the vehicle was undergoing routine maintenance, the independent mechanic discovered that the frame was corroded. There were no warning indicators illuminated. Royal south toyota (3115 s walnut st, bloomington, in 47401, (866) 609-4926) was contacted and unable to assist. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 137,357.
Tl* the contact owns a 2005 toyota tacoma. The contact stated that there was a hole in the frame of the vehicle. The vehicle was taken to holman toyota (1301 nj-73, mt laurel township, nj 08054, (888) 632-3967) and they stated that there was a warranty enhancement program dated from 7/17/17 to 01/31/19. The dealer and manufacturer stated that during that time, they could have made the repairs; however, they could no longer assist since the warranty was expired. The vehicle was not diagnosed or repaired. The failure mileage was 140,698. *bf
Mechanic noted rust on frame. Contacted toyota, there was a lawsuit about premature rusting on frames, but settlement is done and there is nothing they(toyota) can do?
Exhaust system was in need of repair. Shop would not be able to fix because the frame is so rusted there is nothing left to attach new parts to. Shop showed me large holes in frame. Then advised me that I should not be driving it with the possibilities of breaking. Which I have heard happen to others. I have never received a notice or recall for this problem. The only recall that I have received and taken care of was the issue with the accelerator. This alarms me since I often have my children with me.
Tl* the contact owns a 2005 toyota tacoma. When the vehicle was taken to an independent mechanic for an oil change, the technician found that the front end frame was completely rusted. The dealer and manufacturer were not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 107,000.
We brought the truck in to have it checked for rust and corrosion that we seen, palmers airport toyota said they seen none, the a-frame has rusted and corroded to the point of snapping and the metal is corroded and peeling with a crack going around the whole a-frame. The truck is now not moveable, the whole tire will fall off if we do move it, we made it back to our home with it luckily and toyota corporate says there is nothing they can do.
The 2005 toyota tacoma bumper is mounted to the hitch. The hitch is welded to brackets that connect to the frame. The frame has been replaced with previous campaigns, however there is a severe safety issue with these hitches. Any tacoma with the bumper mounted to the hitch would be at risk of creating a hazard for other drivers. If I had been towing something with the hitch, it may have caused my vehicle to overturn and kill me or what I was towing could've separated from my vehicle and caused another accident. I called toyota and logged this complaint. The dealer and manufacturer both state there is nothing they will do to help me out. This is a $1700 hitch/bumper assembly replacement bill. I'll fix it of course on my own as a responsible driver that's concerned with my and other driver's safety. Unfortunately toyota doesn't seem to be concerned with people's safety on the roads. That's unfortunate.
2005 toyota tacoma. Consumer writes in regards to vehicle frame corrosion recall problems. *smd the consumer was awaiting settlement claims from the court. Updated 07/19/2017
Tl* the contact owns a 2005 toyota tacoma. While having the vehicle inspected, the contact observed corrosion on the frame. The vehicle was taken to local dealer (cox toyota 3860 danbrook road, burlington, nc 27215) where it was diagnosed that the frame had excessive corrosion and needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed the contact that a recall was sent out years prior. The contact stated that he was the original owner and never received notification of corrosion on the frame. The failure mileage was approximately 239,000. Updated 09/07/17*lj
Toyota frame recall - I have a 2005 toyota tacoma with holes and cracks visible in the frame. I can only imagine the damage internally to the frame. Huge chunks of frame rust come from the inside of the frame when pressure washed. The truck was originally purchased and resided in the northeast for the majority of the vehicle's life. The truck was obviously exposed to road salts and as a result the frame has been compromised. The toyota dealer must be aware of the history of the vehicle as the truck was serviced regularly at toyota dealerships and third party service centers throughout the northeast. In 2014 toyota tried to covered up the problem with a "rust inhibitor" which only hide the true damage on the frame. I recently took my truck to autonation toyota at 2555 colonial blvd, fort myers, fl 33907 phone:(239) 321-5413 for a different recall, the rear springs. I requested the frame be replaced under the recent toyota frame recall settlement and was simply ignored. I am currently driving my truck as a necessity knowing there may be a catastrophic failure at any time. Toyota has agreed in court to either replace or buy out the vehicles affected. My truck is a danger to myself and others on the road but I can't afford another vehicle. I have taken pictures of the affected areas of the frame as evidence of the damage. Please help!
Tl* the contact owns a 2005 toyota tacoma. Upon trading in the vehicle, the contact was informed that the frame was cracked and rusted. The vehicle was taken to the dealer where it was diagnosed that the frame was rusted and split and needed to be replaced. The vehicle was not repaired. The manufacturer was notified and referred the contact to the heffner group. The failure mileage was 26,000. Updated 06/27/17 *bf
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Toyota Tacoma?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history